NHTSA vehicle safety data

2003 Chevrolet Avalanche Recalls, Ratings & Complaints

The 2003 Chevrolet Avalanche has 6 NHTSA recall campaigns and 204 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Chevrolet dealer.

NHTSA recall and complaint data for the 2003 Chevrolet Avalanche, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Chevrolet Avalanche owner complaints

Owners have filed 204 complaints with NHTSA about the 2003 Chevrolet Avalanche, describing incidents dated January 1, 2003 to March 26, 2016.

Most-cited components

Service Brakes 79 complaints
Electrical System 42 complaints
Air Bags 14 complaints
Power Train 14 complaints
Vehicle Speed Control 11 complaints
Visibility/Wiper 10 complaints

Of the 204 complaints on file, 10 report a crash and 2 a fire; across all 204 complaints, owners report 7 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10855523 · Filed April 14, 2016
MY 17 YEAR OLD SON WAS ON THE FREEWAY AND THE BRAKE PEDAL TRAVELLED ALL THE WAY TO THE FLOOR WHILE ATTEMPTING TO STOP. THE SERVICE BRAKE SYSTEM LIGHT CAME ON AT THE SAME TIME. STOPPING DISTANCE WAS INCREASED DRAMATICALLY, BY AT LEAST DOUBLE. IF THERE WOULD HAVE BEEN A CURVE OR CAR IN FRONT OF HIM…
ODI #10837117 · Filed February 19, 2016
TL* THE CONTACT OWNS A 2003 CHEVROLET AVALANCHE. WHILE DRIVING APPROXIMATELY 65 MPH, THE INSTRUMENT PANEL FAILED. IN ADDITION, THE DRIVER SIDE HEADLIGHT FAILED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL…
ODI #10747108 · Filed August 7, 2015
BRAKE LINE FAILURE: I HAD A RUPTURED STEEL BREAK LINE FAILURE WHILE APPLYING NORMAL BREAKING PRESSURE ON THE PEDAL. AFTER FURTHER INSPECTION OF BREAK LINES, I FOUND ALL BREAK LINES WERE RUSTED AND IN DANGER OF ALSO RUPTURE.

Read all 204 complaints

Owner-reported

2003 Chevrolet Avalanche mileage at failure

159 of the 204 complaints on file for the 2003 Chevrolet Avalanche give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Service Brakes	Median 105,000 miles	Middle half 60,000–135,000 miles	Based on 67 complaints
Electrical System	Median 70,000 miles	Middle half 45,000–90,000 miles	Based on 34 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2003 Chevrolet Avalanche in 4 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE10-010: Brake line corrosion failure
Closed January 5, 2011
Defect Petition DP05-009: PARKING BRAKE FAILURE
Closed May 31, 2006
Engineering Analysis EA04-012: HYDRAULIC PUMP FAILRES
Closed February 28, 2005
- Recall 05V-005
Engineering Analysis EA04-005: TAILGATE CABLE BREAKAGE
Closed September 28, 2004
- Recall 04V-129
- Recall 04E-067

Open and recently closed NHTSA defect investigations

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

SEAT BELT ROUTING

NHTSA #05V163000 · Seat Belts — Rear/Other · NHTSA notice

Reported April 22, 2005 · GENERAL MOTORS CORP.

Potentially affected: 1,359,824 vehicles

Manufacturer campaign 05037 · Owners notified July 21, 2005 · Vehicles built April 3, 2002 – July 31, 2003 (per NHTSA)

Defect description

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.

Safety consequence

A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.

Manufacturer remedy

DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.

Notes

GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/TAILGATE SUPPORT CABLE

NHTSA #04V129000 · Structure — Body — Tailgate — Hinge and Attachments · NHTSA notice

Reported March 17, 2004 · GENERAL MOTORS CORP.

Potentially affected: 3,662,211 vehicles

Manufacturer campaign 04007 · Owners notified September 18, 2004 · Vehicles built April 1, 2002 – July 31, 2003 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.

Safety consequence

ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.

Manufacturer remedy

DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.

Notes

GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/FMVSS 135/BRAKE VALVE

NHTSA #04V045000 · Service Brakes, Hydraulic · NHTSA notice

Reported February 4, 2004 · GENERAL MOTORS CORP.

Potentially affected: 68,875 vehicles

Manufacturer campaign 04004 · Owners notified June 18, 2004 · Vehicles built May 1, 2003 – July 31, 2003 (per NHTSA)

Defect description

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Safety consequence

CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Manufacturer remedy

DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

Notes

GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/CROSS MEMBER FRACTURE/FUEL TANK PUNCTURE

NHTSA #03V019000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported January 27, 2003 · GENERAL MOTORS CORP.

