NHTSA vehicle safety data

2009 Chevrolet Avalanche Recalls, Ratings & Complaints

The 2009 Chevrolet Avalanche has 5 NHTSA recall campaigns and 76 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2009 Chevrolet Avalanche, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2009 Chevrolet Avalanche owner complaints

Owners have filed 76 complaints with NHTSA about the 2009 Chevrolet Avalanche, describing incidents dated March 3, 2010 to March 1, 2023.

Most-cited components

Air Bags 41 complaints
Unknown or Other 28 complaints
Structure 8 complaints
Electrical System 4 complaints
Vehicle Speed Control 4 complaints
Engine 2 complaints

Of the 76 complaints on file, 4 report a crash and 1 a fire; across all 76 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11532117 · Filed July 13, 2023
The passenger side air bag was replaced under a current recall (N212328790) however, once they fixed the issue at Love Chevy (Inverness, FL), the air bag light stayed on. It has never shut off and after speaking with the dealership as well as Chevrolet, they refuse to fix the issue they caused. I do…
ODI #11512395 · Filed March 17, 2023
The contact owns a 2009 Chevrolet Avalanche equipped with Cooper Tires, Tire Line: Discoverer Rugged Trek, Tire Size: 275/55/R20, DOT Number: (Not Available). The contact stated that while driving at an undisclosed speed, an abnormal noise was heard coming from the front passenger’s side tire. The…
ODI #11444139 · Filed December 17, 2021
2009 CHEVROLET AVALANCHE. CONSUMER WRITES IN REGARDS TO AIRAG SAFETY RECALL. THE CONSUMER STATED THE PARTS NECESSARY TO COMPLETE THE RECALL REPAIR HAVE NOT BECOME AVAILABLE. THE CONSUMER WAS PLACED ON AWAITING LIST AT THE DEALERSHIP TO BE CONTACTED WHEN THE PART ARRIVES.

Read all 76 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2009 Chevrolet Avalanche in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021

Open and recently closed NHTSA defect investigations

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V050000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 2,641,272 vehicles

Repair completion: 44.01% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328760 · Owners notified March 1, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V053000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 692,526 vehicles

Repair completion: 56.96% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328790 · Owners notified May 11, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #21V052000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 5, 2021 · General Motors, LLC

Potentially affected: 557,023 vehicles

Repair completion: 54.81% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N212328780 · Owners notified September 20, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Manufacturer remedy

GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

HEATED WINDSHIELD WASHER MODULE SHORT CIRCUIT

NHTSA #10V240000 · Electrical System · NHTSA notice

Reported June 4, 2010 · GENERAL MOTORS CORP.

Potentially affected: 1,365,070 vehicles

Owners notified June 11, 2010

Defect description

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Safety consequence

IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Manufacturer remedy

DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FUEL SYSTEM CONTROL MODULE

NHTSA #09V154000 · Fuel System, Gasoline · NHTSA notice

Reported May 6, 2009 · GENERAL MOTORS CORP.

Potentially affected: 27,188 vehicles

Manufacturer campaign 08411 · Owners notified May 18, 2009 · Vehicles built June 1, 2008 – September 30, 2008 (per NHTSA)

Defect description

GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.

Safety consequence

WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.

Notes

GM RECALL NO. 08411.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

2009 Chevrolet Avalanche 4-DR w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

21% rollover risk

Safety Technology

Electronic Stability Control

1 investigation

76 owner complaints have been filed with NHTSA for the 2009 Chevrolet Avalanche.

Air Bags; Unknown or Other; Fuel/Propulsion System

ODI #11532117

Incident: December 1, 2021 · Filed: July 13, 2023

The passenger side air bag was replaced under a current recall (N212328790) however, once they fixed the issue at Love Chevy (Inverness, FL), the air bag light stayed on. It has never shut off and after speaking with the dealership as well as Chevrolet, they refuse to fix the issue they caused. I do not know if the recall has actually been fixed. Additionally, I am unable to refuel appropriately due to another recall (that my vehicle apparently isn't a part of), however, based on the amount of people that have the same problem, it should be a wider issued recall. This is for Chevy recall # 08411 for the Fuel System Control Module. It affects the charcoal canister, along with purge value and corresponding lines. Depending on how bad, charcoal canister needs replacement, even possibly the lines, as well as the gas tank. Very expensive fix that Chevy refuses to address. This is a common problem that mechanics see with these vehicles.

Tires

ODI #11512395

Incident: March 1, 2023 · Filed: March 17, 2023

The contact owns a 2009 Chevrolet Avalanche equipped with Cooper Tires, Tire Line: Discoverer Rugged Trek, Tire Size: 275/55/R20, DOT Number: (Not Available). The contact stated that while driving at an undisclosed speed, an abnormal noise was heard coming from the front passenger’s side tire. The contact pulled over and noticed that the front passenger’s side tire side wall was blown out. The vehicle was towed to an independent mechanic, who removed the tire. The contact then stated that the tire was taken to another independent mechanic, where it was diagnosed and determined that the front passenger’s side tire needed to be replaced. The tire was not replaced. The tire was a replacement tire. The manufacturer was made aware of the failure. The approximate tire mileage was 20,000. The approximate vehicle failure mileage was 165,000. The VIN was unavailable.

