NHTSA vehicle safety data

2006 Chrysler Voyager Recalls & Complaints

The 2006 Chrysler Voyager has 1 NHTSA recall campaign and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Chrysler dealer.

NHTSA recall and complaint data for the 2006 Chrysler Voyager. Recall data is refreshed daily from NHTSA.

2006 Chrysler Voyager owner complaints

Owners have filed 1 complaint with NHTSA about the 2006 Chrysler Voyager, describing incidents dated September 1, 2006.

Most-cited components

Structure 1 complaint

Newest complaints

ODI #10245066 · Filed October 10, 2008
CHRYSLER MOTORS LLC, MY CAR HAS BEEN LEAKING WATER INTO THE PASSENGER SIDE FLOOR FOR OVER 2 YEARS. DESPITE MANY TRIPS TO THE DEALER TO FIX IT, PHONE CALLS TO CORPORATE, AND LETTERS TO CORPORATE, MY CAR CONTINUES TO LEAK WATER AND MOLD CONTINUES TO GROW ON THE MAT. THE MOST RECENT SUGGESTION FOR…

Read the full complaint

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Chrysler Voyager in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP14-002: Engine Stall After Refueling
Closed April 6, 2015
Engineering Analysis EA11-010: Loss of headlight illumination
Closed November 29, 2012

Open and recently closed NHTSA defect investigations

CURVED TEMPERED AUTOMOTIVE REPLACEMENT GLASS

NHTSA #07E104000 · Visibility — Glass, Side/Rear · NHTSA notice

Reported December 11, 2007 · SAFELITE FULFILLMENT, INC.

Potentially affected: 1,657 vehicles

Owners notified January 15, 2008

Defect description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Manufacturer remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 Chrysler Voyager. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2006 Chrysler Voyager.

Structure

ODI #10245066

Incident: September 1, 2006 · Filed: October 10, 2008

CHRYSLER MOTORS LLC, MY CAR HAS BEEN LEAKING WATER INTO THE PASSENGER SIDE FLOOR FOR OVER 2 YEARS. DESPITE MANY TRIPS TO THE DEALER TO FIX IT, PHONE CALLS TO CORPORATE, AND LETTERS TO CORPORATE, MY CAR CONTINUES TO LEAK WATER AND MOLD CONTINUES TO GROW ON THE MAT. THE MOST RECENT SUGGESTION FOR REPAIR IS ONCE AGAIN TEMPORARILY FIXING THE SYMPTOM AND THE QUOTED COST THIS TIME WAS BETWEEN $600 AND $800. IT WILL NOT FIX THE CAUSE OF THE SYMPTOM WHICH IS DEBRIS GETTING INTO THE PAN AND THE HOSE. AFTER A FEW MONTHS DEBRIS WILL ACCUMULATE AGAIN AND I WILL HAVE TO HAVE IT CLEANED AGAIN, AND BE CHARGED AGAIN. THE REPAIR NEEDS TO ADDRESS THE CAUSE NOT THE SYMPTOM. MY CAR IS PARKED IN A GARAGE BOTH AT HOME AND AT WORK SO I DO NOT UNDERSTAND WHY I AM HAVING PROBLEMS TO BEGIN WITH. I LIVED IN THE SAME HOME FOR 15 YEARS AND WE HAVE HAD 4 OTHER CARS (ALL HONDAS, NEVER A CHRYSLER) AND HAVE NEVER HAD THIS PROBLEM BEFORE. CHRYSLER CONTINUES TO GIVE TEMPORARY, EXPENSIVE, SOLUTIONS THAT WILL NOT FIX THE CAUSE OF THE PROBLEM. WATER CONTINUES TO LEAK INTO THE PASSENGER SIDE OF THE CAR EVERY TIME THE AIR CONDITIONING OR THE HEAT IS ON. MOLD CONTINUES TO GROW. THE CAR CONTINUES TO STINK. MY KIDS AND I CONTINUE TO BREATHE THE BAD AIR. I CONTINUE TO PUT TOWELS OVER THE WETNESS SO THE MOLD SPORES DON'T CIRCULATE AS MUCH. I AM ASKING FOR CHRYSLER TO CARE ABOUT THE HEALTH HAZARD THEIR VEHICLE IS SUBJECTING MY FAMILY TO EVERY DAY. I AM ASKING FOR A REPAIR TO THE CAUSE OF THE PROBLEM TO BE PRESENTED, NOT A TEMPORARY REPAIR THAT WILL MAKE CHRYSLER MONEY OVER AND OVER AGAIN EACH TIME I AM BACK WITH WATER LEAKING INTO MY CAR. IN MY OPINION THERE IS A MAJOR DESIGN FLAW IN THIS CAR. SINCERELY, CORY WATSON *TR

Other Chrysler Voyager model years

Check your 2006 Chrysler Voyager VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chrysler Voyager at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chrysler VIN