NHTSA vehicle safety data

2019 Vanleigh Vilano Recalls & Complaints

The 2019 Vanleigh Vilano has 2 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Vanleigh dealer.

NHTSA recall and complaint data for the 2019 Vanleigh Vilano. Recall data is refreshed daily from NHTSA.

2019 Vanleigh Vilano owner complaints

Owners have filed 1 complaint with NHTSA about the 2019 Vanleigh Vilano, describing incidents dated May 5, 2019.

Most-cited components

Suspension 1 complaint

Newest complaints

ODI #11253637 · Filed September 6, 2019
TL* THE CONTACT OWNS A 2019 VANLEIGH VILANO 365RL. WHILE DRIVING APPROXIMATELY 60 MPH, ANOTHER MOTORIST ALERTED THE CONTACT THAT THE REAR PASSENGER SUSPENSION WAS TILTED TO THE RIGHT. THE RV WAS TOWED TO A PARKING LOT. THE TOW SERVICE CAME BACK THE FOLLOWING DAY AND REPLACED THREE SPRINGS ON THE…

Read the full complaint

Water Heater May Leak Gas Into Coach

NHTSA #21V355000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Water Heater · NHTSA notice

Reported May 14, 2021 · VanLeigh RV

Potentially affected: 366 vehicles

Repair completion: 48.46% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified July 9, 2021

Defect description

VanLeigh RV (VanLeigh) is recalling certain 2019-2021 Beacon and 2019-2022 Vilano coaches. The water heater housing may not have been properly sealed, allowing gas to enter the coach.

Safety consequence

Gas inside the coach increases the risk of a fire.

Manufacturer remedy

Dealers will install a grommet ensuring the sleeve is facing out and use zip-ties to secure the sleeves to the gas line, free of charge. Owner letters were mailed July 9, 2021. Owners may contact VanLeigh customer service at 1-662-612-4040.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Suspension Shackle Failure

NHTSA #19V588000 · Suspension — Rear — Springs — Leaf Spring Assembly — Shackle · NHTSA notice

Reported August 12, 2019 · VanLeigh RV

Potentially affected: 1,808 vehicles

Repair completion: 34.35% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified August 30, 2019 · Vehicles built June 25, 2015 – June 29, 2018 (per NHTSA)

Defect description

Vanleigh RV (Vanleigh) is recalling certain 2015-2019 Vilano and Beacon fifth wheel recreational trailers. The suspension shackles may be too short, causing them to fail.

Safety consequence

Failure of the suspension shackle may cause a loss of control, increasing the risk of a crash.

Manufacturer remedy

Vanleigh will notify owners, and dealers will replace the existing shackles with longer ones, free of charge. The recall began August 30, 2019. Owners may contact Vanleigh customer service at 1-662-612-4040.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

try.vin has no NCAP crash-test rating on file for the 2019 Vanleigh Vilano. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2019 Vanleigh Vilano.

Suspension

ODI #11253637

Incident: May 5, 2019 · Filed: September 6, 2019

TL* THE CONTACT OWNS A 2019 VANLEIGH VILANO 365RL. WHILE DRIVING APPROXIMATELY 60 MPH, ANOTHER MOTORIST ALERTED THE CONTACT THAT THE REAR PASSENGER SUSPENSION WAS TILTED TO THE RIGHT. THE RV WAS TOWED TO A PARKING LOT. THE TOW SERVICE CAME BACK THE FOLLOWING DAY AND REPLACED THREE SPRINGS ON THE REAR SUSPENSION. THE CONTACT STATED THAT THERE WERE NORMALLY SIX SPRINGS. THE RV WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT ALSO MENTIONED REPLACING ALL SIX SPRINGS OF THE REAR SUSPENSION ON HIS OWN. THE RV WAS DRIVEN TO AN INDEPENDENT RV SPECIALIST WHO COMPLETELY REPLACED THE REAR SUSPENSION SYSTEM. THE RV WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO THE FRAME MANUFACTURER (LIPPERT COMPONENTS, INC.). THE CONTACT STATED THAT HE FOUND NHTSA CAMPAIGN NUMBER: 19V588000 (SUSPENSION) ON THE MANUFACTURER'S WEB SITE. THE RV WAS REPAIRED.*DT *TT *JS *TR

Other Vanleigh Vilano model years

Check your 2019 Vanleigh Vilano VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Vanleigh Vilano at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Vanleigh VIN