NHTSA vehicle safety data

1996 Chevrolet Cavalier Recalls, Ratings & Complaints

The 1996 Chevrolet Cavalier has 13 NHTSA recall campaigns and 503 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 1996 Chevrolet Cavalier, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1996 Chevrolet Cavalier owner complaints

Owners have filed 503 complaints with NHTSA about the 1996 Chevrolet Cavalier, describing incidents dated September 10, 1995 to November 24, 2017.

Most-cited components

Engine 107 complaints
Electrical System 94 complaints
Air Bags 73 complaints
Service Brakes 57 complaints
Power Train 50 complaints
Steering 45 complaints

Of the 503 complaints on file, 58 report a crash and 10 a fire; across all 503 complaints, owners report 61 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11050932 · Filed November 28, 2017
TL* THE CONTACT OWNED A 1996 CHEVROLET CAVALIER. WHILE THE CONTACT WAS MAKING A U TURN, ANOTHER VEHICLE CRASHED INTO THE DRIVER SIDE OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES TO THE HEAD, RIGHT SHOULDER, AND LEFT KNEE. THE PASSENGER…
ODI #11029889 · Filed September 26, 2017
TL* THE CONTACT OWNS A 1996 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE DRIVER'S SIDE BY ANOTHER VEHICLE. THE DRIVER SIDE AIR BAG DID NOT DEPLOY DURING THE CRASH; HOWEVER, IT SUDDENLY DEPLOYED WHILE THE CONTACT ATTEMPTED TO EXIT THE VEHICLE. THE…
ODI #10638170 · Filed September 22, 2014
TL* THE CONTACT OWNS A 1996 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. AS A RESULT, THE CONTACT CRASHED INTO A STOP SIGN AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND NO…

Read all 503 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 1996 Chevrolet Cavalier in 4 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP03-007: UNINTENDED VEHICLE ACCELERATION
Closed January 30, 2004
Preliminary Evaluation PE02-001: FIRE IN STEERING COLUMN AREA
Closed March 15, 2002
- Recall 02V-070
Engineering Analysis EA98-001: OVERSENSITIVE AIR BAG DEPLOYMENTS
Closed July 31, 1998
- Recall 98V-146
Preliminary Evaluation PE97-041: INADVERTENT AIR BAG DEPLOYMENTS
Closed January 23, 1998

Open and recently closed NHTSA defect investigations

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

INTERMEDIATE STEERING SHAFT/LOSS OF STEERING

NHTSA #08E063000 · Steering · NHTSA notice

Reported October 17, 2008 · DORMAN PRODUCTS, INC.

Potentially affected: 3,855 vehicles

Owners notified October 16, 2008

Defect description

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Safety consequence

IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

Notes

THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL PUMP MODULES

NHTSA #07E015000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported February 26, 2007 · DELPHI

Potentially affected: 3,124 vehicles

Owners notified March 20, 2007

Defect description

CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING CORRECTLY (IDLE ROUGH AND/OR STALL) DUE TO AN OVERLY RICH FUEL BLEND OR THE VEHICLE'S EVAPORATIVE EMISSION CARBON CANISTER MAY LEAK FUEL.

Safety consequence

A STALLED VEHICLE CAN INCREASE THE RISK OF A VEHICLE CRASH. A FUEL LEAK CAN RESULT IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE MRAS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2007. OWNERS CAN CONTACT DELPHI AT 1-877-335-7443.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PUMP MODULES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E049000 · Exterior Lighting · NHTSA notice

Reported May 24, 2006 · CK MOTORSPORT, INC.

Potentially affected: 27,176 vehicles

Owners notified July 1, 2006

Defect description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/POWER STEERING ASSEMBLY

NHTSA #02V286000 · Steering — Rack and Pinion · NHTSA notice

Reported November 4, 2002 · GENERAL MOTORS CORP.

Potentially affected: 1,159,156 vehicles

Manufacturer campaign 02049 · Owners notified January 24, 2003 · Vehicles built January 1, 1996 – July 31, 1996 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.

Safety consequence

IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.

Manufacturer remedy

DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Notes

GM RECALL NO. 02049.ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/IGNITION SWITCH

NHTSA #02V070000 · Electrical System — Ignition — Switch · NHTSA notice

Reported March 6, 2002 · GENERAL MOTORS CORP.

