2018 Volvo S90 Recalls & Complaints

Incident: March 9, 2025 · Filed: March 12, 2025

Rear right door lock failed, stuck closed. Extremely unsafe if someone was sitting in the back and unable to leave vehicle. It has been confirmed by others. It has been inspected by an independent mechanic. There has been zero warning lights to indicate the issue

Incident: February 17, 2025 · Filed: February 19, 2025

At 5pm while driving home, which was 2 hours away, I needed to stop and refuel. At the pump I pushed the fuel door and it would not release to open. After many tries it would not open. I called Volvo On Call and informed them of the problem. The agent relayed that I should go to the back of the car near the fuel door, and with the remote lock and unlock the door which should release the door. It did not work. I tried it again with no success. The agent then informed me that there is no other way to open the door and to go to a Volvo dealership to get repaired. I asked the agent is there a way to open the door from the trunk, for instance like a rope to pull to manually open the door. He said unfortunately no. So, I am no where near a dealership and if I was it would be closed, it is after 5pm on February 17 and its 20 degrees outside and I need fuel to get home. I get in my car and search the internet on a possible way to open the door and I see that this is a big problem with Volvo that has affected many families and individuals that, as I, have been put in a compromised possibly dangerous position. While at the gas station I fortunately saw a tow truck and asked the driver if I could borrow a screw driver to try to pry open the door to which I was successful. A simple pull cord in the trunk, as some vehicles have, would have solved this issue without putting anyone in a precarious situation. I took my car to a mechanic and he replaced the fuel door lock solenoid.

Incident: February 12, 2024 · Filed: February 23, 2024

The rear door will not open from the inside or the outside. Apparently this is a door lock actuator issue experinced by many volvo owners. It is extremely dangerous not to be able to open a rear door in the case of an accident or other incident where you need to enter or exit the car. Dealer confirms that there is an issue with these. No warning message appears when inoperable.

Incident: October 20, 2023 · Filed: October 23, 2023

255/35 R20 Bleb in sidewall with air leak through tread adjacent. No unusual trauma to tire.

Incident: September 14, 2022 · Filed: October 24, 2022

water get inside the car in the back on the floor mat behind driver seat. was not aware of this problem at all.

Incident: May 1, 2021 · Filed: June 16, 2022

The contact owns a 2018 Volvo S90. The contact stated that upon the depression of the brake pedal, the steering wheel would violently shake without warning. The contact has had two sets of brake rotors replaced on the vehicle due to the failure. Since owning the vehicle, the contact stated that the failure would occur approximately every 8,000-10,000 miles. After the third failure, the contact was informed that the repair for the rotors would not be covered under warranty. The contact was provided an estimate for the repair. The manufacturer was notified of the failure and filed a claim; the contact was called back and was informed that the claim was denied. The vehicle had been repaired. The failure mileage was approximately 47,000.

Incident: April 16, 2022 · Filed: May 9, 2022

The contact owns a 2018 Volvo S90. The contact stated that the Vehicle Connectivity Module (VCM) had an error causing the Telematics and Driver Support Systems to function improperly. The contact stated the "Volvo on Call Service Required" warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the software installed in the Vehicle Connectivity Module (VCM) needed to be updated. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V800000 (Electrical System). The manufacturer had been informed of the failure. The failure mileage was approximately 75,000.

Incident: January 4, 2021 · Filed: August 17, 2021

Hi, When you drive over 70mph, steering, floors and whole cabin start vibrates, I have changed tires as Volvo recommended, alignment done. Everything dealer requested I have done. I have driven couple of more volvo as a loaners and noticed they all vibrates , but not bad as mine. Try to reach out Volvo head office but no proper resolution. They are keep blaming tires which I have changed 3 times but actually vibration happen from engine or somewhere else. Lots of Volvo owners online shares same issues online. Please help me out on this matter.

Incident: September 15, 2020 · Filed: September 15, 2020

2018 VOLVO S-90. CONSUMER WRITES IN REGARDS TO A PRODUCT FLAW. *LD THE CONSUMER STATED THE VEHICLES FLOOR MAT HAD UNSNAPPED AND BECOME WEDGED UNDER THE ACCELERATOR PEDAL. THE CONSUMER WAS UNABLE TO DRIVE FORWARD OR IN REVERSE. *JS

Incident: July 9, 2019 · Filed: July 15, 2019

I PURCHASED A VOLVO S90 2018 FROM ECAR ONE . ON JULY 6 2019. I WAS TOLD BY THE SALEMAN VIRGIL . THAT THERE WAS A RECALL ON THE DASHBOARD AND ALL I HAVE TO DO WAS CALL VOLVO DEALERSHIP AND THEY WOULD FIX FOR FREE. WHEN I CALLED VOLVO AFTER MY PURCHASE THEY SAID NO RECALL ON THIS VEHICLE. 0709