NHTSA vehicle safety data

1999 Chevrolet Monte Carlo Recalls & Complaints

The 1999 Chevrolet Monte Carlo has 5 NHTSA recall campaigns and 125 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 1999 Chevrolet Monte Carlo. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1999 Chevrolet Monte Carlo owner complaints

Owners have filed 125 complaints with NHTSA about the 1999 Chevrolet Monte Carlo, describing incidents dated September 1, 1998 to January 2, 2019.

Most-cited components

Service Brakes 48 complaints
Engine 39 complaints
Electrical System 10 complaints
Power Train 7 complaints
Visibility/Wiper 6 complaints
Exterior Lighting 5 complaints

Of the 125 complaints on file, 5 report a crash and 6 a fire; across all 125 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11244983 · Filed August 19, 2019
RECALL
ODI #11170065 · Filed January 14, 2019
NO ANTI-LOCK BRAKES
ODI #11154913 · Filed November 30, 2018
FAN WANT COOL THE CAR WHEN STOP AT RED BREAKS WHEN FAST STOPING HAS SLOW GRIP TOO THEM

Read all 125 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 1999 Chevrolet Monte Carlo in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA02-030: ENGINE COMPARTMENT FIRES
Closed March 9, 2004
- Recall 04V-090

Open and recently closed NHTSA defect investigations

Engine Oil Dripping On Manifold may Cause Fire

NHTSA #15V701000 · Engine and Engine Cooling — Engine · NHTSA notice

Reported October 26, 2015 · General Motors LLC

Potentially affected: 1,003,556 vehicles

Repair completion: 38.23% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 15757 · Owners notified February 19, 2016 · Vehicles built May 1, 1997 – June 23, 2001 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Safety consequence

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Manufacturer remedy

The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

ENGINE COMPARTMENT FIRE

NHTSA #09V116000 · Engine and Engine Cooling · NHTSA notice

Reported April 8, 2009 · GENERAL MOTORS CORP.

Potentially affected: 1,497,516 vehicles

Manufacturer campaign 09047 · Owners notified April 9, 2009 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

Safety consequence

IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

Notes

GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AFTERMARKET FUEL PRESSURE REGULATORS

NHTSA #07E021000 · Fuel System, Other — Storage — Tank Assembly — Pressure Relief Devices · NHTSA notice

Reported March 12, 2007 · DELPHI

Potentially affected: 742 vehicles

Owners notified April 27, 2007

Defect description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Safety consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/PASSENGER AIR BAG MISSING CHECK VALVE PIN

NHTSA #02V329000 · Air Bags — Frontal · NHTSA notice

Reported December 9, 2002 · GENERAL MOTORS CORP.

Potentially affected: 272 vehicles

Manufacturer campaign 02061 · Owners notified December 16, 2002 · Vehicles built March 1, 1999 – June 30, 1999 (per NHTSA)

Defect description

ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.

Safety consequence

THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.

Manufacturer remedy

DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.

Notes

GM RECALL NO. 02061. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/WET BRAKE PERFORMANCE

NHTSA #01I014000 · Service Brakes, Hydraulic — Foundation Components · NHTSA notice

Reported September 24, 2001 · GENERAL MOTORS CORP.

Owners notified September 26, 2001 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.

Safety consequence

THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.

Manufacturer remedy

DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.

Notes

GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO MODIFY THE VEHICLE IF AN OWNER HAS EXPERIENCED A GREATER THAN EXPECTED REDUCTION OR DELAY IN BRAKING ON WET ROADS.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, CONCERNING THIS PROGRAM.

try.vin has no NCAP crash-test rating on file for the 1999 Chevrolet Monte Carlo. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

125 owner complaints have been filed with NHTSA for the 1999 Chevrolet Monte Carlo.

