2013 Toyota Prius Plug-In Hybrid Recalls, Ratings & Complaints

Incident: June 17, 2024 · Filed: June 20, 2024

Brakes stopped functioning fully when i was driving and car started throwing ABS and Brake warning signs. I could not brake my car properly and had to stop the car and get it towed. The dealer said its a brake actuator failure. The error code is C1391.Its costing me around 2000 to get it fixed

Incident: May 23, 2024 · Filed: May 28, 2024

On 5/23/24, the ABS, Traction, and Brakes lights came on the dash and the brakes were not responding. My car was picked up from the Toyota dealer on 5/22/24 afternoon. It passed their multipoint inspection after they replaced all 4 brake pads on 5/21/24. Code C1391 internal leak. The brake actuator and brake pump needed to be replaced. I was quoted $2700 for repairs after I already paid over $570 to replace brake pads.

Incident: May 22, 2024 · Filed: May 24, 2024

Parts failed: accumulator/brake actuator and brake pump [XXX]: I dropped off my car at the Coggin Toyota dealer in Jacksonville, FL to replace all (4) brake pads [XXX]: I picked up my car during lunch and their multipoint inspection passed with no issues [XXX]: Maintenance lights came on the dash during lunch, brakes were not responsive, and my car was beeping non-stop. I dropped off my car to Coggin Toyota to check the issue. They estimated $2722.81 before tax to replace brake actuator and brake pump because there is an internal leak in the brake actuator. [XXX]: The Toyota advisor stated that my car did not qualify for their extended warranty to replace the parts. He also stated that if I pay for the repairs, they will only cover the parts for up to 12k miles or 1 year. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: December 5, 2023 · Filed: January 16, 2024

The rear axle broke and the drivers side wheel sat sideways making the car undriveable. The car has been serviced by the dealer regularly in fact the rear wheel bearings were replaced recently.

Incident: September 15, 2023 · Filed: December 15, 2023

The contact owns a 2013 Toyota Prius Plug-In-Hybrid. The contact stated that upon coming to a complete stop, the ABS warning light illuminated on the instrument panel. After the failure, the contact became aware that the brake pedal needed an excessive amount of force to be depressed while bringing the vehicle to a complete stop. The brake and traction control warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 140,000.

Incident: June 18, 2023 · Filed: July 6, 2023

On [XXX], while driving on a highway with two young children, the dashboard lit up with multiple lights and error warnings. This appeared without warning and with no incident, and the warnings included the main hybrid screen reading “Check PCS System”, triangular Master Warning Light, Brake System Warning Light, Brake Warning Buzzer, ABS Warning Light, and Slip Indicator. We immediately pulled over to the side of the highway to check for any major damage or leaks, but found nothing unusual. We booked a diagnostic with a Toyota service center, where we were informed that brake system error code C1391 was discovered and the service recommendation was to replace the failed (leaking) brake booster and booster pump assembly. The service representative informed us that this exact system failure was previously covered by a Toyota Customer Support Program due to a known faulty part, but the primary coverage date ended in August 2021 and we just barely surpassed the 10-year secondary coverage date of February 2023. We were urged to repair it right away and were told that the vehicle is unsafe to drive in the current condition, as the Antilock Braking System could fail at any time. We have noticed that it takes more pressure to brake the vehicle than prior to the issue, which may have been began deteriorating prior to the issue but was difficult to identify due to the slow progression. We brought the vehicle home with hopes of resolving the matter with Toyota customer engagement. They confirmed that this issue affected almost 1 million vehicles, but because it was a customer support program and not a recall, they could not help us since we were past the 10-year mark (yet well under the 150,000 mile limit to the program). The vehicle still has all the lights described above, and as such is concerning to drive. A second vehicle is critical for our family, so to be suddenly told that our vehicle is unsafe to drive but the defect wasn’t a full recall is concerning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: July 10, 2020 · Filed: July 15, 2020

I WAS INVOLVED IN AN ACCIDENT WITH MY 2013 TOYOTA PRIUS DRIVING ON THE HIGHWAY WITH THE FLOW OF TRAFFIC. THE CAR IN FRONT OF ME SUDDENLY CAME TO A STOP AND I IMMEDIATELY SLAMMED ON MY BRAKES. THERE WAS AMPLE DISTANCE TO STOP SAFELY BUT I ENDED UP REAR ENDING THE CAR AHEAD OF ME WITHOUT ANY NOTICEABLE SLOWDOWN. THE BRAKE PEDAL FELT SPONGY AND THE BRAKES DID NOT APPLY. THE CAR WOULD TYPICALLY JERK IF THE ANTI LOCK BRAKES WERE WORKING BUT THIS DID NOT OCCUR. THE FRONT STEERING WHEEL AND KNEE AIRBAGS DEPLOYED. THE SEAT BELT DID NOT TIGHTEN UP EITHER. THE FRONT END OF THE CAR WAS BADLY DAMAGED AND THE INSURANCE ADJUSTER CONSIDERED THE CAR TOTALED.

Incident: October 16, 2019 · Filed: May 3, 2020

GOT A 2014 PLUG IN.. I SMELL SOME ELCTRICAL BURN UNDER THE HOOD... IT FEEL LIKE COME FROM THE INVTER I SEE A 2ND RECALLED ON THE 2018 BUT I NEVER GOT A RECALLED LETTER.

Incident: January 7, 2019 · Filed: January 7, 2019

THE ABS AND STABILITY CONTROL LIGHT CAME ON. BRAKING SYSTEM FEELS INCONSISTENT. WHEN THE LIGHTS CAME ON, THERE IS NO WARNING SO YOU MIGHT GET AN ACCIDENT WITHOUT BEING PREPARED. THIS IS A REOCCURING SAFETY ISSUE AND FROM MY 10 MINUTE RESEARCH, IT IS A WIDESPREAD PROBLEM.

Incident: March 14, 2018 · Filed: March 14, 2018

BATTERY HOLD DOWN BRACKETS FOR MAIN TRACTION BATTERY (21 KW) BROKE ALLOWING AN UNSAFE CONDITION FOR SEVERAL MONTHS WHILE THE DEALER TRIED TO FIGURE OUT THE NOISE WE REPORTED. THIS HAS HAPPENED TWICE NOW IN 88900 MILES. DEALER AND TOYOTA STATES THAT THIS OCCURRED BECAUSE OF A DIRT ROAD I DRIVE ON REGULARLY. THE "UNBREAKABLE" HOLD DOWN BRACKETS AS DESCRIBED BY THEIR ENGINEER, BROKE TWICE NOW.