NHTSA vehicle safety data

2008 BMW K1200 GT Recalls & Complaints

The 2008 BMW K1200 GT has 7 NHTSA recall campaigns and 34 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized BMW dealer.

Includes campaigns NHTSA files under the spelling "K 1200 GT".

NHTSA recall and complaint data for the 2008 BMW K1200 GT. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2008 BMW K1200 GT owner complaints

Owners have filed 34 complaints with NHTSA about the 2008 BMW K1200 GT, describing incidents dated April 15, 2008 to February 10, 2021.

Most-cited components

Service Brakes 14 complaints
Fuel/Propulsion System 11 complaints
Power Train 8 complaints
Electrical System 1 complaint
Engine 1 complaint
Unknown or Other 1 complaint

Of the 34 complaints on file, 1 reports a crash and 1 a fire; across all 34 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11398414 · Filed March 1, 2021
THE FUEL PUMP FLANGE ON THIS 2008 BMW K1200GT IS LEAKING ONTO THE ENGINE BELOW. THIS IS A KNOWN PROBLEM WITH THIS MODEL AS SEEN IN THIS LINK: HTTPS://WWW.ASPHALTANDRUBBER.COM/RECALL/BMW-FUEL-FLANGE-LEAK-RECALL-2020/ AND ALSO AT THE LINK BELOW WHICH SHOWS NHTSA'S LETTER ABOUT THIS PROBLEM…
ODI #10886044 · Filed July 20, 2016
FUEL LEVEL SENSOR FAILURE. RAN OUT OF FUEL WHILE DRIVING AT HIGHWAY SPEEDS ON INTERSTATE 90 WESTBOUND NEAR MITCHELL, SD. FUEL GAUGE SHOWED 1/8 TANK OF FUEL. NO WARNING ISSUED BY MOTORCYCLE TO RIDER. BIKE JUST SUDDENLY SLOWED IN TRAFFIC. THIS IS 3RD TIME FOR THIS FAILURE.
ODI #10886042 · Filed July 20, 2016
FUEL LEVEL SENSOR FAILURE. RAN OUT OF FUEL WHILE DRIVING AT HIGHWAY SPEEDS ON INTERSTATE 90 EASTBOUND IN NY MILEPOST 460.5. FUEL GAUGE SHOWED 1/4 TANK OF FUEL. NO WARNING ISSUED BY MOTORCYCLE TO RIDER. BIKE JUST SUDDENLY SLOWED IN TRAFFIC. THIS IS 4TH TIME FOR THIS FAILURE (HAD IT REPAIRED BY BMW ON…

Read all 34 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2008 BMW K1200 GT in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA13-006: Fuel Leak - Motorycle
Closed January 31, 2014 · Filed for the K 1200 GT
- Recall 13V-617

Open and recently closed NHTSA defect investigations

Fuel Pump Flange may Leak

NHTSA #20V471000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported August 10, 2020 · BMW of North America, LLC

Potentially affected: 16,926 vehicles

Repair completion: 58.36% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 18, 2021

Defect description

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Safety consequence

A fuel leak in the presence of an ignition source can increase the risk of a fire.

Manufacturer remedy

BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Rear Wheel Mounting Flange may Crack

NHTSA #15V141000 · Wheels — Lugs/Nuts/Bolts/Studs · NHTSA notice

Reported March 11, 2015 · BMW of North America, LLC

Potentially affected: 43,426 vehicles

Repair completion: 60.91% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified May 7, 2015 · Vehicles built November 28, 2005 – April 4, 2008 (per NHTSA)

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2010 R1200GS and R1200RT, 2006-2010 R1200GS Adventure, 2007-2010 R1200R, 2007 R1200S and K1200R Sport, 2005-2007 R1200ST, 2008-2009 HP2 Megamoto, 2006 HP2 Enduro, 2008-2010 HP2 Sport, 2005-2008 K1200S, 2006-2008 K1200R, K1200GT, 2009-2011 K1300S, 2010-2011 K1300R, and 2009-2010 K1300GT motorcycles. In the affected motorcycles, the rear wheel mounting flange may crack if the rear wheel mounting bolts are over tightened.

Safety consequence

If the rear wheel mounting flange cracks, the mounting bolts may loosen and the rear wheel may not remain secured to the motorcycle, causing a loss of stability and increasing the risk of a crash.

Manufacturer remedy

BMW will notify owners, and dealers will replace the existing aluminum rear wheel flange with a steel one, free of charge. The recall began on May 7, 2015. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Fuel Pump Flange may Leak

NHTSA #13V617000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported December 12, 2013 · BMW of North America, LLC

Potentially affected: 50,184 vehicles

Repair completion: 59.33% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified April 16, 2014 · Vehicles built November 28, 2005 – April 4, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.

Safety consequence

A fuel leak in the presence of an ignition source may result in a fire.

Manufacturer remedy

BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at [email protected].

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

REAR WHEEL LINKAGE

NHTSA #10V488000 · Suspension — Rear · NHTSA notice

Reported October 8, 2010 · BMW OF NORTH AMERICA, LLC

Potentially affected: 11,826 vehicles

Owners notified March 30, 2011 · Vehicles built May 1, 2004 – August 31, 2008 (per NHTSA)

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2005-2011 MOTORCYCLES. THE BEARINGS COULD BE SUBJECT TO CORROSION. THIS COULD LEAD TO REDUCED MOVEMENT OF THE LINK LEVER.

Safety consequence

THIS COULD AFFECT THE HANDLING OF THE MOTORCYCLE INCREASING THE RISK A DRIVER MAY LOSE CONTROL OF THE VEHICLE RESULTING IN A CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRONT BRAKE LINES

NHTSA #10V276000 · Service Brakes, Hydraulic · NHTSA notice

Reported June 18, 2010 · BMW OF NORTH AMERICA, LLC

Potentially affected: 15,532 vehicles

Owners notified September 20, 2010

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 R 1200 AND K 1200 SERIES MOTORCYCLES MANUFACTURED FROM AUGUST 2006 THROUGH MAY 2009. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, AND THEREFORE ASSOCIATED VIBRATION. THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINE COULD SPLIT AND START TO DEVELOP A LEAK.

Safety consequence

IF THIS GOES UNNOTICED, AND THE BRAKE FLUID RESERVOIR RUNS EMPTY, THE FRONT BRAKES COULD FAIL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND DEALERS WILL INSTALL NEW BRAKE LINES, CONTAINING A "SLEEVE" ALONG A PORTION OF THE LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 20, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Notes

FRONT BRAKE DISC FASTENER

NHTSA #08V245000 · Service Brakes, Hydraulic — Foundation Components — Disc · NHTSA notice

Reported June 4, 2008 · BMW OF NORTH AMERICA, LLC

Potentially affected: 548 vehicles

Owners notified August 1, 2008 · Vehicles built January 11, 2008 – January 16, 2008 (per NHTSA)

Defect description

BMW IS RECALLING 548 MY 2008 K1200 S AND GT MOTORCYCLES. THE FASTENERS USED TO SECURE THE FRONT BRAKE-DISC MAY NOT BE LONG ENOUGH TO ENSURE A SECURE MOUNTING. OVER TIME, THESE FASTENERS COULD LOOSEN. IF THAT HAPPENED, THE BRAKE DISC WOULD NO LONGER BE SECURELY MOUNTED.

Safety consequence

FAILURE TO OBSERVE THE FOLLOWING PRECAUTIONS, IN CONJUNCTION WITH TRAFFIC AND ROAD CONDITIONS, AND THE RIDER'S REACTIONS, COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND INSTALL A LONGER FRONT BRAKE DISC FASTENERS AND REROUTE THE SENSOR CABLE FREE OF CHARGE. THE RECALL BEGAN DURING AUGUST 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

OIL DUCT

NHTSA #08V239000 · Engine and Engine Cooling — Engine · NHTSA notice

Reported June 2, 2008 · BMW OF NORTH AMERICA, LLC

Potentially affected: 39 vehicles

Owners notified August 1, 2008 · Vehicles built December 11, 2007 – January 9, 2008 (per NHTSA)

Defect description

BMW IS RECALLING 30 MY 2008 K1200 S AND K1200 GT MOTORCYCLES. A SET SCREW MAY NOT HAVE BEEN INSTALLED AT ITS SPECIFIC LOCATION WITHIN THE OIL DUCT. CONSEQUENTLY, AN ADEQUATE SUPPLY OF OIL MAY NOT CIRCULATE WITHIN THE ENGINE.

Safety consequence

IT IS POSSIBLE THAT CONNECTING ROD AND CRANKSHAFT DAMAGE COULD OCCUR. IF THIS HAPPENED, THE ENGINE COULD SEIZE. IF THE MOTORCYCLE WAS IN GEAR, ENGINE SEIZING COULD RESULT IN LOCK-UP OF THE REAR TIRE, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A SET SCREW IN THE OIL DUCT. THE RECALL BEGAN DURING AUGUST 2008. OWNERS MAY CONTACT BMW AT 1-800-331-1117.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2008 BMW K1200 GT. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

34 owner complaints have been filed with NHTSA for the 2008 BMW K1200 GT.

Fuel/Propulsion System

ODI #11398414

Incident: February 10, 2021 · Filed: March 1, 2021

THE FUEL PUMP FLANGE ON THIS 2008 BMW K1200GT IS LEAKING ONTO THE ENGINE BELOW. THIS IS A KNOWN PROBLEM WITH THIS MODEL AS SEEN IN THIS LINK: HTTPS://WWW.ASPHALTANDRUBBER.COM/RECALL/BMW-FUEL-FLANGE-LEAK-RECALL-2020/ AND ALSO AT THE LINK BELOW WHICH SHOWS NHTSA'S LETTER ABOUT THIS PROBLEM HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2020/RCAK-20V471-2669.PDF ON MY MOTORCYCLE GAS IS LEAKING OUT FROM THE SAME FUEL PUMP FLANGE AND LEAKING DOWN ONTO THE ENGINE.. THIS IS A FIRE HAZARD AS NOTED IN NHTSA'S REPORT. I HAVE INCLUDED A YOUTUBE VIDEO LINK BELOW THAT SHOWS HOW AND WHERE THE GAS IS LEAKING OUT FROM MY GAS TANK. THIS OCCURS IF THE BIKE IS STATIONARY OR IN MOTION. SEE BELOW: HTTPS://WWW.YOUTUBE.COM/WATCH?V=PWUSMVRBN8M I AM ASKING THAT MY BMW MOTORCYCLE BE INCLUDED IN THIS RECALL AS IT HAS THE SAME PROBLEM AS THE OTHER 2008 K1200GT BIKES THAT WERE COVERED. I AM NOT SURE WHY MY BIKE WOULD NOT ALSO BE IN THAT RECALL.

Fuel/Propulsion System

ODI #10886044

Incident: July 20, 2015 · Filed: July 20, 2016

FUEL LEVEL SENSOR FAILURE. RAN OUT OF FUEL WHILE DRIVING AT HIGHWAY SPEEDS ON INTERSTATE 90 WESTBOUND NEAR MITCHELL, SD. FUEL GAUGE SHOWED 1/8 TANK OF FUEL. NO WARNING ISSUED BY MOTORCYCLE TO RIDER. BIKE JUST SUDDENLY SLOWED IN TRAFFIC. THIS IS 3RD TIME FOR THIS FAILURE.

Fuel/Propulsion System

ODI #10886042

Incident: July 14, 2016 · Filed: July 20, 2016

FUEL LEVEL SENSOR FAILURE. RAN OUT OF FUEL WHILE DRIVING AT HIGHWAY SPEEDS ON INTERSTATE 90 EASTBOUND IN NY MILEPOST 460.5. FUEL GAUGE SHOWED 1/4 TANK OF FUEL. NO WARNING ISSUED BY MOTORCYCLE TO RIDER. BIKE JUST SUDDENLY SLOWED IN TRAFFIC. THIS IS 4TH TIME FOR THIS FAILURE (HAD IT REPAIRED BY BMW ON AUG 5, 2015)

Service Brakes

ODI #10883550

Incident: January 4, 2011 · Filed: July 8, 2016

ABS FAILED WITH NO WARNINGS, TOTAL LOSS OF BRAKING POWER. I BELEIVE THIS WAS A SIGNIFICANT FAILIURE. HAPPEND ON MY BROTHERS BIKE AS WELL 2 MONTHS LATER. LESS THEN 30K MILES AND JUST PAST 3 YEARS... HAPPENED DURING RIDE ON FREEWAY ON FIRST USE OF BRAKE. I HAD TO PAY TO REPLACE. BMW CLAIMED IT IS NOT SIGNIFICANT AND NOT A PROBLEM.

Fuel/Propulsion System

ODI #10777932

Crash Fire 1 injury

Incident: July 19, 2011 · Filed: September 27, 2015

7/19/11 SINGLE VEHICLE ACCIDENT, 5-10 MPH, WHEN GAS CAP CAME OPEN AND FUEL DUMPED ALL OVER VICTIM AND MOTORCYCLE. RIDER 2ND AND 3RD DEGREE BURNS OVER 40% OF HIS BODY, ULTIMATELY RESULTED IN AMPUTATION OF BOTH LEGS. PREVIOUS TO THE ACCIDENT, DRIVER TOOK THE MOTORCYCLE TO DEALERSHIP MULTIPLE TIMES TO REPORT GAS CAP WOULD COME OPEN WHILE DRIVING BIKE DOWN THE ROAD. DEALERSHIP NEVER FIXED GAS CAP.

