2012 Volkswagen Touareg Recalls & Complaints

Incident: December 20, 2025 · Filed: March 23, 2026

After driving the car for approximately 30 minutes without any problems and turning it off, it would not turn the ignition back on, release the parking brake or shift out of „P“. Several towing companies were unable to tow the vehicle due to the manufacturer’s failure to provide instructions on how to release the shifter in case of a problem. Other vehicles have a release button somewhere, the 2012 VW Touareg doesn’t. On page 481 of the owners manual VW advises the owner that if „you want to have the vehicle towed, the gear shift selection lever must first be released with the emergency procedure. Get professional assistance.“ The manual doesn’t explain what this emergency procedure would be. We had to call 3 different towing companies with professionals who didn’t have any clue in regards to the question how to release the shifter. The fourth company came with special equipment which allowed to tow the vehicle with the shifter in „P“ The dealership found that the ESL module (electronic steering lock) was faulty, which could be a safety issue, especially if it actuates while driving the vehicle.

Incident: February 16, 2025 · Filed: February 20, 2025

I was driving to church on the morning of 2/16/25 when I heard a very loud “Boom.” I thought something had hit the car. It sounded like a gun going off. When I pulled over to see what had happened I realized the right side mirror had exploded. The glass was completely gone with only the glue left on the back plate housing. Both mirrors were in the “off” position. Nothing hit the outside housing. The right side mirror simply exploded. Thank God the window was not down with a passenger in the right front seat. In cool weather I often drive with the window down. Someone could have been hurt. I have owned many cars but NEVER one with a side mirror that exploded. This design is DANGEROUS.

Incident: December 13, 2024 · Filed: December 27, 2024

While driving my family around, the car lost engine power and came to a stop on a busy roadway leaving us stranded until a tow truck could arrive. There were no warnings or indications that anything was wrong. One minute, it was driving fine and out of nowhere, the engine shut off in the middle of the road leaving us blocking a lane and creating a dangerous situation. The dealership is claiming that the high pressure fuel pump suffered a catastrophic failure and that the entire fuel system needs to be replaced, which is going to cost more than $13,000.

Incident: February 22, 2023 · Filed: October 3, 2023

The contact owns a 2012 Volkswagen Touareg. The contact stated while driving at an undisclosed speed, he smelled an oil odor and smoke odor in the interior of the vehicle. After a visual inspection, the contact observed oil leaking from underneath the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who determined the diesel particulate filter needed to be replaced but was unable to locate the part. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 124,000.

Incident: January 1, 2023 · Filed: August 23, 2023

The contact owns a 2012 Volkswagen Touareg. The contact stated that the driver’s side seat belt unintendedly unlatched while driving at various speeds. Additionally, the contact stated that the clockspring was defective, causing several failures with the vehicle. The contact stated while tilting the steering wheel, the vehicle drifted away from the intended direction and the windshield wipers would activate to the fastest speed with windshield washer fluid spraying onto the windshield and the horn was blaring uncontrollably. The vehicle was taken to a dealer and the contact was provided an estimate for a diagnostic test. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 178,000.

Incident: August 7, 2022 · Filed: August 9, 2022

The contact owns a 2012 Volkswagen Touareg. The contact stated that there was an abnormal gasoline odor on the driver’s side of the vehicle. There were no warning lights illuminated. The contact looked underneath the vehicle at the gas tank and noticed that gasoline was leaking from the fuel tank onto the exhaust pipe. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number 17V151000 (Fuel System, Gasoline). The VIN was not included. The approximate failure mileage was 119,000.

Incident: July 8, 2020 · Filed: May 10, 2021

THE DRIVER SEAT BELT DOES NOT LATCH PROPERLY AND COMES OFF WHILE DRIVING. MULTIPLE ATTEMPTS ARE REQUIRED FOR THE SEAT BELT TO LATCH AND BE SECURE. THIS PROBLEM STARTED AROUND JULY 2020.

Incident: September 15, 2019 · Filed: November 2, 2019

THE CATALYTIC CONVERTER COMPLETELY SEPARATED FROM ITS OWN FLANGE WHERE IT CONNECTS TO THE EXHAUST HEADER. ULTIMATELY CAUSING AN EXHAUST LEAK AND A CHECK ENGINE LIGHT. THIS OCCURRED WHILE DRIVING AND UNDER NORMAL OPERATING CONDITIONS. DRIVING ON A LOCAL HIGHWAY WITH A SPEED LIMIT OF 55 MPH, WHICH DOES NOT HAVE EXCESSIVE AMOUNT OF POT HOLES) .

