NHTSA vehicle safety data

2005 Chevrolet Monte Carlo Recalls, Ratings & Complaints

The 2005 Chevrolet Monte Carlo has 4 NHTSA recall campaigns and 120 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2005 Chevrolet Monte Carlo, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Chevrolet Monte Carlo owner complaints

Owners have filed 120 complaints with NHTSA about the 2005 Chevrolet Monte Carlo, describing incidents dated January 1, 2006 to January 9, 2024.

Most-cited components

Electrical System 87 complaints
Exterior Lighting 17 complaints
Fuel/Propulsion System 9 complaints
Engine 7 complaints
Service Brakes 7 complaints
Vehicle Speed Control 5 complaints

Of the 120 complaints on file, 1 reports a crash and 3 a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11564424 · Filed January 9, 2024
I have had numerous lights, noise, continuously for the last 7 years have replaced numerous parts, only to last awhile then the lights, noise return. Seems there is no cure for this malfunctioning problem, have heard GM is aware of these problems but have never received a letter regarding them, the…
ODI #11266427 · Filed October 4, 2019
THE PCM FOR THE TRANSMISSION IS OUT OR DEFECTIVE AND FROM WHAT I'VE RESEARCHED THIS IS A VERY COMMON PROBLEM WITH THE MONTE CARLO. CHEVROLET SHOULD BE RESPONSIBLE FOR SELLING A KNOWN DEFECTIVE COMPUTER!
ODI #11242930 · Filed August 9, 2019
TAKATARECALL STIL TILL I HAVE THAT PROBLEMS

Read all 120 complaints

Owner-reported

2005 Chevrolet Monte Carlo mileage at failure

93 of the 120 complaints on file for the 2005 Chevrolet Monte Carlo give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Electrical System	Median 70,000 miles	Middle half 45,000–85,000 miles	Based on 72 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

Ignition Switch may Turn Off

NHTSA #14V400000 · Electrical System — Ignition · NHTSA notice

Reported July 3, 2014 · General Motors LLC

Potentially affected: 5,877,718 vehicles

Repair completion: 37.05% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14350 · Owners notified September 8, 2014

Defect description

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Safety consequence

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Manufacturer remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

STEERING KNUCKLE BREAKING/LOSS OF STEERING CONTROL

NHTSA #09E005000 · Steering · NHTSA notice

Reported February 17, 2009 · DORMAN PRODUCTS, INC.

Potentially affected: 979 vehicles

Owners notified February 23, 2009

Defect description

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Safety consequence

A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Manufacturer remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

INTERMEDIATE STEERING SHAFT/LOSS OF STEERING

NHTSA #08E063000 · Steering · NHTSA notice

Reported October 17, 2008 · DORMAN PRODUCTS, INC.

Potentially affected: 3,855 vehicles

Owners notified October 16, 2008

Defect description

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Safety consequence

IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

Notes

THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL PRESSURE REGULATORS

NHTSA #07E021000 · Fuel System, Other — Storage — Tank Assembly — Pressure Relief Devices · NHTSA notice

Reported March 12, 2007 · DELPHI

Potentially affected: 742 vehicles

Owners notified April 27, 2007

Defect description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Safety consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2005 Chevrolet Monte Carlo 2-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 3, Passenger: 4

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

120 owner complaints have been filed with NHTSA for the 2005 Chevrolet Monte Carlo.

Service Brakes

ODI #11564424

Incident: January 9, 2024 · Filed: January 9, 2024

I have had numerous lights, noise, continuously for the last 7 years have replaced numerous parts, only to last awhile then the lights, noise return. Seems there is no cure for this malfunctioning problem, have heard GM is aware of these problems but have never received a letter regarding them, the anti-lock traction control braking system on these cars are headaches and troublesome, and expensive with no cure in sight, have spent tons of money on these problems, still keep having them.

Power Train

ODI #11266427

Incident: March 2, 2019 · Filed: October 4, 2019

THE PCM FOR THE TRANSMISSION IS OUT OR DEFECTIVE AND FROM WHAT I'VE RESEARCHED THIS IS A VERY COMMON PROBLEM WITH THE MONTE CARLO. CHEVROLET SHOULD BE RESPONSIBLE FOR SELLING A KNOWN DEFECTIVE COMPUTER!

Electrical System; Air Bags; Electronic Stability Control (ESC)

ODI #11242930

Incident: July 3, 2014 · Filed: August 9, 2019

TAKATARECALL STIL TILL I HAVE THAT PROBLEMS

Electrical System

ODI #11092066

Incident: May 2, 2018 · Filed: May 5, 2018

WHEN I FIRST BOUGHT THIS CAR THE BOOST GAGE WAS NOT WORKING. A FEW DAYS LATER THE GAS OIL PRESSURE AND TEMPERATURE GAUGES STARTED GOING CRAZY. THE TEMPERATURE GAUGE NEEDS TO WORK TO SHOW OVERHEATING OF ENGINE TO AVOID DAMAGE. INTERNET FORUMS SAY THIS ISSUE A VERY COMMON ISSUE. PICTURE SHOWS GAUGES ON LEFT AFTER CAR RUNNING 10 MIN WITH APPROX HALF TANK OF GAS

Exterior Lighting

ODI #11053609

Incident: May 10, 2010 · Filed: December 9, 2017

THE MULTI FUNCTION SWITCH IS FAULTY. MY BLINKERS NEVER WORK RIGHT. SOMETIMES I HAVE RIGHT AND NO LEFT TURN SIGNAL AND MANY TIMES THE HAZARD LIGHTS TURN ON WHEN I USE TURN SIGNAL. THE TURN SIGNAL SOUND OF CLICKING NEVER STOPS, CONSTANT CLICKING THAT OFTEN STARTS BUZZING. QUITE OFTEN MY TURN SIGNALS DO NOT FUNCTION PROPERLY AND I HAVE NO WAY TO ALERT OTHER DRIVERS THAT I AM SWITCHING LANES. IT SEEMS TO BE A COMMON PROBLEM WITH CHEVROLET AND GMC AND EXPENSIVE TO CORRECT.

Fuel/Propulsion System

ODI #11010229

Incident: July 21, 2017 · Filed: July 24, 2017

FEUL PRESSURE REGULATOR RECALL #07E021000 FOR 2005 IMPALA, BUT NOT FOR MY MONIE CARLO , GAS SMELL WHILE DRIVING/FUEL PRESSURE REGULATOR LEAKING.

Electrical System

ODI #10959753

Incident: March 6, 2017 · Filed: March 9, 2017

TL* THE CONTACT OWNS A 2005 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE KEY FAILED TO TURN OVER IN THE IGNITION SO THE CONTACT WAS UNABLE TO START THE VEHICLE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS WAITING TO BE REFERRED TO AN AUTHORIZED DEALER TO DIAGNOSE THE FAILURE AND PROVIDE THE RECALL REMEDY. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.

Unknown or Other; Fuel/Propulsion System

ODI #10926462

Incident: November 16, 2016 · Filed: November 16, 2016

MY CAR HAS A STRONG GAS ODOR PARTICULARLY IN COLDER WEATHER. I NOTICED IT LAST WINTER AND IT WENT AWAY DURING THE SUMMER. NOW THAT THE TEMPS ARE GETTING COOLER, IT HAS STARTED AGAIN. I TURN ON THE HEAT AND HAVE TO DRIVE WITH THE WINDOWS DOWN FOR VENTILATION. I'VE HAD THREE DIFFERENT MECHANIC SHOPS CHECK IT OUT. NONE HAVE BEEN ABLE TO FIND THE CAUSE. IT IS EMBARRASSING IN THE SCHOOL CAR RIDER LINE OR IN A DRIVE THROUGH. SOMEONE ALWAYS COMMENTS ON IT. I AM WORRIED IT MAY CATCH FIRE.

Engine

ODI #10923978

Incident: November 2, 2016 · Filed: November 3, 2016

MY ENGINE (V6 3.8L 3800 SERIES) IS LEAKING OIL ON THE ENGINE. MY MECHANIC TOLD ME THIS YESTERDAY (11/2/16) WHEN HE REPLACED THE PLASTIC ELBOWS AS I HAD ANTIFREEZE LEAKING FROM THEM. HE SAID THE 3.8 L ENGINE HAS A RECALL FOR THIS, OIL LEAKING FROM THE VALVE COVER GASKETS AND SAID CHEVROLET HAS A RECALL TO REPLACE THEM. I DO REMEMBER SEEING THIS RECALL ONLINE SOMEWHERE, BUT HAVE NOT SEEN IT WHILE SEARCHING THE LAST TWO DAYS. MY MECHANIC OLD ME IT WILL CAUSE A FIRE. I HAVE 87771 MILES ON MY CAR. I HAVE TO ADD A QUART OF OIL IN BETWEEN OIL CHANGES. I HAVE HAD TO DO THIS SINCE I PURCHASED THE CAR 6/2008. THE CAR HAS BEEN LEAKING OIL FOR AWHILE NOW.

Electrical System; Electronic Stability Control (ESC)

ODI #10920405

Incident: October 29, 2016 · Filed: October 31, 2016

KEY FOB QUIT WORKING. I USE THE KEY TO MANUALLY UNLOCK CAR. HOWEVER, AFTER CAR IS PARKED AND OFF, THE DOORS LOCK AND UNLOCK THEMSELVES. THE FRONT AND REAR LIGHTS FLASH WHILE DOORS LOCKING AND UNLOCKING. THE OTHER NIGHT, IT WAS FLASHING MORSE CODE FOR OVER 24HOURS. I DO NOT HAVE ON STAR CONNECTED. HORN QUIT WORKING 4 MONTHS RIGHT BEFORE KEY FOB QUIT. I CAN'T USE MY BRIGHT LIGHTS, BECAUSE I LOSE DASH LIGHTS, HEAD LIGHTS. MY SON AND I SHARE THIS CAR TO DRIVE TO WORK. SINCE THE LIGHTS STARTED FLASHING ALL DAY AND NIGHT, I FELT IT IS UNSAFE FOR HIM TO DRIVE TO WORK WHICH IS 40 MILES ONE WAY. WHY SO MANY ISSUES THAT ARE NOT BEING TAKEN SERIOUS? I DRIVE MY CAR DURING DAY TIME. I PRAY I MAKE IT TO WORK. I HAVE TO DRIVE 9 MILES ONE WAY TO WORK. HOWEVER, I DRIVE HIGHWAY 75 WITH SEMI TRUCKS GOING 70 MILES AN HOUR. IF THIS CAR LOSES POWER ON THAT HIGHWAY, I WILL PROBABLY NOT SURVIVE. UNSAFE AND NOT RELIABLE VEHICLE. CHEVY SHOULD HELP US MONTE CARLO OWNERS GET THEM FIXED. THANKS FOR YOUR TIME.

Other Chevrolet Monte Carlo model years

Check your 2005 Chevrolet Monte Carlo VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Monte Carlo at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN