NHTSA vehicle safety data

2021 Vanleigh Vilano Recalls & Complaints

The 2021 Vanleigh Vilano has 1 NHTSA recall campaign and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Vanleigh dealer.

NHTSA recall and complaint data for the 2021 Vanleigh Vilano. Recall data is refreshed daily from NHTSA.

2021 Vanleigh Vilano owner complaints

Owners have filed 2 complaints with NHTSA about the 2021 Vanleigh Vilano, describing incidents dated May 30, 2023 to November 20, 2024.

Most-cited components

Tires 1 complaint
Trailer Hitches 1 complaint

Newest complaints

ODI #11743741 · Filed June 12, 2026
The contact owns a 2021 Vanleigh Vilano RV. The contact stated that while driving at various speeds on two separate occasions, the contact observed excessive vertical movement in the pin box/fifth-wheel hitch assembly. Upon pulling to a gas station and inspecting the vehicle, the contact noticed…
ODI #11530505 · Filed July 5, 2023
I’ve had three blow outs all westlake tires 215/75R 17.5 all on the freeway speed 60 Mph have been told by several tire companies that this is a low grade tire and I should replace them, the manufacturer is replacing them on the new models but would not on ours first one blow in south decota. The…

Read all 2 complaints

Water Heater May Leak Gas Into Coach

NHTSA #21V355000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Water Heater · NHTSA notice

Reported May 14, 2021 · VanLeigh RV

Potentially affected: 366 vehicles

Repair completion: 48.46% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified July 9, 2021

Defect description

VanLeigh RV (VanLeigh) is recalling certain 2019-2021 Beacon and 2019-2022 Vilano coaches. The water heater housing may not have been properly sealed, allowing gas to enter the coach.

Safety consequence

Gas inside the coach increases the risk of a fire.

Manufacturer remedy

Dealers will install a grommet ensuring the sleeve is facing out and use zip-ties to secure the sleeves to the gas line, free of charge. Owner letters were mailed July 9, 2021. Owners may contact VanLeigh customer service at 1-662-612-4040.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

try.vin has no NCAP crash-test rating on file for the 2021 Vanleigh Vilano. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2021 Vanleigh Vilano.

Trailer Hitches

ODI #11743741

Incident: November 20, 2024 · Filed: June 12, 2026

The contact owns a 2021 Vanleigh Vilano RV. The contact stated that while driving at various speeds on two separate occasions, the contact observed excessive vertical movement in the pin box/fifth-wheel hitch assembly. Upon pulling to a gas station and inspecting the vehicle, the contact noticed that the mounting screws under the fifth wheel holding the fiberglass had ripped through the fiberglass. The RV was taken to the dealer, where it was diagnosed with a fractured frame. The RV was repaired, but the failure recurred approximately 18 months later. The RV was inspected by an independent mobile technician; however, a definitive diagnosis was currently pending. The failure mileage was unknown.

Tires

ODI #11530505

Incident: May 30, 2023 · Filed: July 5, 2023

I’ve had three blow outs all westlake tires 215/75R 17.5 all on the freeway speed 60 Mph have been told by several tire companies that this is a low grade tire and I should replace them, the manufacturer is replacing them on the new models but would not on ours first one blow in south decota. The other was in az and the last was in Colorado speed and tire pressure was as per manufacturer

Other Vanleigh Vilano model years

Check your 2021 Vanleigh Vilano VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Vanleigh Vilano at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Vanleigh VIN