Incident: April 25, 2018 · Filed: August 6, 2018

THERE HAS BEEN A SUBSTANTIAL CHANGE/DECREASE IN THE PERFORMANCE OF MY 2012 TOUAREG TDI RESULTING IN SIGNIFICANTLY REDUCED FUEL ECONOMY: PREVIOUS AVG FUEL ECONOMY WAS APPROX 27MPG AND IS NOW BARELY AVERAGING 16 MPG. NOTICED CONTINUAL DECREASE IN CAR PERFORMANCE AFTER TAKING MY CAR IN FOR GENERAL MAINTENANCE TO GARCIA VW DEALERSHIP IN SANTA FE, NM ON THE FOLLOWING DATES: 3/6/18: GENERAL MAINTENANCE (AIR/CABIN/FUEL/ADBLUE MAINTENANCE/ AND TIRE CHANGE) 4/17/18: REPLACE A FAULTY RADIO WHICH SUDDENLY FAILED (DEALERSHIP HAD CAR FOR 8 DAYS) 6/7/18: CLEAN UP AD BLUE FUEL SPILL IN THE REAR SPARE TIRE COMPARTMENT THE ENGINE NOW RUNS SIGNIFICANTLY LOUDER AND IS REVVING UP AND SURGING AT INTERVALS. IN ADDITION TO THE SUBSTANTIAL DROP IN FUEL ECONOMY, THE AVERAGE SPEED/MPH HAS BEEN LOCKED AT 13MPH AND DROPPED TO 12MPH ON JUNE 1, 2018. CHANGE IN ENGINE BEHAVIOUR: -ENGINE RUNS LOUDER AND IS REVVING UP WHEN IDLING,ACCELERATING, BREAKING,DOWNSHIFTING -SOUNDS LIKE THE FUEL INJECTION IS SLUGGISH WHEN ACCELERATING -STEERING WHEEL FEELS SLUGGISH WHEN TURNING RIGHT AND ACCELERATING THROUGH TURNS. VIBRATING SOUND WHEN TURNING. -STARTING IGNITION: LONGER PAUSE FOR IGNITION TO START AFTER TURNING THE KEY AND FOOT IS ON BRAKE. -SUSPENSION: SUSPENSION OF THE CAR ROCKS BACK AND FORTH WHEN BRAKING AND SOUNDS LIKE THERE'S A TANK SLIDING/ SHIFTING IN THE REAR WHEN COMING TO A STOP. WHEN I INITIALLY HEARD THIS SOUND I OPENED THE TRUNK/CARGO AREA FOR THE SPARE TIRE AND FOUND DRIED AD BLUE SPILLED ALL OVER THE CARGO AREA INCLUDING DIRTY RAGS WHICH HAD BEEN USED TO WIPE UP ADBLUE AND STUFFED IN THE BOTTOM OF THE TRUNK. -AIR CONDITIONER IS EMITTING A VERY STRONG NAUSEATING YEAST ODOR THAT WILL NOT GO AWAY AND ISN'T COOLING EFFICIENTLY. I HAVENT AUTHORIZED OR APPROVED ANY UPDATES MODIFICATIONS TO THE VEHICLE RE: THE 3.0 LITER GEN EPA/CARB MODIFICATIONS: I SUSPECT VEHICLE TAMPERING.

Incident: February 5, 2018 · Filed: February 6, 2018

THIS HAPPENED TO THIS MY 2012 TOUAREG. THE ENGINE RANDOMLY DIED, EVEN ON FREEWAY, WHICH IS TOO DANGEROUS. THE PREVIOUS TIME IN IN JAN,2018 AND THIS TIME WAS ON FEB, 5TH, 2018. I WENT TO VW DEALERSHIP, THEY COULDN'T FIND OUT ANYTHING. SAYING EVERYTHING IS NORMAL AND THEY COULDN'T SUGGEST ANYTHING. BUT IT IS EXTREME UNSAFE FOR ME TO DRIVE THIS CAR. THE ISSUE RANDOMLY HAPPENS. PER HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4965979-CAR-RANDOMLY-DIES-WHILE-DRIVING-ON-FREEWAY, SEEMS THIS IS A COMMON ISSUE AMONG VW VEHICLES, AND PEOPLE THOUGHT IT IS HIGH PRESSURE FUEL PUMP PROBLEM OR OTHER RELEVANT PARTS. VW SHOULD TAKE IT SERIOUSLY AND FIND OUT THE ROOT CAUSE AND FIX IT. THANKS, LIANG