Air Bags

ODI #11444139

Incident: December 17, 2021 · Filed: December 17, 2021

2009 CHEVROLET AVALANCHE. CONSUMER WRITES IN REGARDS TO AIRAG SAFETY RECALL. THE CONSUMER STATED THE PARTS NECESSARY TO COMPLETE THE RECALL REPAIR HAVE NOT BECOME AVAILABLE. THE CONSUMER WAS PLACED ON AWAITING LIST AT THE DEALERSHIP TO BE CONTACTED WHEN THE PART ARRIVES.

Air Bags

ODI #11443583

Incident: December 13, 2021 · Filed: December 13, 2021

2009 CHEVROLET AVALANCHE. CONSUMER WRITES IN REGARDS TO TAKATA AIRBAG SAFETY RECALL. THE CONSUMER STATED THE AIRBAG COULD NOT BE REPLACED WITHOUT DESTROYING THE DASHBOARD. THE CONSUMER WOULD HAVE TO INCUR THE COST OF THE DASHBOARD REPLACEMENT AND REPAIR. THE CONSUMER STATED THIS WAS UNSATISFACTORY.

Air Bags; Structure

ODI #11441514

Incident: October 5, 2021 · Filed: November 23, 2021

The contact owns a 2009 Chevrolet Avalanche. The contact stated that he received notification of NHTSA Campaign Number: 21V052000 (Air Bags) and the vehicle was taken to the dealer for the recall repair. The contact stated that upon picking up the vehicle from the dealer, he noticed that the dealer had fractured a portion of the dashboard close to the passenger’s side air bag housing. The dealer was notified of the failure and informed the contact that the dashboard was fractured prior to the recall repair. The manufacturer was notified of the failure and advised the contact that they could not assist. A case was opened. The vehicle was repaired. The approximate failure mileage was 102,000. Consumer stated dealer installed new dash into the vehicle.*JB

Air Bags

ODI #11420387

Incident: February 1, 2021 · Filed: June 10, 2021

Takata recall. The contact owns a 2009 Chevrolet Avalanche. The contact received notification of NHTSA Campaign Number: 21V052000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.

Air Bags; Unknown or Other

ODI #11418663

Incident: May 26, 2021 · Filed: May 26, 2021

I purchased the 2009 Chevrolet Avalanche new in October 2009. While in warranty I noticed the dashboard was cracking and took it to the dealer, Four Stars Auto, in Henrietta, Texas. At that time I was told they would order a new dash board and replace it. I took the truck in for replacement of the dash board on the scheduled date. After the truck was out of warranty the dash board cracked again in the same place. I suspect the dash was repaired and painted and not replaced, but I have no proof so I did not contact the dealer. Since that time I have learned this has been an issue with other owners of GM trucks and nothing can be done about it other than replacing the dash, which is a very expensive repair for someone that is retired and on a fixed income. My dash board has now cracked in at least four places and seems to be getting worse. I have heard this could cause issues with the deployment of the airbags, not to mention diminished resale value.

Air Bags; Unknown or Other

ODI #11405465

Incident: March 1, 2018 · Filed: March 29, 2021

MY TRUCK IS ONE OF THE MANY WITH THE CRACKING OF THE DASH IN MULTIPLE PLACES. THIS VEHICLE HAS BEEN STORED IN A GARAGE OR IN SHADED AREAS MOST OF ITS LIFE AND HAS THE DEFECTIVE DASH BOARD THAT IS FALLING APART. I AM CONCERNED THAT IF A AIRBAG EVER HAS TO DEPLOY, THIS DASH COULD CAUSE SHRAPNEL TO EITHER PUNCTURE THE AIRBAG OR HARM A PASSENGER. I HAVE ASKED GM DEALERSHIP TO REPLACE AND THEY QUOTED THOUSANDS FOR WHAT APPEARS TO BE A PROVEN DEFECT.

Air Bags

ODI #11404327

Incident: March 16, 2021 · Filed: March 22, 2021

RECALL #N212328790 FOR AIR BAG ,NHTSA # 21V053 . SERVICE DONE BY DEALER ,BUT AIR BAG WARNING LIGHT STILL ILLUMINATED , MECHANIC SAID BAG WILL NOT DEPLOY WITH LIGHT ON .WHAT WAS PURPOSE OF RECALL IF WE STILL HAVE NO OPERATING AIR BAG?

Structure

ODI #11399802

Incident: July 17, 2017 · Filed: March 8, 2021

TL* THE CONTACT OWNS A 2009 CHEVROLET AVALANCHE. THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED. THE VEHICLE WAS TAKEN TO CUTTER CHEVROLET (711 ALA MOANA BLVD, HONOLULU, HI 96813) WHERE THE CONTACT WAS INFORMED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS A COMMON AND THAT THE DASHBOARD WOULD BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

Other Chevrolet Avalanche model years

Check your 2009 Chevrolet Avalanche VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Avalanche at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN