2007 BMW 530I Recalls & Complaints

Incident: August 25, 2025 · Filed: September 28, 2025

BMW 530I headlights have faulty wiring. Insulation is crumbling an severly degraded leaving bare wires exposed to short circuits. Discovered the faulty wire when I went to replace the parking / angel eye lights. I have attempted to solve the problem short term with electrical tape. As soon as you touch the wire to put electrical tape on it, more of the faulty insulation comes off. Wire has essentially lost all insulation.

Incident: June 16, 2023 · Filed: June 19, 2023

I purchased my BMW & got inside to drive off jumping on 275 freeway & the whole car just started smoking out nowhere the whole car was scorching hot & smoking other cars had to literally pull over because of so much white smoke I took it to several certified car doctors & they all refused to touch it because of the PVC recall valve

Incident: November 10, 2022 · Filed: June 3, 2023

Well was driving fine one day then the next it didn't do nothing an still hasn't done or moved since found that the module in the truck were the spare was got wet an melted then I got another put it in an still nothing changed starter still nothing an found out a recall was found called bmw but they wasn't willing to have it towed to a service provider

Incident: January 7, 2023 · Filed: January 25, 2023

The contact owns a 2007 BMW 530I. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that while driving at approximately 65 MPH, there was smoke coming from the hood. The "transmission overheating" message was displayed. The vehicle was inoperable. The vehicle was towed to an independent mechanic, where it was diagnosed that the PCV valve and transmission needed to be replaced. The vehicle remained with the independent mechanic awaiting the repair. The manufacturer was made aware of the failure. The approximate failure mileage was 170,000. The VIN was not available.

Incident: August 23, 2018 · Filed: August 23, 2022

The contact owns a 2007 BMW 530I. The contact stated while driving at various speeds, there was an abnormal burning odor coming from the A/C vents. The contact also noticed the burning odor whenever opening the hood. The message "Service Engine Soon" was displayed. The contact later received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). However, the parts to do the recall repair were not yet available. The local dealer was not contacted. The contact stated while driving 65-70 MPH, he noticed smoke coming out from underneath the hood of the vehicle. The contact veered to the side of the road for a moment and then opened the hood. The contact was able to continue driving. The contact stated that the failure had reoccurred on two different occasions. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 175,000. VIN tool confirms parts not available.

Incident: December 9, 2019 · Filed: July 9, 2021

The contact owns a 2007 BMW 530i. The contact stated while driving at various speeds, the brakes would not engage when the brake pedal was depressed. The contact also stated that he had to use additional force on the brake pedal to stop the vehicle. The contact stated no warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with the vacuum hose and the brake booster needing to be replaced. The vehicle was not repaired. The contact was relating the failure to NHTSA campaign number: 10V446000 (Service Brakes, Hydraulic). The manufacturer had been informed of the failure and referred the contact to the local dealer. The failure mileage was approximately 137,745.

Incident: December 20, 2020 · Filed: March 29, 2021

ELECTRICAL PROBLEMS AND TRANSMISSION REPAIR ISSUES

Incident: July 2, 2020 · Filed: July 12, 2020

BRAKE PRESSURE LOSS, UNABLE TO STOP VEHICLE IN A SAFE MANNER. BRAKE PEDAL WENT TO THE FLOOR. CHECKED BRAKE FLUID RESERVOIR & FLUID LEVEL LOW. DEEPER INSPECTION REVEALED CORRODED REAR BRAKE HARD LINE. VERY COMMON ON E60 & PREVIOUS GENERATION E39 BMW'S.

Incident: September 15, 2019 · Filed: June 10, 2020

MY CAR WAS IN MY DRIVEWAY. MY COMPLAINT IS I JUST BOUGHT THE CAR FROM A FRIEND OF OUR FAMILY AND EVERYTHING WAS. ABOUT A MONTH LATER WHEN I START THE CAR I GET THIS ERROR" FAULT IN PASSENGER RESTRAINT SYSTEM EFFECTING AIRBAG-BELT TENSIONER OR BELT FOR DELIMITER. SO I CALL BMWUSA TO SEE IF THIS WAS RECALLED. THE MAN I SPOKE WITH SAID YES IT WAS BUT I LET ME HAVE YOUR VIN# OH NO I'M SORRY NOT FOR YOUR VIN " I WAS SHOCKED TO THINK IT WOULD BE A RECALL ON ONE BUT NOT ANOTHER. IF IT IS EFFECTING MY AIR BAG U WOULD THINK. IT WOULD BE A SAFETY ISSUE FOR ALL CARS THAT GET THAT ERROR. OR WAS THAT CAR BUILT KNOWING IT WAS EVENTUALLY GOING TO GO OUT AND WE THE CUSTOMERS ARE GOING TO HAVE TO PAY FOR IT. I WOULD RATHER NOT HAVE THAT AT ALL. IT MAKES NO SENSE. ESPECIALLY IF YOUR OK TO FIX SOME CARS AND NOT ALL OF THEM AFTER ALL WHY WOULD WE WANT SOMETHING IN THE CAR IF WE KNOW ONE ITS JUST GOING TO GO OUT AND WE HAVE TO PAY FOR IT. AND FOR THE SAFETY PART . IT EVEN SOUNDS MORE CRAZY THAT SOMETHING LIKE THAT COULD MALFUNCTION AND I NOT EVEN SURE IF ANYBODY SHOULD RIDE IN MY PASSENGER SEAT. WELL IT'S [XXX] AT [XXX] IF YOU HAVE ANY QUESTIONS THANK YOU FOR YOUR TIME AND HAVE A WONDERFUL DAY. GOOD BLESS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

Incident: March 16, 2020 · Filed: March 16, 2020

THE HEADLIGHT WENT OUT - REPLACED BULBS AND STILL NOT WORKING. REMOVED THE HEADLIGHT ASSEMBLY AND NOTICED EVERY WIRE WAS BARE WITH BARELY ANY COATING LEFT TO PROTECT THE WIRES- AT LEAST 15 WIRES. HEADLIGHT REPLACEMENT COST IS OVER $650.00.!! THIS IS AN ELECTRICAL HAZARD AND COULD CAUSE SHORTING OUT AND A DANGEROUS DRIVING SITUATION IN THE LEAST.