2012 BMW 550I Recalls, Ratings & Complaints

Incident: August 2, 2026 · Filed: October 26, 2026

2012 BMW with the N63 twin-turbo V8 engine, excessive oil consumption

Incident: September 1, 2023 · Filed: September 2, 2023

I was driving when the vehicle engine randomly shut down with out warning I was on the freeway at the time and could have been hit by a car. I took thr car to an auto repair shop, had the problem inspected snddiagnosed and was told the engine was faulty. I had the engine replaced and the same issue occurred. There were no warning lamps, messages, or alerts prior to the problem occurring. The drivetrain malfunction light came on as soon as the engine cut off.

Incident: August 1, 2021 · Filed: November 30, 2021

The contact owns a 2012 BMW 550i. The contact stated after parking and exiting the vehicle, he noticed coolant leaking on the front driver’s side and saw white smoke exiting near the water pump. The contact stated the low coolant fluid and the drivetrain malfunction warning lights were illuminated. The contact stated the smoke disappeared on its own. The contact stated that he continued driving the vehicle. The contact took the vehicle to an independent mechanic and was informed that the water pump needed to be replaced. The vehicle was not repaired. The contact took the vehicle to the local dealer, where it was diagnosed with needing the water pump to be replaced. The vehicle was not repaired but was pending repairs. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V248000 (Engine and Engine Cooling) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 60,000.

Incident: October 25, 2021 · Filed: November 17, 2021

My car died in an intersection unexpectedly as if my battery had died. My infant was in the backseat. This was suck a busy intersection that police dept had to park behind me to keep me from being hit. The car could not be put in neutral to move it out of the way. After over an hour we were able to restart the car and excessive battery discharge message displayed. This is on top of me taking it to the dealership for excessive oil consumption and BMW was aware my motor would eventually give out.

Incident: May 26, 2021 · Filed: July 10, 2021

Engine is available for inspection upon request. Earlier this month, my 550i completely shut off at a traffic light. When attempting to restart the engine, the Starter strained very hard and smoke came out of the engine. Engine was immediately shut off and the car was towed to a local shop. In turn the shop replaced the Starter the following day and heard knocking from the engine once it turned it over. Upon examination the shop pulled open the oil filter and it was full of metal shrapnel. I feel fortunate the car was not in motion at the time of the failure, given the engine shut off with no warning this could have resulted in a catastrophic accident.

Incident: May 7, 2021 · Filed: June 23, 2021

2012 F10 had issues while running as car installed and stopped completely multiple times in traffic. Fuel supply sign came on. Diagnosed as low pressure fuel pump degraded and need replacement. Same recall took place for 2007-2011 5 series model as well via recall campaign No. 16v-746: In-Tank Fuel Pump. 2012 have same issue and very dangerous to drive on road when vehicle stalls and stops while driving in traffic

Incident: February 16, 2021 · Filed: March 4, 2021

THE HIGH PRESSURE FUEL PUMP CAUSED A FIRE IN THE ENGINE COMPARTMENT AND TOTALED THE CAR WITH LESS THAN 60K MILES ON IT

Incident: March 1, 2020 · Filed: September 28, 2020

TL* THE CONTACT OWNS A 2012 BMW 550I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVETRAIN MALFUNCTION WARNING LIGHT APPEARED ON THE INSTRUMENT PANEL. THE CONTACT ALSO NOTICED THAT THE WARNING LIGHT WAS ILLUMINATED UPON DEPRESSING THE ACCELERATOR PEDAL. THE CONTACT ALSO STATED THAT THE VEHICLE HESITATED WHEN THE FAILURE OCCURRED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO REPLACED A SINGULAR COIL AND A SPARK PLUG. TWO MONTHS LATER, THE SAME FAILURE RECURRED AND THE CONTACT TOOK THE VEHICLE BACK TO THE INDEPENDENT MECHANIC WHERE THEY REPLACED ALL THE COILS AND SPARK PLUGS. UPON RETURN OF THE VEHICLE, THE CONTACT WAS DRIVING HOME AND THE VEHICLE SHUT-OFF WITHOUT WARNING. THE VEHICLE WAS TOWED BACK TO THE SAME INDEPENDENT MECHANIC. UPON FURTHER INSPECTION OF THE VEHICLE, THE MECHANIC DETERMINED THAT THE OIL PUMP TIMING CHAIN WAS LOOSENED AND NEEDED TO BE REPLACED. UPON INVESTIGATION, THE CONTACT LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 16V746000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VEHICLE WAS NOT INCLUDED. THE CONTACT REACHED OUT TO A DEALER AND WAS INFORMED THAT A DIAGNOSTIC NEEDED TO BE PERFORMED TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT DECLINED THE DIAGNOSTIC TEST. THE CONTACT ALSO EMAILED THE MANUFACTURER WHO INFORMED HIM TO TAKE THE VEHICLE TO A LOCAL DEALER FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000.

Incident: September 25, 2020 · Filed: September 27, 2020

VEHICLE STOPS SUDDENLY WHILE DRIVING

Incident: May 21, 2020 · Filed: May 26, 2020

TL* THE CONTACT OWNS A 2012 BMW 550I GRAN TURISMO. THE CONTACT STATED THAT WHILE HER SON WAS DRIVING AT 45 MPH, THE VEHICLE LOSS POWER AND STALLED WITHOUT WARNING. THE VEHICLE WAS PULLED TO THE SIDE OF THE ROAD AND RESTARTED. THE VEHICLE JERKED. THE VEHICLE WAS TAKEN TO THE CLASSIC BMW LOCATED AT 6800 DALLAS PKWY, PLANO, TX 75024, (214) 778-2600, WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP AND THE SPARK PLUGS NEEDED TO BE REPLACED. THE CONTACT WAS TOLD THAT THERE WAS NO RECALL. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.