Potentially affected: 5,734 vehicles

Manufacturer campaign 03002 · Owners notified February 20, 2003 · Vehicles built April 1, 2002 – January 31, 2003 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, VEHICLES, DURING A 30 DEGREE LEFT ANGLE FRONTAL IMPACT OF SUFFICIENT SEVERITY, A TEAR COULD DEVELOP IN THE MID-FRAME CROSS MEMBER AT ITS ATTACHMENT TO THE LEFT FRAME RAIL. IF THE MID-FRAME CROSS MEMBER TEARS DURING FRONTAL IMPACT AND PRODUCES A SHARP EDGE, CONTACT OF THE SHARP EDGE WITH THE FUEL TANK COULD RESULT IN A PUNCTURE OF THE FUEL TANK AND POSSIBLE FUEL LEAKAGE.

Safety consequence

FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL INSTALL A FUEL TANK SHIELD. OWNER NOTIFICATION BEGAN FEBRUARY 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Notes

GM RECALL NO. 03002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2003 Chevrolet Avalanche 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Safety Technology

5 investigations

204 owner complaints have been filed with NHTSA for the 2003 Chevrolet Avalanche.

Service Brakes

ODI #10855523

Incident: March 26, 2016 · Filed: April 14, 2016

MY 17 YEAR OLD SON WAS ON THE FREEWAY AND THE BRAKE PEDAL TRAVELLED ALL THE WAY TO THE FLOOR WHILE ATTEMPTING TO STOP. THE SERVICE BRAKE SYSTEM LIGHT CAME ON AT THE SAME TIME. STOPPING DISTANCE WAS INCREASED DRAMATICALLY, BY AT LEAST DOUBLE. IF THERE WOULD HAVE BEEN A CURVE OR CAR IN FRONT OF HIM THERE WOULD HAVE BEEN AN ACCIDENT. PARKED THE TRUCK UNTIL IT COULD BE INSPECTED AND FOUND A LEAK UNDER DRIVER SIDE FRONT DOOR. ALL OF THE MAIN BRAKE PIPES WERE RUSTED AND FRAGILE. TAKING TRUCK TO DEALERSHIP TO HAVE ALL BRAKE PIPES REPLACED WITH KIT MENTIONED IN (TSB) 13-05-22-001. I AM VERY DISAPPOINTED THAT GM IS FIGHTING A RECALL BY SIGHTING THE FACT THAT THERE ARE TWO DIFFERENT BRAKE SYSTEMS AND IT IS NOT A SAFETY ISSUE. WHAT IF THE RUSTED BRAKE LINES FOR BOTH SYSTEMS FAILED. AT THE VERY LEAST IT SEEMS THAT HAVING YOUR STOPPING DISTANCE INCREASE BY ALMOST DOUBLE WITH OUT WARNING IS A SAFETY ISSUE.

Electrical System; Exterior Lighting

ODI #10837117

Incident: July 12, 2010 · Filed: February 19, 2016

TL* THE CONTACT OWNS A 2003 CHEVROLET AVALANCHE. WHILE DRIVING APPROXIMATELY 65 MPH, THE INSTRUMENT PANEL FAILED. IN ADDITION, THE DRIVER SIDE HEADLIGHT FAILED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Service Brakes

ODI #10747108

Incident: July 29, 2015 · Filed: August 7, 2015

BRAKE LINE FAILURE: I HAD A RUPTURED STEEL BREAK LINE FAILURE WHILE APPLYING NORMAL BREAKING PRESSURE ON THE PEDAL. AFTER FURTHER INSPECTION OF BREAK LINES, I FOUND ALL BREAK LINES WERE RUSTED AND IN DANGER OF ALSO RUPTURE.

Steering

ODI #10725848

Incident: June 13, 2015 · Filed: June 17, 2015

THE OTHER DAY I STARTED NOTICING THAT WHEN I TURN RIGHT (OR LEFT IN REVERSE) AT A LOW RATE OF SPEED THE VEHICLE MAKES A CLUNKING NOISE AND MY STEERING IS AFFECTED. I STARTED LOOKING ONLINE FOR A REMEDY TO THIS PROBLEM AND FOUND THAT SEVERAL PEOPLE HAD THE SAME PROBLEM AND DID NOT KNOW WHERE TO REPORT IT. I DON'T FEEL IT IS FAIR THAT AS THE CONSUMER THAT I AM RESPONSIBLE FOR A DESIGN FLAW BY GM. I ALSO DON'T FEEL ITS FAIR TO HAVE TO SPEND UP $400 WHEN ITS ALL SAID AND DONE EACH TIME THAT IT WILL HAVE TO BE REPAIRED.

Service Brakes

ODI #10723547

Incident: June 3, 2013 · Filed: June 5, 2015

TL* THE CONTACT OWNS A 2003 CHEVROLET AVALANCHE. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE CONTACT DISCOVERED THAT THE BRAKE LINES NEAR THE DRIVER SIDE DOOR WERE RUSTED AND CORRODED, AND BRAKE FLUID HAD LEAKED FROM THE VEHICLE. THE CONTACT INDICATED THAT THE BRAKE LINES HAD BEEN PREVIOUSLY REPLACED ON THE VEHICLE DUE TO RUSTING AND CORROSION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 150,000.

Service Brakes, Hydraulic

ODI #10701341

Incident: March 23, 2015 · Filed: March 24, 2015

TL* THE CONTACT OWNS A 2003 CHEVROLET AVALANCHE.WHILE AT A TRAFFIC LIGHT, THE CONTACT COULD NOT DEPRESS THE BRAKE PEDAL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

Service Brakes

ODI #10691263

Incident: January 9, 2015 · Filed: February 28, 2015

VEHICLE EXPERIENCED COMPLETE BRAKE FAILURE UPON SLOWING FOR A TRAFFIC LIGHT. THIS WAS COMPOUNDED BY THE DOWNHILL ORIENTATION OF THE ROAD SURFACE. LEFT ROADWAY TO AVOID COLLISION WITH TRACTOR-TRAILER. THERE WAS NO WARNING OR INDICATION OF AN IMPENDING BRAKE FAILURE. NO INDICATION THAT ANY PART OF THE BRAKING SYSTEM WAS STILL FUNCTIONING. IT WAS DISCOVERED UPON INSPECTION THAT THE BRAKE LINES WERE EXCESSIVELY CORRODED COMPARED WITH OTHER BODY AND ENGINE COMPONENTS. METAL COMPOSITION OF BRAKE TUBING SEEMS VERY PRONE TO CORROSION. COMPLETE BRAKE LINE REPLACEMENT OF THE ENTIRE SYSTEM IS NOW NECESSARY. *TR

Service Brakes

ODI #10690668

Incident: February 24, 2015 · Filed: February 25, 2015

THE REAR BRAKE LINE BURST CATASTROPHICALLY AND MY BRAKE PEDAL WENT TO THE FLOOR. I WAS COMING UP TO STOPPED CARS AT AN INTERSECTION AND HAD TO SWERVE INTO THE ONCOMING LANE TO AVOID REAR ENDING ANOTHER TRUCK. LUCKILY THERE WERE NO CARS IN THE LANE AT THE TIME. I THEN HAD TO MAKE A SHARP TURN INTO A SHOPPING CENTER PARKING LOT TO AVOID RUNNING THROUGH THE INTERSECTION (WHICH DID HAVE TRAFFIC). I HAD ZERO BRAKING POWER WHATSOEVER. I TRIED PUSHING DOWN THE EMERGENCY BRAKE AND IT HAD NO EFFECT ( I LATER FOUND THAT THE EMERGENCY BRAKE LINES WERE FROZEN IN A LARGE CHUNK OF ICE NEAR THE DRIVERS SIDE REAR WHEEL AND WOULD NOT MOVE). THE PICKUP BED DRAINS DOWN ONTO THE LOWER FRAME IN THIS AREA AND THAT ACCOUNTED FOR THE ICE BUILDUP. I CONTINUED THROUGH THE SHOPPING CENTER PARKING LOT AND ALL I COULD TO WAS DOWNSHIFT TO SLOW MYSELF DOWN. LUCKY AGAIN...THE PARKING LOT WAS NEARLY EMPTY AND VERY LONG. AFTER ABOUT 4-500 FT I WAS GOING SLOW ENOUGH THAT I WAS ABLE TO JAM THE TRANSMISSION INTO PARK. THERE WAS NO WARNING OF THIS FAILURE. THE LINES WERE NOT LEAKING. I HAVE NOW READ ONLINE THAT GM HAS HAD MANY COMPLAINTS OF RUSTED LINES ON THEIR PICKUPS SUDDENLY FAILING. THIS COULD HAVE BEEN A LIFE THREATENING SITUATION. BRAKE LINES SHOULD NOT SUDDENLY FAIL. THEY SHOULD LAST THE LIFE OF THE VEHICLE. NON-CORROSIVE NICKLE COPPER BRAKE LINES EXIST THAT DO NOT RUST. THESE SHOULD BE MANDATORY ON ALL VEHICLES. *JS

Electrical System; Service Brakes; Engine

ODI #10679203

Incident: October 15, 2014 · Filed: January 27, 2015

IT STARTED WITH THE AIRBAG LIGHT, BUT NOBODY WILL OWN UP TO FIXING IT, AS WE MOVED FROM PA TO FL. THEN THE BRAKE LINES WENT, ALL OF THEM, NOW WITH THE AIRBAG ISSUE THE PCM IS SENDING ALL KINDS OF STUPID CODES LIKE THE AIRBAG ISSUE IS AFFECTING THE WHOLE ELECTRICAL SYSTEM IN THE TRUCK. *TR

Seats

ODI #10678976

Crash

Incident: January 24, 2015 · Filed: January 26, 2015

TL* THE CONTACT OWNS A 2003 CHEVROLET AVALANCHE 1500. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 5 MPH, THE DRIVERS SEAT RECLINED INDEPENDENTLY, WHICH CAUSED THE CONTACT TO CRASH WITH ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

Other Chevrolet Avalanche model years

Check your 2003 Chevrolet Avalanche VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Chevrolet Avalanche at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Chevrolet VIN