NHTSA vehicle safety data

2001 Chevrolet Express 3500 Recalls & Complaints

The 2001 Chevrolet Express 3500 has 1 NHTSA recall campaign and 11 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2001 Chevrolet Express 3500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Chevrolet Express 3500 owner complaints

Owners have filed 11 complaints with NHTSA about the 2001 Chevrolet Express 3500, describing incidents dated June 28, 2002 to November 22, 2017.

Most-cited components

Engine 4 complaints
Tires 3 complaints
Service Brakes 2 complaints
Air Bags 1 complaint
Electrical System 1 complaint
Fuel/Propulsion System 1 complaint

Of the 11 complaints on file, 2 report a crash; across all 11 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11050993 · Filed November 28, 2017
TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 EQUIPPED WITH DEXTERO DHT2 TIRES, SIZE: LT245/75R/16 (NA). WHILE TRAVELING AT HIGHWAY SPEEDS, THE REAR PASSENGER TIRE EXPERIENCED A BLOW OUT. THE VEHICLE WAS TOWED TO AMERICAN CUSTOM TIRE INC (1300 W MAIN ST, QUARTZSITE, AZ) WHERE IT WAS DIAGNOSED…
ODI #10871926 · Filed June 1, 2016
THE "PCM"-PUMP CONTROL MODULE LOCATED ON THE INJECTION PUMP THAT IS IN CHARGE OF OPERATING AND COORDINATING PUMP OPERATIONS FAILS AFTER 30,000 TO 40,000 MILES. THIS CAUSES THE VEHICLE TO STOP RUNNING--NO BRAKES OR STEERING SIMILAR TO IGNITION SWITCH PROBLEM IN OTHER VEHICLES. GM LIKES TO GET 1,400…
ODI #10865402 · Filed May 17, 2016
THE REAR MAIN SEAL, FRONT HARMONIC SEAL AND POWER STEERING PUMP SHAFT SEAL ARE LEAKING. THE VEHICLE HAS 96,000 MILES ON IT. THIS SHOULD NOT BE. I TOOK IT TO A SHOP LAST WEEK TO HAVE PROBLEM FIXED. NEED HELP VERY EXPENSIVE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)…

Read all 11 complaints

OIL FILTER/OIL LEAK/POSSIBLE FIRE

NHTSA #07E088000 · Equipment · NHTSA notice

Reported October 24, 2007 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 121,680 vehicles

Owners notified November 8, 2007

Defect description

CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.

Safety consequence

THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2001 Chevrolet Express 3500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

11 owner complaints have been filed with NHTSA for the 2001 Chevrolet Express 3500.

Tires

ODI #11050993

Incident: November 22, 2017 · Filed: November 28, 2017

TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 EQUIPPED WITH DEXTERO DHT2 TIRES, SIZE: LT245/75R/16 (NA). WHILE TRAVELING AT HIGHWAY SPEEDS, THE REAR PASSENGER TIRE EXPERIENCED A BLOW OUT. THE VEHICLE WAS TOWED TO AMERICAN CUSTOM TIRE INC (1300 W MAIN ST, QUARTZSITE, AZ) WHERE IT WAS DIAGNOSED THAT THE INTERNAL SIDEWALL FAILED. THE TIRE WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND DID NOT ASSIST. THE VIN AND VEHICLE FAILURE MILEAGE WERE UNKNOWN. THE TIRE FAILURE MILEAGE WAS 1,500.

Electrical System; Engine; Fuel/Propulsion System

ODI #10871926

Incident: June 1, 2014 · Filed: June 1, 2016

THE "PCM"-PUMP CONTROL MODULE LOCATED ON THE INJECTION PUMP THAT IS IN CHARGE OF OPERATING AND COORDINATING PUMP OPERATIONS FAILS AFTER 30,000 TO 40,000 MILES. THIS CAUSES THE VEHICLE TO STOP RUNNING--NO BRAKES OR STEERING SIMILAR TO IGNITION SWITCH PROBLEM IN OTHER VEHICLES. GM LIKES TO GET 1,400 TO FIX, AFTER THE TOW. THANKS [XXX] A BETTER FIX NEEDS TO BE MADE HERE RATHER THAN INSTALLING ANOTHER DEFECTIVE PART. THIS PROBLEM HAPPENS IN ALL THE 6.5 DIESEL MOTORS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Steering; Engine

ODI #10865402

Incident: May 11, 2016 · Filed: May 17, 2016

THE REAR MAIN SEAL, FRONT HARMONIC SEAL AND POWER STEERING PUMP SHAFT SEAL ARE LEAKING. THE VEHICLE HAS 96,000 MILES ON IT. THIS SHOULD NOT BE. I TOOK IT TO A SHOP LAST WEEK TO HAVE PROBLEM FIXED. NEED HELP VERY EXPENSIVE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Service Brakes, Hydraulic

ODI #10446431

Incident: January 5, 2012 · Filed: January 29, 2012

BRAKE LINES SEVERELY CORRODED AND RUSTED AT MULTIPLE LOCATIONS. COMPLETE REPLACEMENT IS REQUIRED TO RENEW SAFETY INSPECTION CERTIFICATION.

Service Brakes, Hydraulic

ODI #10346137

Crash

Incident: June 20, 2010 · Filed: July 29, 2010

TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 VAN. THE CONTACT WAS APPROACHING A TRAFFIC STOP WHEN HE APPLIED THE BRAKES. THE BRAKES ENGAGED MOMENTARILY AND THEN INDEPENDENTLY RELEASED. THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT STATED THE FAILURE OCCURRED ONCE PRIOR TO THE CRASH. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED THAT THE BRAKE CYLINDER SENSOR MAY POTENTIALLY HAVE CAUSED THE FAILURE AND WERE KEEPING THE BRAKE LINES CLOSED WITHOUT ALLOWING PRESSURE TO RELEASE AND STOP THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 12,419. UPDATED 10/26/10. *LJ UPDATED 10/26/10

Engine and Engine Cooling

ODI #10345862

Incident: July 26, 2010 · Filed: July 28, 2010

TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 VAN. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. AS THE CONTACT WAS COASTING TO A STOP, THE VEHICLE INDEPENDENTLY RESTARTED. THE MANUFACTURER ADVISED THERE WERE NO RECALLS FOR THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 90,000.

Tires

ODI #10225892

Incident: April 16, 2007 · Filed: April 28, 2008

TIRE TREAD SEPARATED FROM TIRE CARCASS. *TR

Air Bags

ODI #10179463

Crash 1 injury

Incident: December 14, 2006 · Filed: January 23, 2007

TL*- THE CONTACT STATED THAT ON 12/14/06 AT 7:30 PM ON A CLEAR EVENING A SECOND VEHICLE RAN A RED LIGHT AND THE CONTACT'S VEHICLE HIT THE OTHER VEHICLE ON THE PASSENGER FRONT SIDE AT 55 MPH WITH THE 2001 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT HE LOST CONTROL OF THE VEHICLE AND HIT A DITCH HEAD ON AT 50 MPH. THE POLICE WERE CALLED, HE DIDN'T SPEAK WITH AN OFFICER BECAUSE THE CONTACT WAS FLOWN BY HELICOPTER TO THE HOSPITAL. THE CONTACT SUSTAINED BROKEN RIBS, A BROKEN PELVIS, AND OTHER INJURIES. THE CONTACT STATED THAT THE SEAT BELT HARNESS DID RESTRAIN HIM, BUT THE AIR BAG DIDN'T DEPLOY. THE NATURE OF THIS COMPLAINT IS THE AIR BAGS DID NOT DEPLOY. *AK UPDATED 2/22/2007 - *NM

Engine and Engine Cooling

ODI #10168631

Incident: June 28, 2002 · Filed: September 19, 2006

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS UNDER NORMAL DRIVING CONDITIONS, THE ENGINE STALLED AND OPERATED AT A REDUCED SPEED. THE REDUCED ENGINE POWER LIGHT ILLUMINATED. THE CONTACT PULLED OVER WITHOUT INCIDENT AND TURNED THE IGNITION OFF. AFTER A PERIOD OF 15 MINUTES, THE ENGINE EASILY RESTARTED WITHOUT FURTHER INCIDENT ALTHOUGH AFTER RESTARTING THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE ACCELERATOR MODULE OF THE ENGINE NEEDED TO BE REPLACED. AFTERWARDS, THE ENGINE STALLING AND REDUCED POWER PERSISTED. THE MANUFACTURER WAS NOTIFIED. NUMEROUS PARTS HAVE BEEN REPLACED IN THE VEHICLE SUCH AS A SENSOR, CRANKSHAFT, THROTTLE BODY UNIT, AND A WIRING CONNECTOR. UPDATED 11/03/06. *JB

Tires

ODI #10165923

Incident: August 18, 2006 · Filed: August 18, 2006

DT*: THE CONTACT STATED WHILE DRIVING 70 MPH ON THE INTERSTATE DURING DRY ROAD CONDITIONS, THE TREAD SEPARATED FROM THE DRIVER'S REAR TIRE. THE CONTACT HEARD A VIBRATION IN THE REAR OF THE VEHICLE PRIOR TO THE INCIDENT. THE DEALERSHIP WAS NOT NOTIFIED. THE TIRE WAS A FIRESTONE STEEL TX RADIAL R4S. *AK

Other Chevrolet Express 3500 model years

Check your 2001 Chevrolet Express 3500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Express 3500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN