2022 Toyota RAV4 Prime Recalls, Ratings & Complaints

Incident: October 7, 2026 · Filed: October 9, 2026

The contact owns a 2022 Toyota Rav4 Prime. The contact stated that while driving 30 MPH, there was a popping sound coming from the vehicle and the sunroof simultaneously exploded, causing shattered glass to fall onto the closed shade cover. The contact continued driving. The dealer was notified of the failure by phone but denied helping. The failure mileage was approximately 100,300.

Incident: March 18, 2026 · Filed: May 17, 2026

I was beginning to slowly back out of a parking space in a super market parking lot. I had not put my foot on the accelerator because my car begins to slowly inch backwards once it is put into reverse. As the car began to inch backwards, I saw a car approaching down the parking lot driveway behind me. I immediately stepped on my brake, but instead of stopping, my car began to race backwards, accelerating at a fast speed. The car never responded when I put my foot on the brake, so I was unable to stop the car. This caused me to crash into the car driving past me, and that finally stopped the car. Because I was almost perpendicular to the car I hit, and the driver was unable to get out of his car, I then put my car into drive to move it out of the way. My car accelerated out of control, again, this time forward. Again, it did not respond when I put my foot on the brake. My out of control car was quickly heading toward a large metal fire gate. In complete desperation, I stomped very hard on the brake, pressing it to the floor as I was about to hit the gate, and the car finally stopped. In both incidents, my brakes completely failed to stop the car accelerator which was acting on its own. The problem has not been reproduced by Toyota, which says there is nothing wrong with the car. However the data report they gave us is suspect because the data shows no reverse movement of the car and labels the accident a rollover, which it was not. In addition, the inspector told my husband there were more tests he could do, but Toyota had not authorized him to do them. There is a police report, and a witness who observed the whole thing. She said that because of the way the car was moving, it looked like a hit and run accident with the driver trying to make a speedy getaway. There were no warning lights or messages displayed.

Incident: April 10, 2026 · Filed: April 17, 2026

Incident Detail: In April 2026, my 2022 Toyota RAV4 Prime (VIN: [XXX] ) suffered a critical failure where the charging cable became physically locked in the vehicle’s high-voltage (HV) charging port. I transported the vehicle to Ken Garff Cheyenne (authorized Toyota dealer), where management allowed non-certified, non-technical staff to perform unauthorized physical interventions on the HV port. No manufacturer-certified technician was provided for a safe diagnostic. ​Safety Hazard and Immediate Consequence: Following these unauthorized interventions, my wife (an educated automotive technician) determined the vehicle was in a hazardous state, risking thermal runaway or electrical fire. This hazard was so severe that the owner of the property where I was staying in Cheyenne—a [XXX] dependent senior—was too frightened to allow the vehicle to remain on the premises. Due to this immediate safety risk and the dealership's refusal to coordinate a safe tow, I had to have the vehicle towed to a neutral facility to protect the life and property of a vulnerable widow. ​Legal and Technical Context: I am a permanent resident of San Diego, California, and this vehicle is covered under the California Song-Beverly Act. The vehicle is also subject to Federal Recall 23V478 (DC-DC Converter Fire Risk). The dealership’s unauthorized tampering with the HV system, combined with ambient temperatures in Cheyenne often falling below the 41°F safety threshold for this system, created an unmitigated fire risk that the manufacturer has failed to address. ​Request: I am seeking a federal investigation into the dealer’s failure to follow High-Voltage safety protocols. I demand that Toyota Motor North America provide a Field Technical Specialist (FTS) to perform a safe diagnostic at the neutral facility where the car is now located, as the dealership’s actions rendered the vehicle a public safety hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: January 23, 2025 · Filed: January 7, 2026

The mechanized power liftgate— the rear door, the primary way to access the back of vehicle—fails to open & close as intended. A continuous beeping noise sounds due to the liftgate’s failure to fully open and close. We reported this issue to the dealer multiple times during 2025. The dealer refused to acknowledge or fix the problem.

Incident: December 5, 2025 · Filed: December 9, 2025

The contact owns a 2022 Toyota Rav4 Prime. The contact stated that while driving approximately 50 MPH, there was a loud bang like a gunshot heard, and the sunroof shattered. The vehicle was pulled over to the side of the road, and the contact inspected the vehicle, but the contact was unable to determine the cause of the shattering of the sunroof glass. The vehicle was then taken to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 49,500.

Incident: March 14, 2025 · Filed: May 8, 2025

The 12v battery keeps dying. The dealer has checked it multiple times and finally replaced it with a new one which has now died twice. The weather has not been freezing, car is garage, i don't leave anything on that would drain battery and I drive it several times a week. I have over 23,000 miles. It dies at worst time when I really need to go somewhere.

Incident: April 14, 2025 · Filed: April 20, 2025

The idling on this car has had a slight knocking sound but it goes off when engine is warm and i have never got a check engine light. i noticed recently when driving the car had a slight jerk but still no check engine light. until traveling on day it came on and i scanned the codes and replaced all applicable parts - the electrical system is pointing to a bypass hose which was changed as well as a camshaft sensor which still didi not solve the issue. i check online it found many others had this problem. My camshaft was ticking when the car was under warranty around 40k miles but now the car is not. Code p136001 'A' Camshaft Actuator bank 1:General Electrical Failure Code p136415 'C' Camshaft Actuator bank 1: Circuit short to battery or open P268111 Engine coolant bypass valve: circuit short to Ground

Incident: July 30, 2024 · Filed: August 2, 2024

I was slowly pulling (front end forward) into a parking space at a local retail store. Parking spots are perpendicular to building. There is a space about the width of a sidewalk that runs along the front of the building. As I was coming to a complete stop, the car suddenly accelerated on its own, crashed into the building and then stopped. The airbag did not deploy. The car is available for inspection. Both Toyota and Farmers Insurance have said they will pull data from the event logs. The unintended acceleration malfunction put me and others at severe risk. The storefront has a concrete and glass front which was damaged from the impact. If an employee or shopper had been in the area of the crash, they could have been severely injured. I suffered a contusion of the sternum and stiff neck and shoulders. The vehicle's event data has not yet been pulled and evaluated. There were no advance warning signals.

Incident: June 26, 2024 · Filed: June 26, 2024

Driving at highway speed on US101 N with no other vehicles in sight (5:50 AM), moonroof exploded outward with the sound of a gunshot. Moonroof glass and interior cover were closed. Inside temperature was 72 ºF, exterior temperature was 63 ºF and clear, and the sun had not yet crested the mountains (not a large temperature differential). No warning lamps or other problems prior to event. Remaining glass is domed outward.

Incident: April 26, 2024 · Filed: April 30, 2024

On Friday 4/26/24 at about 8 PM, I pulled vehicle into garage and suddenly was aware that vehicle was crashing into shelving against the garage wall in front of its usual stopping place. I recall application of brakes and believe that I put into reverse in order to stop progression/acceleration. After it stopped, I was able to get out of the vehicle and describe the incident to my husband who came out from the house, having heard the crash. The hood and front parts of the car were damaged and it is currently in the collision shop. The shelving unit was destroyed. I am concerned that an unintended acceleration took place and do not know the mechanism.