Potentially affected: 1,589,948 vehicles

Manufacturer campaign 02008 · Owners notified March 27, 2002 · Vehicles built November 1, 1994 – August 31, 1996 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.

Safety consequence

IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.

Manufacturer remedy

DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/REAR SUSPENSION

NHTSA #98V319000 · Suspension — Rear · NHTSA notice

Reported December 15, 1998 · GENERAL MOTORS CORP.

Potentially affected: 27,083 vehicles

Owners notified December 28, 1998 · Vehicles built June 1, 1996 – March 31, 1997 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. ONE OF THE REAR SUSPENSION TRAILING ARM BOLTS CAN FATIGUE AND BREAK.

Safety consequence

IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A LOSS OF VEHICLE CONTROL CAN OCCUR, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE REAR SUSPENSION TRAILING ARM FASTENERS.

Notes

OWNER NOTIFICATION BEGAN DECEMBER 28, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/AIR BAG DEPLOYMENT

NHTSA #98V146000 · Air Bags · NHTSA notice

Reported June 29, 1998 · GENERAL MOTORS CORP.

Potentially affected: 675,302 vehicles

Owners notified August 11, 1998 · Vehicles built April 1, 1995 – August 31, 1996 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.

Safety consequence

AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.

Manufacturer remedy

DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.

Notes

OWNER NOTIFICATION BEGAN DURING AUGUST 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1022 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4326).

GM/FMVSS 101

NHTSA #98V027000 · Interior Lighting · NHTSA notice

Reported February 17, 1998 · GENERAL MOTORS CORP.

Potentially affected: 249,420 vehicles

Owners notified February 28, 1998 · Vehicles built April 1, 1995 – January 31, 1996 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."

Safety consequence

THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.

Manufacturer remedy

DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.

Notes

OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300,PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GENERAL MOTORS/FMVSS 108/4 WAY FLASHERS

NHTSA #96V250000 · Exterior Lighting — Hazard Flashing Warning Lights · NHTSA notice

Reported December 17, 1996 · GENERAL MOTORS CORP.

Potentially affected: 270,014 vehicles

Owners notified January 30, 1997 · Vehicles built July 1, 1995 – August 31, 1995 (per NHTSA)

Defect description

THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.

Manufacturer remedy

DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.

Notes

OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING JANUARY 1997. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Vehicle Speed Control

NHTSA #95V201000 · NHTSA notice

Reported October 23, 1995 · GENERAL MOTORS CORP.

Potentially affected: 360 vehicles

Owners notified October 19, 1995 · Vehicles built September 1, 1995 – September 1, 1995 (per NHTSA)

Defect description

THE ACCELERATOR CONTROL CABLE COULD HAVE BEEN KINKED DURING ASSEMBLY CAUSING HIGH ACCELERATOR PEDAL EFFORT, STICKING ACCELERATOR CONTROL CABLE, OR A BROKEN ACCELERATOR CONTROL CABLE.

Safety consequence

IF THE ACCELERATOR CONTROL CABLE STICKS OR BREAKS, UNWANTED ACCELERATION AND/OR LOSS OF THROTTLE CONTROL CAN RESULT INCREASING THE RISK OF A VEHICLE ACCIDENT.

Manufacturer remedy

DEALERS WILL REPLACE THE ACCELERATOR CONTROL CABLE ASSEMBLY.

Notes

SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737 OR CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

1996 Chevrolet Cavalier 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 3

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

4 investigations

503 owner complaints have been filed with NHTSA for the 1996 Chevrolet Cavalier.

Air Bags

ODI #11050932

Crash 2 injuries

Incident: November 24, 2017 · Filed: November 28, 2017

TL* THE CONTACT OWNED A 1996 CHEVROLET CAVALIER. WHILE THE CONTACT WAS MAKING A U TURN, ANOTHER VEHICLE CRASHED INTO THE DRIVER SIDE OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES TO THE HEAD, RIGHT SHOULDER, AND LEFT KNEE. THE PASSENGER SUSTAINED INJURIES TO THE LEFT SHOULDER. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS TOWED TO A TOW YARD AND DEEMED DESTROYED. THE VEHICLE WAS NOT DIAGNOSED FOR THE AIR BAG FAILURE. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000.

Air Bags

ODI #11029889

Crash 1 injury

Incident: May 12, 1997 · Filed: September 26, 2017

TL* THE CONTACT OWNS A 1996 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE DRIVER'S SIDE BY ANOTHER VEHICLE. THE DRIVER SIDE AIR BAG DID NOT DEPLOY DURING THE CRASH; HOWEVER, IT SUDDENLY DEPLOYED WHILE THE CONTACT ATTEMPTED TO EXIT THE VEHICLE. THE VEHICLE WAS TOWED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED SEVERE WHIPLASH, LEG BRUISES, AND HEAD LACERATIONS. MEDICAL ATTENTION WAS REQUIRED. THE CONTACT WAS TREATED AND RELEASED FROM THE HOSPITAL UNDER HER DOCTOR'S SUPERVISION. THE FOLLOWING DAY, THE DOCTOR DETERMINED THAT THE CONTACT'S NECK WAS FRACTURED AND SHE WAS SENT TO GET AN MRI AT THE REGIONAL HOSPITAL. THE VEHICLE WAS DIAGNOSED BY MARION CHEVROLET/CADILLAC IN MARION, ILLINOIS. THE AIR BAG WAS REPLACED AND THE VEHICLE'S BODY DAMAGE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 5,000.

Air Bags; Service Brakes

ODI #10638170

Crash

Incident: June 9, 2014 · Filed: September 22, 2014

TL* THE CONTACT OWNS A 1996 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. AS A RESULT, THE CONTACT CRASHED INTO A STOP SIGN AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 195,450.

Steering; Electrical System; Engine

ODI #10567934

Incident: October 4, 2006 · Filed: March 8, 2014

THIS CAR SHUTS OFF WHILE DRIVING LIKE THE GM CARS BEING MENTIONED IN THE NEWS TODAY. STARTED IN 2005 AND WAS EVALUATED BY MULTIPLE MECHANICS INCLUDING A CHEVROLET DEALERSHIP THAT KEPT IT OVER A MONTH. IT DOESN'T SHOW A CODE WHEN IT HAPPENS. IT RANDOMLY SHUTS OFF WHILE YOU ARE DRIVING (VARIED SPEEDS). IT ALSO RANDOMLY WON'T START. TOTALLY UNPREDICTABLE WHEN IT WILL QUIT ON YOU OR NOT START.RESETTING DID NOT HELP.CAR WAS PURCHASED FOR DAUGHTER (NEW DRIVER) TO DRIVE, BUT WAS TOO UNSAFE. *TR

Interior Lighting

ODI #10501440

Incident: May 21, 1999 · Filed: March 5, 2013

TL* THE CONTACT OWNS A 1996 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE INTERIOR LIGHTS WOULD SPORADICALLY ILLUMINATE. THE FAILURE OCCURRED NUMEROUS TIMES OVER THE COURSE OF SIXTEEN YEARS. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS NUMEROUS TIMES BUT THE CONTACT WAS TOLD THAT THERE WERE NO FAILURES DISCOVERED. THE CONTACT EVENTUALLY REMOVED THE INTERIOR LIGHT FUSE TO STOP THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 98V027000 (INTERIOR LIGHTING) BUT WAS TOLD THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT ALSO STATED THAT THE CATALYTIC CONVERTER WAS REPLACED SIX TIMES. THE VEHICLE WAS NOT REPAIRED FOR THE INTERIOR LIGHTING FAILURE. THE FAILURE MILEAGE WAS 11,000 AND THE CURRENT MILEAGE WAS 233,163.

Engine and Engine Cooling; Electrical System

ODI #10440387

Incident: December 16, 2011 · Filed: December 19, 2011

THERE'S ALOT OF STUFF WRONG WITH THIS CAR. IT RAN GOOD AND IS RELIABLE WHEN RUNNING,BUT RECENTLY STOP RUNNING. *TR

Engine and Engine Cooling; Power Train; Air Bags; Electronic Stability Control (ESC)

ODI #10438689

Incident: December 5, 2011 · Filed: December 6, 2011

I REPLACED THE BATTERY ON MY 1996 CHEVROLET CAVALIER 2.4L WITH MANUAL TRANSMISSION ABOUT 3 DAYS AGO. TODAY AS I WAS DRIVING TO GET GAS THE VEHICLE STARTED TO IDLE LOW AS IF IT WAS NOT GETTING ENOUGH FUEL TO THE ENGINE. AS I CAME TO A STOP IT GOT WORSE AND THEN I CHECK THE DASH FOR ANY INDICATION OF MALFUNCTION ONLY TO SEE MY AIRBAG, CHECK ENGINE, ABS, CHECK OIL & BATTERY LIGHTS FLICKERING. MOMENTS LATER AS I SHIFT INTO 3RD GEAR IT DIES RENDERING ALL SAFETY AND NORMAL OPERATION OF THE VEHICLE NEARLY IMPOSSIBLE. I HAD TO CALL A FRIEND TO JUMP ME 3 MORE TIMES BEFORE REACHING MY HOME WHICH WAS LESS THAN A MILE AWAY! *TR

Electrical System; Interior Lighting

ODI #10361181

Incident: October 13, 2010 · Filed: October 19, 2010

YES CAR WILL TURN OVER BUT WON'T START IT DOES THIS AT TIME OR U CAN PRESS THE GAS TO TRY AND START INTERIOR LIGHT DON'T WORK. *TR

Engine and Engine Cooling; Equipment; Unknown or Other

ODI #10354784

Incident: September 5, 2010 · Filed: September 9, 2010

I PURCHASED A 1996 CHEVY CAVALIER IN 1999 AND FROM THE BEGINNING HAD PROBLEMS WITH THE CHECK ENGINE LIGHT CONTINUALLY ON ETC. FROM 1999 TO SEPT 2010 - I TOOK IT TO SEVERAL CHEVY DEALERS WHILE IT WAS UNDER WARRANTY AND THEY NEVER FIXED THE PROBLEM COMPLETELY AND THE LIGHTS REMAINED ON. I WAS TOLD TO PUT FUEL INJECTION CLEANER IN IT BY ONE CAR DEALER OF COURSE THAT DIDN'T WORK. YEARS LATER AND MANY REPAIRS, ENGINE REBUILT, THERMOSTAT REPLACED, WATER PUMPS, FANS ETC.. FOUR CATALYTIC CONVERTERS I STILL HAVE THE SAME PROBLEM - LOSS OF POWER, CAR SHUTTING OFF AND LEAVING ME IN INTERSECTION, FREEWAYS ETC.. CAUSING A VERY DANGEROUS SITUATION, I HAVE OVER THESE YEARS BECOME VERY FRUSTRATED THE CODES READ O2 SENSORS, THE CAT CONVERTER PIECES FALL APART EASILY CAUSING VERY COSTLY REPAIRS BECAUSE THESE DEFECTIVE PARTS CLOG THE AIR FLOW CAUSING OVERHEATING AND LOSS OF POWER, IT SHOULD NOT BE THIS DIFFICULT OR COST TO KEEP THIS CAR IN REPAIR ORDER. CAT CONVERTERS, SENSORS, HEAD GASKETS, SEALS, WATER PUMPS, STICKING THERMOSTATS ETC.. CONTINUALLY REPLACED AND STILL THE SAME ON GOING PROBLEM WITH NO HOPE OF EVER FINALLY FIXING THIS DANGEROUS DEFECTIVE PROBLEM. *TR

Air Bags

ODI #10342884

Incident: June 1, 2010 · Filed: July 13, 2010

TL* THE CONTACT OWNS A 1996 CHEVROLET CAVALIER. WHILE DRIVING AT 30 MPH, THE DRIVER SIDE AIR BAG INDEPENDENTLY DEPLOYED. THE CONTACT WAS UNABLE TO SEE THE ROADWAY AND THE PASSENGER HAD TO MAINTAIN CONTROL OF THE STEERING WHEEL AS THE VEHICLE STEERED OF ROAD INTO A GAS STATION AREA. BOTH THE PASSENGER AND CONTACT EXITED THE VEHICLE AND THE FRONT PASSENGER SIDE AIR BAG THEN INDEPENDENTLY DEPLOYED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS AWAITING A DIAGNOSIS OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,950 AND THE CURRENT MILEAGE WAS 136,018. UPDATED 9/13/10 *CN UPDATED 09/15/10

Other Chevrolet Cavalier model years

Check your 1996 Chevrolet Cavalier VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Cavalier at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN