try.vin
Log in

NHTSA vehicle safety data

2005 Volvo VHD Recalls & Complaints

The 2005 Volvo VHD has 6 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Volvo dealer.

NHTSA recall and complaint data for the 2005 Volvo VHD. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Volvo VHD owner complaints

Owners have filed 3 complaints with NHTSA about the 2005 Volvo VHD, describing incidents dated September 25, 2004 to August 27, 2005.

Most-cited components

  • Power Train 1 complaint
  • Suspension 1 complaint
  • Visibility/Wiper 1 complaint
  • Wheels 1 complaint

Newest complaints

  • ODI #10138129 · Filed

    DT: 2005 VOLVO S60 T5. THE CONSUMER STATED THE WINDSHIELD HAS A GLARE FROM THE DASHBOARD WHICH INTERFERES WITH DRIVER'S VISIBILITY. THE GLARE HAS BEEN ON WINDSHIELD SINCE THE CONSUMER PURCHASED THE CAR. THERE HAS NOT BEEN ANY ACCIDENT YET. THE CONSUMER CONTACTED THE DEALERSHIP, AND THE DEALERSHIP…

  • ODI #10106787 · Filed

    THE VEHICLE STARTED SHAKING UNCONTROLLABLY FOLLOWED BY A LOUD BANGING NOISE COMING FROM THE FRONT. CONSUMER DROVE VEHICLE TO THE DEALER, AND MECHANIC DETERMINED THAT THE TRANSMISSION BOLT SHEARED OFF, CAUSING THE TRANSMISSION TO DROP DOWN FROM THE VEHICLE. TRANSMISSION NEEDED TO BE REPLACED. *AK

  • ODI #10094967 · Filed

    WHILE DRIVING AT 40 MPH CONSUMER FELT VIBRATION, AND THEN NOTICED WHEELS ROLLING PASSED THE VEHICLE. THE BRAKES WERE APPLIED, BUT FAILED TO STOP THE VEHICLE. IT COASTED TO A COMPLETE STOP ON ITS OWN. VEHICLE WAS TOWED TO THE IMPOUND. THE RIGHT REAR DUEL WHEEL SEPARATED AND CAME OFF. THE SECOND…

Read all 3 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Volvo VHD in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Open and recently closed NHTSA defect investigations

Incorrect Plow Light Software//FMVSS 108

NHTSA #18V766000 · Exterior Lighting · NHTSA notice

Reported October 30, 2018 · Volvo Trucks North America

Potentially affected: 4,625 vehicles

Repair completion: 43.37% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Volvo campaign RVXX1804 · Owners notified December 19, 2018 · Vehicles built January 1, 2003 – October 23, 2018 (per NHTSA)

Defect description

Volvo Trucks North America (Volvo) is recalling certain 2004-2019 Volvo VHD trucks equipped with snow plow lamp preparation kits. The snow plow headlights can be turned on without other exterior lights, and high beam indicator will not work when the snow plow high beams are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Safety consequence

The driver may operate the vehicle with the snow plow headlights on but the marker and tail lamps off, reducing the vehicle's visibility and increasing the risk of a crash.

Manufacturer remedy

Volvo will notify owners, and dealers will update the software related to the plow lights, free of charge. The recall began December 19, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1804.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Seat Belt weld/FMVSS 210

NHTSA #12V510000 · Seat Belts · NHTSA notice

Reported October 18, 2012 · Volvo Trucks North America

Potentially affected: 1,496 vehicles

Volvo campaign RVXX1204 · Owners notified May 10, 2013 · Vehicles built August 4, 2000 – June 22, 2012 (per NHTSA)

Defect description

Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."

Safety consequence

In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.

Manufacturer remedy

Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.

Notes

Volvo's recall campaign number is RVXX1204.Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153), or go to www.safercar.gov.

WIPER MOTOR

NHTSA #09V173000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported May 21, 2009 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 127,764 vehicles

Volvo campaign RVXX0902 · Owners notified September 30, 2009

Defect description

VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.

Safety consequence

IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.

Manufacturer remedy

VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0902.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LIGHTING SYSTEM/CIRCUIT BREAKERS

NHTSA #07V573000 · Electrical System — Wiring — Fuses and Circuit Breakers · NHTSA notice

Reported December 14, 2007 · VOLVO TRUCKS NORTH AMERICA

Potentially affected: 104,845 vehicles

Volvo campaign RVXX0707 · Owners notified February 25, 2008

Defect description

ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.

Safety consequence

IF A SHORT CIRCUIT OCCURS AND IS LEFT UNTREATED, COMPONENTS AND WIRING MAY BE SUBJECT TO OVERHEATING WHICH COULD POSSIBLY RESULT IN A VEHICLE FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE CIRCUIT BREAKERS WITH FUSES. THE RECALL BEGAN ON FEBRUARY 25, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0707.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DISC WHEEL SPACER

NHTSA #06V213000 · Wheels · NHTSA notice

Reported June 14, 2006 · VOLVO TRUCKS NORTH AMERICA, INC.

Potentially affected: 873 vehicles

Volvo campaign RVXX0603 · Owners notified June 26, 2006 · Vehicles built December 1, 2001 – June 30, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRUCKS, THE WHEEL SPACER MAY BECOME DISTORTED FROM HEAT WHICH POTENTIALLY COULD LEAD TO A LOSS OF CLAMP THAT MAY RESULT IN LOOSE WHEEL NUTS.

Safety consequence

IF THE WHEEL NUTS LOOSEN FOR ANY REASON, DAMAGE TO THE WHEEL STUDS AND WHEEL MAY OCCUR, AND MAY LEAD TO A COMPLETE SEPARATION OF THE WHEELS FROM THE TRUCK WHICH COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE WHEEL SPACERS AND THE WHEEL EQUIPMENT (WHEELS,STUDS, AND HUB) WILL BE INSPECTED FOR DAMAGE AND REPLACED IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 26, 2006. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0603.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

EXHAUST GAS RECIRCULATION COOLER PIPES

NHTSA #06V021000 · Engine and Engine Cooling — Exhaust System · NHTSA notice

Reported January 26, 2006 · VOLVO TRUCKS NORTH AMERICA, INC.

Potentially affected: 33,102 vehicles

Volvo campaign RVXX0601 · Owners notified March 3, 2006 · Vehicles built November 1, 2002 – January 31, 2006 (per NHTSA)

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH D12D ENGINES, THE EXHAUST GAS RECIRCULATION (EGR) COOLER INLET PIPES OR THE PIPES THAT CONNECT THE EGR VALVES TO THE COOLER MAY CRACK OR BREAK.

Safety consequence

IF THE PIPES OR THE COOLER INLET PIPES FAIL AND ARE LEFT UNTREATED, THE AIR CLEANER AND INNER FENDER MAY BE SUBJECT TO HOT EXHAUST GASES, WHICH COULD LEAD TO A FIRE.

Manufacturer remedy

DEALERS WILL INSPECT AND REPAIR THE EGR COOLER PIPES AS REQUIRED AND INSTALL A HEAT SHIELD FREE OF CHARGE. AN INTERIM OWNER LETTER WAS MAILED ON FEBRUARY 17, 2006, TO ADVISE ON PRECAUTIONS THAT THE OWNER CAN TAKE UNTIL PARTS BECOME AVAILABLE. OWNERS ARE BEING NOTIFIED STARTING MARCH 3, 2006, THAT PARTS ARE NOW AVAILABLE. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.

Notes

VOLVO TRUCKS RECALL NO. RVXX0601.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Other Volvo VHD model years

Check your 2005 Volvo VHD VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Volvo VHD at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Volvo VIN