Engine

ODI #11244983

Incident: April 15, 2015 · Filed: August 19, 2019

RECALL

Service Brakes

ODI #11170065

Incident: January 2, 2019 · Filed: January 14, 2019

NO ANTI-LOCK BRAKES

Electrical System; Service Brakes

ODI #11154913

Incident: November 15, 2018 · Filed: November 30, 2018

FAN WANT COOL THE CAR WHEN STOP AT RED BREAKS WHEN FAST STOPING HAS SLOW GRIP TOO THEM

Electrical System

ODI #10916655

Incident: October 17, 2016 · Filed: October 17, 2016

NHTSA CAMPAIGN ID NUMBER 14V400000 - I SENT A PRIOR COMPLAINT TODAY REGARDING MY 1999 MONTE CARLO AND I APOLOGIZE FOR MISSTATING A FACT.. I SAID IN THE ORIGINAL COMPLAINT THAT MY MONTE CARLO WAS LISTED ON THE RECALL AT THE YEAR 2000. AND THAT IT WAS SIMILAR TO THE LUMINA, I MEANT TO SAY THAT IT IS SIMILAR TO THE 1999 MALIBU, WHICH IS BEING RECALLED BECAUSE OF THE IGNITION SYSTEM. THE RECALL NUMBER IS 14350. AND MY COMPLAINT NUMBER THAT I SENT EARLIER WHICH DESCRIBES IN DETAIL THE PROBLEM I AM HAVING IS 10916644.. *TR

Electrical System

ODI #10916644

Incident: October 17, 2016 · Filed: October 17, 2016

MY CAR WILL NOT TURN ALL THE WAY OFF TO BE ABLE TO REMOVE THE KEYS FROM THE IGNITION. I UNDERSTAND THERE IS A RECALL ON 2000 MODELS AND UP. AND THERE IS A RECALL FOR THE SAME ISSUE ON THE 1999 LUMINA - BUT NOT ON THE MONTE CARLO, GIVEN THAT THE MC IS SO SIMILAR TO THE LUMINA, I THINK THERE HAS BEEN A MISTAKE NOT INCLUDING THE MC. IT HAS HAPPENED ON SEVERAL DIFFERENT OCCASIONS AND IS GETTING WORSE. I BELIEVE THE 1999 SHOULD BE INCLUDED IN THE RECALL ALSO. PLEASE LET ME KNOW, THANK YOU. IF YOU ARE NOT THE RIGHT PEOPLE PLEASE POINT ME IN THE RIGHT DIRECTION. *TR

Electrical System; Engine; Fuel/Propulsion System

ODI #10908112

Incident: October 15, 2012 · Filed: September 20, 2016

TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. AFTER REFUELING THE VEHICLE, THE CONTACT NOTICED FUEL LEAKING UNDERNEATH THE VEHICLE. IN ADDITION, THE FRONT DRIVER AND PASSENGER SIDE POWER WINDOWS AND THE AIR CONDITIONER FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED AND THE AIR CONDITIONING UNIT NEEDED TO BE RECHARGED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE WITH THE AIR CONDITIONER RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

Engine

ODI #10852428

Incident: March 30, 2016 · Filed: March 30, 2016

TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING OIL. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. PARTS DISTRIBUTION DISCONNECT.

Engine

ODI #10836901

Incident: December 2, 2015 · Filed: February 18, 2016

TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PART DISTRIBUTION DISCONNECT.

Engine

ODI #10823994

Incident: December 18, 2015 · Filed: February 3, 2016

TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WAS A BURNING OIL ODOR EMITTING FROM THE VEHICLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Engine

ODI #10816776

Fire

Incident: December 14, 2015 · Filed: December 29, 2015

TL* THE CONTACT OWNS A 1999 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WAS A LEAK COMING FROM UNDER THE HOOD THAT WAS GETTING PROGRESSIVELY WORST. THE LEAK WOULD CREATE A PUDDLE ON THE FLOOR. THE CONTACT ALSO STATED THAT UPON TURNING THE KEY IN THE VEHICLE, IT STARTED SMOKING. THE VEHICLE WAS INSPECTED BY THE CONTACT WHO NOTICED THAT ENGINE OIL WAS LEAKING ONTO THE EXHAUST MANIFOLD. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE) AND WAS TO SCHEDULE A RECALL REPAIR APPOINTMENT ONCE THE PARTS BECAME AVAILABLE. THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Other Chevrolet Monte Carlo model years

Check your 1999 Chevrolet Monte Carlo VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Monte Carlo at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN