NHTSA vehicle safety data
1997 Volvo WG Recalls & Complaints
The 1997 Volvo WG has 8 NHTSA recall campaigns on file as of October 23, 2026. try.vin has no NHTSA owner complaints on file for the 1997 Volvo WG. Recall repairs are usually free at an authorized Volvo dealer.
NHTSA recall and complaint data for the 1997 Volvo WG. Recall data is refreshed daily from NHTSA.
VOLVO TRUCKS/FMVSS 108/LAMP MOUNTING
NHTSA #02V238000 · Exterior Lighting — Tail Lights — Switch · NHTSA notice
Reported September 9, 2002 · VOLVO TRUCKS NORTH AMERICA INC
Potentially affected: 5,532 vehicles
Owners notified October 31, 2002 · Vehicles built November 11, 1990 – July 17, 2002 (per NHTSA)
Defect description
CERTAIN HEAVY DUTY CLASS 8 TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE TWO TAIL LAMPS, BACK-UP LAMP,AND LICENSE TAG LAMP WERE MOUNTED ON INSUFFICIENTLY RIGID MOUNTS.
Safety consequence
IT MAY NOT ALLOW THE DRIVER OF A REARWARD APPROACHING VEHICLE TO HAVE FULL VIEW OF THE LAMPS.
Manufacturer remedy
DEALERS WILL ATTACH THE TWO TAIL LAMPS, BACK-UP LAMP, AND THE LICENSE TAP LAMP ON STIFFER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 31, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Notes
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
VOLVO TRUCKS/ABS ECU
NHTSA #00V232003 · Service Brakes, Air — Antilock · NHTSA notice
Reported August 22, 2000 · VOLVO TRUCKS NORTH AMERICA INC
Potentially affected: 18,362 vehicles
Owners notified December 11, 2000 · Vehicles built November 6, 1997 – August 7, 2000 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
Safety consequence
THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
Manufacturer remedy
DEALERS WILL REPLACE THE ABS ECU.
Notes
OWNER NOTIFICATION WAS PHASED.FIRST MAILING TO CRITICAL CATEGORY "A" OWNERS BEGAN DECEMBER 11, 2000.ALL OTHER OWNER NOTIFICATION BEGAN FEBRUARY 12, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
VOLVO TRUCKS/HALDEX/FMVSS 121
NHTSA #00V002002 · Parking Brake · NHTSA notice
Reported February 24, 2000 · VOLVO TRUCKS NORTH AMERICA INC
Potentially affected: 13,516 vehicles
Volvo campaign RVXX0002 · Owners notified March 28, 2000 · Vehicles built June 4, 1997 – February 28, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH HALDEX MANIFOLD DASH VALVES (MDV) USED IN TRACTOR AND TRAILER PARKING BRAKES. THESE VALVES DO NOT MEET THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." A LOSS OF THE ISOLATION OF THE TWO BRAKE SYSTEM CIRCUITS CAN RESULT IN THE LOSS OF SERVICE BRAKES WHEN THERE IS ANOTHER FAILURE OF ONE OF THE TWO BRAKE CIRCUITS.
Safety consequence
THE LOSS OF SERVICE BRAKES CAN OCCUR, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL REPLACE THE SUSPECT VALVES.
Notes
VOLVO TRUCK RECALL NO. RVXX0002.OWNER NOTIFICATION BEGAN MARCH 28, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
VOLVO TRUCK/FRONT STEER AXLE
NHTSA #98V297000 · Steering — Linkages · NHTSA notice
Reported November 17, 1998 · VOLVO TRUCKS NORTH AMERICA INC
Potentially affected: 25 vehicles
Owners notified November 30, 1998 · Vehicles built September 9, 1997 – October 9, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH A FAL 8.0 FRONT STEER AXLE. THE UPPER STEERING ARM CAN FAIL WITHOUT WARNING.
Safety consequence
THIS CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Manufacturer remedy
DEALERS WILL INSPECT THE UPPER STEERING ARM AND REPLACE IT, IF REQUIRED.
Notes
OWNER NOTIFICATION BEGAN NOVEMBER 30, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCK AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
VOLVO TRUCKS/AIR SUSPENSION
NHTSA #98V255000 · Suspension — Front — Springs — Air Suspension — Lines and Fittings · NHTSA notice
Reported October 14, 1998 · VOLVO TRUCKS NORTH AMERICA INC
Potentially affected: 95,013 vehicles
Owners notified November 27, 1998 · Vehicles built October 1, 1986 – July 13, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE AIR SUSPENSION CONTROL VALVE SUPPLY LINE WAS NOT PLUMBED THROUGH AN AIR PRESSURE PROTECTION VALVE. IN THE EVENT OF A FAILURE, THERE WOULD BE LOSS OF AIR PRESSURE IN THE 'B' SYSTEM AIR RESERVOIR THAT SUPPLIES AIR PRESSURE FOR THE FRONT STEER AXLE BRAKES.
Safety consequence
THIS CONDITION WOULD RESULT IN INCREASED STOPPING DISTANCES.
Manufacturer remedy
DEALERS WILL INSTALL THE NECESSARY AIR PRESSURE PROTECTION VALVE.
Notes
OWNER NOTIFICATION BEGAN DURING NOVEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
VOLVO TRUCK/ACCURIDE/ALUMINUM DUAL WHEELS
NHTSA #98V120001 · Wheels — Rim · NHTSA notice
Reported May 19, 1998 · VOLVO TRUCKS NORTH AMERICA INC
Potentially affected: 3,065 vehicles
Defect description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH AFTERMARKET ALUMINUM DUAL WHEELS, 22.5X8.25, ONE-PIECE, TUBELESS, SUPPLIED BY ACCURIDE/AKW. CERTAIN DESIGN REVISIONS COMBINED WITH PROCESS CONDITIONS CAUSED FATIGUE CRACKS IN THESE WHEELS.
Safety consequence
THIS CONDITION CAN CAUSE FAILURE OF THESE WHEELS.
Manufacturer remedy
ACCURIDE/AKW WILL REPLACE THESE WHEELS.
Notes
ACCURIDE/AKW WILL CONDUCT THE OWNER NOTIFICATION AND REMEDY CAMPAIGN FOR THIS RECALL.OWNER NOTIFICATION BEGAN JULY 27, 1998. OWNERS WHO DO NOT HAVE THEIR WHEELS REPLACED FREE WITHIN A REASONABLE TIME SHOULD CONTACT ACCURIDE/KAISER AT 1-888-665-9189 OR VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
VOLVO TRUCK/FRONT AXLE WHEEL
NHTSA #97V212000 · Suspension — Front — Wheel Bearing · NHTSA notice
Reported November 17, 1997 · VOLVO TRUCKS NORTH AMERICA INC
Potentially affected: 923 vehicles
Owners notified December 17, 1997 · Vehicles built October 1, 1997 – October 20, 1997 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE STEER AXLE WHEEL BEARING JAM NUT LOCK WASHER MAY NOT HAVE BEEN BENT OVER THE JAM NUT AFTER THE WHEEL BEARINGS WERE ADJUSTED.
Safety consequence
IF THIS CONDITION EXISTS, THE JAM NUT AND WHEEL BEARING ADJUSTING NUT CAN BACK OFF THE SPINDLE ALLOWING THE WHEEL AND THE BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A VEHICLE CRASH.
Manufacturer remedy
DEALERS WILL INSPECT THE STEERING AXLE WHEEL BEARING JAM NUT LOCK WASHER TO DETERMINE IF IT IS BENT OVER THE JAM NUT, AND IF NOT, REPAIR AS REQUIRED.
VOLVO HEAVY TRUCK/CAB ENTRY
NHTSA #97V023000 · Structure — Body · NHTSA notice
Reported February 24, 1997 · VOLVO TRUCKS NORTH AMERICA INC
Potentially affected: 1,928 vehicles
Owners notified February 28, 1997 · Vehicles built November 11, 1996 – January 29, 1997 (per NHTSA)
Defect description
WARNING LABELS IDENTIFYING THE CLIMBING SEQUENCE AND PROCESS WERE OMITTED.
Safety consequence
PERSONS NOT USING THE SEQUENCE AND PROCESS DURING CAB ENTRY OR EXIT OR WHEN USING THE OPTIONAL BACK OF CAB ACCESS MAY SLIP AND/OR FALL CAUSING PERSONAL INJURY.
Manufacturer remedy
VOLVO HEAVY TRUCK WILL BE PROVIDING WARNING LABELS TO BE INSTALLED BY OWNERS ON THEIR TRUCKS.
Notes
OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN MARCH 18, 1997. NOTES:OWNERS WHO DO NOT RECEIVE THE WARNING LABEL FREE OF CHARGE WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO GM HEAVY DUTY TRUCK AT 1-910-393-2000.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Other Volvo WG model years
Check your 1997 Volvo WG VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volvo WG at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Volvo VIN