NHTSA vehicle safety data

2006 BMW 550I Recalls & Complaints

The 2006 BMW 550I has 3 NHTSA recall campaigns and 23 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized BMW dealer.

NHTSA recall and complaint data for the 2006 BMW 550I. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 BMW 550I owner complaints

Owners have filed 23 complaints with NHTSA about the 2006 BMW 550I, describing incidents dated August 1, 2008 to August 28, 2023.

Most-cited components

Air Bags 13 complaints
Electrical System 3 complaints
Engine 3 complaints
Service Brakes 2 complaints
Steering 2 complaints
Wheels 2 complaints

Of the 23 complaints on file, 3 report a crash; across all 23 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11541934 · Filed August 31, 2023
The contact owns a 2006 BMW 550I. The contact stated that while operating the vehicle, the front passenger’s side air bag warning light remained illuminated. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was…
ODI #11321429 · Filed April 17, 2020
I WAS DRIVING HOME AND FELT THE CAR LEANING TO ONE SIDE (PASSENGER SIDE) I DROVE SLOWLY WITH HAZARD LIGHTS ON MADE IT HOME AND CHECKED UNDER VEHICLE LOOKED LIKED THE BOLT CAME OFF AND BAR CONNECTED TO TIRE WAS DROPPED HAD IT TOWED TO SHOP AND WAS TOLD CONTROL ARM NEEDED TO BE REPLACED . ANOTHER…
ODI #11279298 · Filed November 10, 2019
NEXEN TIRES N5000 PLUS SIDEWALL ON ALL TIRES ARE STARTING TO CRACK AND SPLIT WITH LESS THAN 30,000 MILES AND 24 MONTHS OF USE. GOING TO REPLACE TIRES WITH ANOTHER BRAND AND REMOVE THESE DUE TO UNSAFE AND POTENTIAL CATASTROPHIC FAILURE OF TIRES COMING APART OR BLOWOUT AT HIGHWAY SPEEDS..

Read all 23 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2006 BMW 550I in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA08-001: BMW AIRBAG LIGHT ILLUMINATION
Closed December 31, 2008
- Recall 08V-384

Open and recently closed NHTSA defect investigations

Front Passenger Seat Occupant Detection Mat Defect

NHTSA #17V428000 · Air Bags — Sensor — Occupant Classification · NHTSA notice

Reported July 6, 2017 · BMW of North America, LLC

Potentially affected: 2,158 vehicles

Repair completion: 30.36% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified September 1, 2017 · Vehicles built November 23, 2005 – November 30, 2005 (per NHTSA)

Defect description

BMW of North America, Inc. (BMW) is recalling certain 2006 325i, 325xi, 330i, 330xi, 525i, 525xi, 530i, 530xi, and 550i vehicles equipped with the Sport Seat option and certain 2006 525i, 525xi, 530i, 530xi, 550i vehicles with standard seats. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.

Safety consequence

Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.

Manufacturer remedy

BMW will notify owners, and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, replacing it as necessary, free of charge. The recall began September 1, 2017. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Front Seat Occupant Protection Mat Defect

NHTSA #13V564000 · Air Bags — Sensor — Occupant Classification · NHTSA notice

Reported November 12, 2013 · BMW of North America, LLC

Potentially affected: 76,565 vehicles

Repair completion: 45.89% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified August 29, 2014 · Vehicles built December 1, 2005 – September 29, 2006 (per NHTSA)

Defect description

BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.

Safety consequence

Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.

Manufacturer remedy

BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at [email protected].

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

ENGINE ELECTRONICS

NHTSA #07V479000 · Engine and Engine Cooling · NHTSA notice

Reported October 12, 2007 · BMW OF NORTH AMERICA, LLC

Potentially affected: 29,250 vehicles

Owners notified October 29, 2007 · Vehicles built August 26, 2005 – June 14, 2007 (per NHTSA)

Defect description

ON CERTAIN VEHICLES EQUIPPED WITH V8 ENGINES, IN CONDITIONS OF BELOW FREEZING TEMPERATURES COMBINED WITH LOW HUMIDITY, IT IS POSSIBLE FOR ELECTROSTATIC DISCHARGE TO OCCUR AT THE FUEL RAILS. IF THIS WERE TO OCCUR, THE ENGINE ELECTRONIC CONTROL UNIT (ECU) COULD BE AFFECTED SO THAT ENGINE STALLING COULD RESULT.

Safety consequence

IF STALLING WERE TO OCCUR, THE DRIVER MAY NOT BE ABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE AND THE POWER STEERING COULD FAIL INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL ATTACH TWO GROUND CABLES IN THE ENGINE COMPARTMENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 BMW 550I. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

23 owner complaints have been filed with NHTSA for the 2006 BMW 550I.

Air Bags

ODI #11541934

Incident: August 28, 2023 · Filed: August 31, 2023

The contact owns a 2006 BMW 550I. The contact stated that while operating the vehicle, the front passenger’s side air bag warning light remained illuminated. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 17V428000 (Air Bags). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 184,000.

Suspension; Engine

ODI #11321429

Incident: October 9, 2019 · Filed: April 17, 2020

I WAS DRIVING HOME AND FELT THE CAR LEANING TO ONE SIDE (PASSENGER SIDE) I DROVE SLOWLY WITH HAZARD LIGHTS ON MADE IT HOME AND CHECKED UNDER VEHICLE LOOKED LIKED THE BOLT CAME OFF AND BAR CONNECTED TO TIRE WAS DROPPED HAD IT TOWED TO SHOP AND WAS TOLD CONTROL ARM NEEDED TO BE REPLACED . ANOTHER SITUATION I HAD WITH MY CAR WAS THE COOLING SYSTEM AND THE OIL I WAS BUYING BOTTLES OF COOLANT AND OIL WEEKLY TOOK IT INTO SHOP AND WAS TOLD COMPLETE COOLING SYSTEM NEEDED TO BE REPLACED AS I WAS DRIVING HOME CAR STARTED TO OVERHEAT SO I STOPPED AS RECOMMENDED AND LET IT COOL MADE IT HOME THEN HAD VEHICLE TOWED TO SHOP THEY ORDERED ALL PARTS AND HOSES FOR COOLING SYSTEM NOW MY CAR SMOKE AT THE EXHAUST WHEN SITTING IDLE FOR A FEW MINUTES THEN WHEN I PUSH ON THE GAS BIG CLOUDS OF WHITE SMOKE COME FROM EXHAUST. *TR

Tires; Wheels

ODI #11279298

Incident: November 10, 2019 · Filed: November 10, 2019

NEXEN TIRES N5000 PLUS SIDEWALL ON ALL TIRES ARE STARTING TO CRACK AND SPLIT WITH LESS THAN 30,000 MILES AND 24 MONTHS OF USE. GOING TO REPLACE TIRES WITH ANOTHER BRAND AND REMOVE THESE DUE TO UNSAFE AND POTENTIAL CATASTROPHIC FAILURE OF TIRES COMING APART OR BLOWOUT AT HIGHWAY SPEEDS..

Electrical System; Exterior Lighting

ODI #11184225

Incident: March 2, 2019 · Filed: March 4, 2019

HEADLIGHT WIRE INSULATION FLAKING OFF AND WIRES ARE SHORTING CAUSING HEADLIGHT TO GO OFF. WIRES SHORT AND ARCING. THE HEADLIGHT WENT OFF WHILE DRIVING ON HIGHWAY AT NIGHT.

Air Bags

ODI #11091046

Incident: April 5, 2016 · Filed: April 30, 2018

TL* THE CONTACT OWNS A 2006 BMW 550I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 13V564000 (AIR BAGS); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO BMW OF LAS VEGAS (6900 W SAHARA AVE, NV 89117, (702) 570-0279), BUT THE PART WAS NOT AVAILABLE FOR THE REPAIR. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Engine; Fuel/Propulsion System

ODI #11023311

Incident: September 7, 2017 · Filed: September 13, 2017

THERE IS FUEL LEAKING FROM THE MAIN FUEL LINE TO THE FUEL RAIL. EXTREMELY DANGEROUS UPON RESEARCH I HAVE FOUND THAT THIS IS A COMMON PROBLEM WITH MY MODEL WHICH EXPLAINS WHY BMW'S CATCH FIRE. DOES SOMEONE HAVE TO DIE BEFORE THEY FIX THIS PROBLEM?

Service Brakes

ODI #10859879

Incident: April 16, 2016 · Filed: April 16, 2016

ALTOUGH MY 2006 BMW 550I V8 IS HARD TO STOP AND FALLS UNDER BMW BRAKE VACUUM PUMP RECALL RELEASED NOVEMBER 2010, FOR SOME REASON MY VIN DOESNT BRING UP THE RECALL. BMW REFUSED TO FIX.A WASTED 1 HOUR TRIP AND DAY.

Air Bags

ODI #10821291

Incident: January 20, 2016 · Filed: January 20, 2016

FRONT PASSENGER AIR BAG LIGHT WARMING ON I-DRIVE AND AIR BAD LIGHT LIT ON DASH. PASSENGER RESTRAINT FAILURE. FAULT IN PASSENGER RESTRAINT SYSTEM AFFECTING AIR BAG,BELT TENSIONER OR BELT-FORCE LIMITER.FASTEN AND CONTINUE TO WEAR BELTS. ON 24-7. FROM THE MOMENT YOU START THE CAR TILL THE MOMENT YOU SHUT IT OFF.

Electrical System

ODI #10720982

Incident: January 1, 2015 · Filed: May 22, 2015

DEFECTIVE ELV STEERING LOCK PREVENTS THE CAR FROM STARTING. THE LOCK CAN'T BE DISABLED. THIS SHOULD BE A RECALL. THE LOCK IS UNNNECSSARY FOR SAFE OPERATION OF THE VEHICLE. THE LOCK CAN'T BE DISABLED. AT THE VERY LEAST, THE OWNER SHOULD BE ABLE TO DISABLE IT.

Steering; Wheels

ODI #10694319

Incident: March 15, 2015 · Filed: March 15, 2015

MY 06 BMW 550I IS HAVING AN ELECTRIC WHEEL LOCK FAULT JUST LIKE THOUSANDS OF OTHERS THIS AS YOU KNOW COULD POSSIBLY LEAD TO AN ACCIDENT. IT IS MY UNDERSTANDING THAT BMW HAS ISSUED A SERVICE BULLETIN ACKNOWLEDGING THE ISSUE. ANY ASSISTANCE IS GREATLY APPRECIATED. *TR

Other BMW 550I model years

Check your 2006 BMW 550I VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW 550I at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN