2021 BMW 530I Recalls & Complaints

Incident: May 6, 2026 · Filed: May 6, 2026

The recall 25V-636 remains unresolved after more than 6 month passed since the manufacturer issued the campaign regarding the engine starter. I would like to see the NHTSA to put the manufacturer on notice that this is unacceptable. We cannot park the vehicle outside of structures permanently as this devalues the vehicle and creates a loss of use.

Incident: March 21, 2026 · Filed: March 21, 2026

I have a 2021 BMW 530i. VIN [XXX] . I brought my vehicle to Pompano Beach BMW and Coconut Creek BMW in Florida. They said both my motor mounts have collapsed. I have discussed the matter with other experts and mechanics, and been told the failure of motor mounts is a serious safety issue and vehicle defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 23, 2025 · Filed: March 19, 2026

The contact owns a 2021 BMW 530I. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Incident: January 10, 2026 · Filed: January 10, 2026

Good afternoon, I am writing regarding the recall affecting my BMW 2021 530i, VIN [XXX] . While I understand the importance of safety recalls, this issue has had a direct and measurable impact on the market value of my vehicle. Due to the recall, I have received reduced trade-in and resale offers, with dealers explicitly citing the recall as a reason for depreciation. This loss in value persists regardless of whether the recall remedy has been completed. I am therefore requesting compensation ($6000) for the depreciation caused by this recall, or financial adjustment or trade in. Please open a case on my behalf and advise on the next steps. I would appreciate this matter being reviewed by a regional case manager if necessary. Thank you for your attention. I look forward to your response. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: September 23, 2025 · Filed: December 2, 2025

The contact owns a 2021 BMW 530I. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System). The contact called a local dealer several times and was advised that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed. The contact had not experienced a failure.

Incident: August 28, 2025 · Filed: November 28, 2025

The contact owns a 2021 BMW 530I. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the remote starter of the vehicle had failed to function as intended, and the key fob was inoperable. The contact replaced the key fob battery three times, but the failure persisted. The contact stated that upon taking the vehicle to an independent mechanic to have the brakes replaced, the mechanic informed the contact of the remote starter failure. Additionally, the contact stated that the brakes had been replaced three times. The independent mechanic was unable to determine the cause of the failure. The local dealer was not contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.

Incident: June 15, 2025 · Filed: June 16, 2025

The contact owns a 2021 BMW 530I. The contact stated that upon starting the vehicle, the vehicle hesitated. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed with motor mount failure. There was an abnormal pulling sound detected. The vehicle was not repaired. The contact spoke with two experts and was informed that the failure should not have occurred. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000.

Incident: February 20, 2025 · Filed: February 20, 2025

I have a code Passanger restraint failure that will not come off unless I pay $2700 to fix. This coding came on after 3 months of getting the vehicle and I’m not the only with the same issue. This is a dangerous situation that Bmw is not recalling but putting this as the owners expense. If I were to get in an accident this will not deploy airbags or open the seat belt this can cause sever injuries or worst death.

Incident: December 30, 2024 · Filed: January 16, 2025

Subject: Urgent Issue with EVAP System Failure Dear Safety Highway Control, I discovered that the EVAP system in my car has failed, confirmed by a computer diagnostic at the Body Shop. The dealer mentioned no recalls, so I contacted the recall department who advised me to contact you. The check engine light has been on, prompting this urgent report. Your prompt investigation is greatly appreciated. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: April 3, 2023 · Filed: November 26, 2024

I went to hospital several times - the car had defect of manufacture- gas fume released inside the car every time i drove the car I had nausea, drowsiness, vomiting because the car at the beginning was new I never assume the car was causing me illness which had a tremendously impact in to my health. I had to buy new cloth, new mattress and changed the carpet. My health was also impacted - I was diagnosed with granulomas on my lungs. the fume is clear, the cloth will smell gas, and particles of gasoline hazard will attached to the skin giving an allergic sensation. This almost killed and I was not aware that the car was causing this impact on my daily life.