Power Train

ODI #10776511

Incident: May 25, 2012 · Filed: September 24, 2015

FIRST INDICATION OF THE FINAL DRIVE FAILING WAS A CLUNKING SOUND FROM THE REAR WHEN RUNNING OVER EXPANSION JOINTS AT HIGHWAY SPEED ,5/25/12 @ 15,784 MILES. THERE WAS NO EXTERNAL OIL LEAK. THE DEALER MADE REPAIR AT MY EXPENSE. SECOND FAILURE ON DAY TRIP 9/24/15 @ 26,687 NOTICED CLUNKING RIDING ON ROUGH PAVEMENT COMING FROM REAR OF BIKE,SPEED APPROXIMATELY 45MPH. AGAIN NO OIL LEAK AND WHEEL RIM AGAIN WOBBLES AT 9 AND 3 O'CLOCK AND 6 AND 12 O'CLOCK. TAKING TO DEALER 9/25/15 AND SEE WHAT THEY HAVE TO SAY ABOUT SECOND FAILURE!

Service Brakes

ODI #10744794

Incident: July 23, 2015 · Filed: July 29, 2015

ABS PUMP FAILURE.

Service Brakes

ODI #10735021

Incident: July 18, 2015 · Filed: July 19, 2015

REAR DRIVE BEARINGS AND WHEEL SIDE SEAL FAILED GEAR LUBE ON REAR BRAKE PADS AND REAR BRAKES QUIT WORKING. TIRE TREAD CONTAMINATED WITH LUBE MAKING GREATLY REDUCED TRACTION. NEARLY LOST CONTROL OF VEHICLE ON STOPPING DUE TO CHANGE IN THE VEHICLE DYNAMICS AND LOSS OF REAR WHEEL TRACTION AS THE FAILURE DID NOT CAUSE ANY INDICATION THAT THIS HAD HAPPENED UNTIL STOPPING. THE REAR DRIVE WAS SERVICED BY THE DEALER WITHIN THE LAST 4 MONTHS MARCH 2015 AT 11,400 MILES OR SO. I HAVE NEVER HAD A FAILURE ON SUCH A MAJOR SAFETY RELATED COMPONENT SUCH AS THIS ON ANY VEHICLE I HAVE OWNED AT SUCH A RELATIVELY LOW TOTAL VEHICLE MILEAGE LEVEL.

Power Train

ODI #10701118

Incident: May 20, 2012 · Filed: March 23, 2015

ON MY WAY HOME AFTER A 250 MILE RIDE, ABOUT 5 MILES FROM HOME WHEN I WOULD RIDE OVER A ROAD SEAM THE BIKE WOULD HESITATE. WHEN I ARRIVED HOME I PUT THE BIKE ON CENTER STAND AND SHOOK REAR WHEEL AT FROM THE 3 TO 9 O'CLOCK POSITIONS, THERE WAS AT LEAST 3/8" OF AN INCH PLAY SIDE TO SIDE AND 6AND 12 O'CLOCK. THERE WAS NO EXTERNAL OIL LEAKING FROM FINAL DRIVE. I CALLED THE DEALER TO SCHEDULE SERVICE.BROUGHT BIKE IN 5/25/12 WAS TOLD THE BEARING FAILED IN FINAL DRIVE. COST OF REPAIR $888.58, HAD FINAL DRIVE REPAIRED AND PICKED UP 5/31/12. THIS WAS AN EXPENSE THAT THEY DID NOT COVER! *TR

Service Brakes

ODI #10658863

Incident: February 4, 2013 · Filed: November 18, 2014

THE ABS BRAKE WARNING LIGHT CAME ON. I TOOK THE MOTORCYCLE TO MY AUTHORIZED BMW DEALER IN LONG BEACH, CA. THEY SAID THAT THE ABS BRAKE MODULE HAD FAILED; HOWEVER THEY REFUSED TO REPAIR OR REPLACE THE FAULTY UNIT. I SENT IT OUT TO AN INDEPENDENT REPAIR FACILITY AND THEY REPAIRED THE UNIT AT MY COST. I THEN HAD THE UNIT REINSTALLED BY MY BMW DEALER AT MY COST. *TR

Other BMW K1200 GT model years

Check your 2008 BMW K1200 GT VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW K1200 GT at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN