2003 BMW 325I Recalls & Complaints

Incident: June 28, 2024 · Filed: July 1, 2024

On June 28,2024, after parking and turning off the ignition switch, the dash started smoking and within minutes the whole dash and front of car were on fire. The car almost completely burned to the ground before the fire department could get there. The car was recently serviced at a BMW for an air bag recall. Heater ducts were loose when returned. There are also recalls for the 2006 325i for similar dash fires. The cause could be either dealer work or a factory issue.

Incident: January 4, 2022 · Filed: January 8, 2022

The xenon projector bowls in the headlight assembly on both sides of the vehicle have slowly been burning. The bowl is made of plastic and with the heat of the xenons burns the plastic creating not only a fire hazard but also greatly reduces the effectiveness of the headlight beam, rendering it almost useless. This is specific to the OEM manufacture of the headlight assembly, ZKW. This has also been well documented on various forums for these vehicles over the years.

Incident: February 12, 2021 · Filed: February 12, 2021

TL* THE CONTACT OWNED A 2003 BMW 325I. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, IT CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE CONTACT STATED THAT THE FIRE ARSONIST INVESTIGATOR FILED A REPORT AND PROVIDED A CASE NUMBER. THE VEHICLE WAS NOT TOWED TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

Incident: June 26, 2020 · Filed: July 1, 2020

THE DOOR LOCKS STOP WORKING PERIODICALLY WHERE ONLY THE DRIVERS DOOR WILL UNLOCK WITH THE KEY. AT THAT TIME, THE REAR AND PASSENGER DOORS WILL NOT UNLOCK WITH THE REMOTE OR THE BUTTON IN THE CENTER CONSOLE OR BY PULLING ON THE DOOR RELEASE INSIDE THE DOORS. THE BMW USUALLY UNLOCKS THE DOOR WITH THE FIRST PULL AND THEN OPENS WITH THE SECOND, BUT WHEN THIS IS HAPPENING, THE DOOR RELEASE (DOOR HANDLE) ON THE INSIDE DOES NOTHING. THIS RESULTS IN ONLY THE DRIVERS DOOR OPENING AND I HAVE TO REACH BACK OVER THE SEATS TO UNBUCKLE MY KIDS AND THEN PULL THEM OUT OVER THE BACK OF THE DRIVERS SEAT. SO LONG AS WE START OUTSIDE THE CAR, IT JUST MAKES THE BACK SEATS UNUSABLE. BUT IF I LOCK THE DOORS WHILE THE KIDS ARE IN THE CAR WHILE DRIVING AND THIS HAPPENS, WE GET INTO THE SCARY/FREAKY SITUATION. I VERIFIED THE CHILD SAFETY LOCKS AREN'T ENGAGED FOR THE DOORS THAT DISABLE THE INTERIOR DOOR HANDLES/RELEASES. I DON'T KNOW WHAT CAUSES THIS TO HAPPEN, IT JUST HAPPENS PERIODICALLY AND THEN GOES AWAY WITH NOTHING I CAN SEE AS A CAUSE. I HAVE VIDEO OF THIS HAPPENING, BUT THE FILE FORMATS LISTED DO NOT INCLUDE VIDEOS.

Incident: December 11, 2019 · Filed: December 18, 2019

DRIVING ON 12/12/2019 ON INTERSTATE HIGHWAY ABOUT 65MPH, GOING STRAIGHT, WHEN ALL OF A SUDDEN REAR WHEELS (THIS IS RWD - 2003 BMW 325I) LOCKED UP COMPLETELY - THE VEHICLE WENT FORWARD AT ABOUT 45 DEGREES SIDEWAYS BEFORE IT STRAIGHTENED OUT WHEN THE SPEED DROPPED. THANKFULLY I DID NOT HIT ANYBODY, AND NO ONE HIT ME ALTHOUGH THERE WAS QUITE A BIT OF TRAFFIC ON THIS MULTI LANE INTERSTATE. I GOT AAA TOW IT HOME. HE HAD TO DRAG IT ONTO THE TRUCK BED AS THE REAR WHEELS CONTINUED TO BE LOCKED UP. WHEN I REMOVED AND OPENED THE DIFFERENTIAL TAPERED ROLLER BEARING ROLLERS WERE IN THE OIL SPACE. LOOKING TO SEE WHERE THEY JAMMED THE SYSTEM UP I NOTICED MARKS ON THE CARRIER. IT APPEARS ROLLERS JAMMED UP IN BETWEEN THE CARRIER AND THE INNER WALL OF THE DIFFERENTIAL BOX - SEE PHOTOGRAPHS. THEY MAY ALSO HAVE JAMMED UP IN BETWEEN THE GEARING BUT I DID NOT NOTICE MARKS ON THE TEETH BUT DID NOT HAVE TIME TO SPEND TO LOOK MORE CLOSELY.

Incident: November 21, 2019 · Filed: November 21, 2019

I OWN A 2003 SULEV BMW AND IT NEEDS A FUEL PUMP. THIS ONLY CAN BE REPAIRED BY A DEALERSHIP DUE TO THE FACT IT HAS A SEALED FUEL TANK. THE COST CAN BE 6 TO 8000.00 DOLLARS. I WAS TOLD THERE IS AN EXTENDED WARRANTY FOR A SULEV CAR. 150000 MI OR 15 YEARS. I CALLED BMW AND THEY NEVER HEARD OF THAT WARRANTY. CAN YOU PLEASE HELP. THANK YOU

Incident: July 15, 2019 · Filed: July 15, 2019

THE PURPOSE OF THIS REQUEST IS TO GET BMW TO HONOR A REMEDY FOR TAILLIGHT DEFECT CAUSED AS A MANUFACTURING DEFECT. MY TAILLIGHT GROUNDING WIRES ARE CAUSING A SHORT ON TURNING SIGNALS. FURTHER RESEARCH INDICATED THIS HAS BEEN REPORTED NHTSA CAMPAIGN ID NUMBER: 11V438000. AFFECTED VEHICLES 325I - 2002-2005 BMW WILL NOT HONOR ITS PROPOSED REMEDY WITH NHTSA, CITING THE VIN HAS NOT BEEN IDENTIFIED IN RECALL. I CONTACTED BOTH DEALERSHIP IN STERLING VA AND CORPORATE BMW OF AMERICA (800-525-7417). BMW OF AMERICA WAS CONTACTED 7.15.2019. OPERATOR ANDREA EMPLOYEE # 6266 INFORMED ME THE CAR IS NOT COVERED UNDER REMEDY. MANUFACTURER: BMW OF NORTH AMERICA, LLC MFR'S REPORT DATE: AUG 25, 2011 NHTSA CAMPAIGN ID NUMBER: 11V438000 COMPONENT: EXTERIOR LIGHTING:TURN SIGNAL SUMMARY: BMW IS RECALLING CERTAIN MODEL YEAR 2002-2005 325I, 325XI, 330I, AND 330XI VEHICLES MANUFACTURED FROM SEPTEMBER 1, 2001, THROUGH MARCH 1, 2005. OVER TIME, RESISTANCE IN THE ELECTRICAL CONTACTS MAY CAUSE ONE OR MORE REAR LAMP FUNCTIONS (TAIL LIGHT, BRAKE LIGHT, AND/OR TURN-SIGNAL), WITHIN THE VEHICLE'S BODY PANEL, TO STOP WORKING. CONSEQUENCE: INTERMITTENT LIGHT OPERATION REDUCES THE ABILITY TO WARN OTHER MOTORISTS OF THE DRIVER'S INTENTIONS. THIS COULD CAUSE A VEHICLE CRASH WITHOUT WARNING. REMEDY: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417. THE RECALL IS FOR MODEL YEARS 2002-2005 OF THE 325I, 325XI, 330I AND 330XI CARS, THE MUNICH-BASED COMPANY SAID TODAY IN A POSTING ON THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S WEBSITE. LIGHTS INCLUDING TAIL, BRAKE AND TURN SIGNALS MAY ONLY WORK INTERMITTENTLY ON THE CARS, BMW TOLD THE AUTO-SAFETY REGULATOR.

Incident: November 27, 2018 · Filed: July 4, 2019

MY REAR WINDOW AND THE ROOFTOP DONT WORK I CAN HEAR THE MOTORS BUT NOTHING HAPPENS A TECHNICIAN EXPLAIN THAT THE REGULATOR AND LINES ARE BROKEN ITS A COMMON THING ON MY MODEL HE SPECIFIED.

Incident: June 14, 2019 · Filed: June 20, 2019

BOTH BACK WINDOWS ON MY 2003 BMW 325I WILL NOT GO UP. GARAGE SAYS BOTH REGULATORS AND ACTUATORS MUST BE REPLACED. RESEARCHING THE INTERNET SHOWS THIS TO BE A COMMON FAILURE ON THIS MODEL AND IT IS CONSIDERED A SAFETY HAZARD.

Incident: January 1, 2019 · Filed: January 5, 2019

AIRBAG LIGHT WON'T TURN OFF