2006 Volvo S60 Recalls, Ratings & Complaints

Incident: March 18, 2024 · Filed: March 18, 2024

The contact owned a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) and would like to be removed from the recall distribution list. The manufacturer was not contacted.

Incident: June 13, 2023 · Filed: February 21, 2024

The contact owns a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted to schedule an appointment for the recall repair; however, the contact was unable to secure an appointment. The manufacturer was contacted and opened a case. The contact had not experienced a failure. Parts distribution disconnect.

Incident: July 7, 2023 · Filed: July 19, 2023

The contact owns a 2006 Volvo S60. The contact stated that the air bag was replaced under NHTSA Campaign Number: 21V766000 (Air Bags) and approximately 2 weeks later, while the vehicle was idling at a stop sign, the air bag compartment on the driver's side started smoking and the air bag warning light illuminated. The smoke then dissipated. There were no injuries or medical attention needed. The contact returned the vehicle to the dealer who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. the manufacturer was made aware of the failure. The approximate failure mileage was 84,190.

Incident: March 5, 2023 · Filed: March 5, 2023

My 06 s60 has blown 3 charge air hoses in the EXACT same spot. (The hose behind the radiator.) A golf-ball sized hole blows out in a bend in the hose while driving. The car will idle , but throttle up at all. The dealer says this is a fluke.

Incident: June 27, 2022 · Filed: June 28, 2022

Lug bolts 19 MM are rusted into the 330 MM Brembo Disk brakes, They take over 220 ft lb of force to break lose, and you can not do that safety on the side of the road to change a flat tire

Incident: November 29, 2021 · Filed: May 4, 2022

The contact owns a 2006 Volvo S60. The contact received notification of NHTSA Campaign Number: 21V766000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Incident: December 6, 2021 · Filed: January 6, 2022

I was expected to pay over one thousand dollars to have the recall remedy performed. My home and location of car is Ketchikan, Alaska. There is no Volvo dealer in Ketchikan and no roads connecting town with the mainland road system. The car would have to be shipped by either aircraft or oceangoing vessel to the mainland for access to a Volvo dealer. This would cost a lot of money. I perform all maintenance and repairs myself so I contacted Volvo asking then to ship me the air bag for installation. Volvo responded that I must take the car to a dealer at my own expense. The practical reality is that transporting the car to a dealer for this (or any other recall) is completely unreasonable, making it virtually impossible to have the recall repair performed unless Volvo will simply supply the part so I can install it.

Incident: September 3, 2018 · Filed: June 28, 2019

A FEW MONTHS BACK, THIS VEHICLE WAS LEAKING GASOLINE FROM THE AREA OF FUEL PUMP. THE FUEL PUMP IS LOCATED UNDER THE REAR SEAT OF THE VEHICLE, SO THERE WAS ALSO A STRONG ODOR INSIDE THE CAR. THE VEHICLE FUEL TANK WAS FILLED JUST PRIOR TO THIS HAPPENING. SO, FOR 20 MILES, MYSELF AND MY WIFE WERE SUBJECTED TO GASOLINE FUMES, AND AT THE SAME TIME, RAW GASOLINE WAS SPILLING UNDERNEATH THE CAR WHILE DRIVING. MY REPAIR SHOP DIAGNOSED, AND REPAIRED CAR BY INSTALLING A NEW FUEL PUMP. AFTER FURTHER INVESTIGATION , I HAVE FOUND THAT VOLVO CARS DID RECALL, AND REPAIR SOME MODELS OF 2003 AND 2005... EVEN MY 2004 WAS REIMBURSED FOR THIS. I BELIEVE THAT VOLVO KNOWS THAT'S THERE IS A PART DEFECT, NOT A PART FAILURE... THIS IS A STATIONARY, HARD COMPOSITE PLASTIC THAT IS THE SAME CULPRIT AS THE EARLIER YEARS INVOLVED. I AM ASKING THE NHTSA TO FURTHER INVESTIGATE VOLVO CARS TO INSURE THAT NO ONE ELSE HAS THIS SCARE. IT COULD HAVE BEEN CATASTROPHIC FOR MYSELF AND ALL OTHERS ON THE ROADS THAT DAY

Incident: April 7, 2010 · Filed: April 25, 2018

THE PASSENGER SIDE LIGHT WORKS INTERMITTENTLY THIS HAS BEEN A SLIGHT ISSUE SINCE 2006 WHEN I HAVE HAD NEW LIGHTS INSTALLED ON A REGULAR BASIS. DESPITE ME GOING TO THE DEALER FOR OVER THE LAST 11 YEARS OR SO IT IS ONLY GETTING MORE FREQUENT IN AGE. IT IS NOT THE BULB BUT THE WIRING IN THE VEHICLE THAT IS FAULTY. THIS CAN BE DANGEROUS ESPECIALLY WHEN COMBINED WITH THE FOG THAT THE LIGHTS HAVE PUT ON THE GLASS OVER THE YEARS. I HAVE PAID TO HAVE THE FOG REMOVED TWICE AND THE WIRING HARNESS CHECKED. AFTER LIVING IN 5 DIFFERENT STATES I SEE THIS IN ALMOST EVERY S60 IN THE MID 2000 ALWAYS ONE HEAD LIGHT OUT. IT WILL COME BACK ON WHEN YOU ENCOUNTER A BUMP SO IT IS A MISSED CONNECTION AT SOME POINT IN THE WIRE HARNESS. THIS CREATES SUCH LIMITED VISION IN NIGHT AND I AM CONSTANTLY GETTING HONKED AT. I HAVE PULLED OVER AND JIGGLED THE WIRES WHICH WILL ALLOW THE LIGHT TO WORK UNTIL YOU TURN A CORNER, HIT A BUMP OR IT JUST FADES. I BELIEVE THE HEADLAMPS SHOULD ALL BE REPLACED AND THE WIRING FIXED THIS IS SUCH AN ISSUE IN THE EVENINGS.

Incident: July 1, 2016 · Filed: July 3, 2016

ENGINE THROTTLE. CAR SLOW DOWN TO A CRAWL WHILE DRIVING SPEED AT 60 MILES ON HIGHWAY , CHECK ENGINE LIGHT. TRYING TO FIND IF A RECALL . OTHER MUST BE HAVING THIS PROBLEM . THIS IS 2006 S60 VOLVO