2026 Toyota Grand Highlander Recalls & Complaints

Incident: September 3, 2026 · Filed: September 3, 2026

After starting the vehicle and coming to a conplete stop the vehicle will hesitate upon new acceleration. The hesitation causes a lag in the vehicle and it then will jerk or jolt while shifting. The vehicle will Rev up in a low gear and not shift correctly. This causes a safety issue especially when going into traffic. I have not taken it to the dealer as of yet, but I will be. This is an intermittent issue, so i fear toyota will say they cannot replicate the issue. There were no warning lamps when the event happens.

Incident: August 29, 2026 · Filed: August 31, 2026

The weather seal on the moonroof is coming off the moon roof surround and this is causing water and air to leak inside the passenger cabin.

Incident: July 31, 2026 · Filed: August 31, 2026

The front grill by design has bigger holes with potential of rock hitting radiator . I have seen very small damage to radiator more like superficial. A bigger rock could damage the radiator

Incident: August 28, 2026 · Filed: August 28, 2026

Dear NHTSA, I am writing to formally report a potential safety defect involving the front grille design of my 2026 Toyota Grand Highlander Limited. Fortunately, my vehicle has not experienced any damage or mechanical failure related to the grille at this time. However, after examining the design of the front grille and the components located directly behind it, I have serious concerns that the relatively large grille openings may allow rocks and other road debris to pass through and strike critical cooling components, including the radiator and other heat exchangers. My concern is particularly related to the potential consequences of such an impact. If road debris were to damage a cooling component, it could result in coolant loss, overheating, warning messages, reduced vehicle performance, or potentially loss of propulsion. If this occurred while traveling at highway speeds, it could create a significant safety risk for the vehicle occupants as well as other motorists. I understand that NHTSA is currently reviewing concerns regarding the front grille design of 2024–2026 Toyota Grand Highlander vehicles. I would like my vehicle and this concern to be included in NHTSA’s review. I believe this issue warrants further evaluation because the concern exists even before an actual failure occurs. A safety defect should ideally be identified and addressed before owners experience a failure that could potentially create a hazardous situation while driving. I respectfully request that NHTSA investigate whether the front grille provides adequate protection for the critical cooling components behind it and determine whether Toyota should provide a protective screen, revised grille design, or another corrective measure. Again, I want to emphasize that I am reporting this as a potential safety defect. My vehicle has not suffered damage or experienced a failure at this time. I am submitting this complaint proactively because I believe the design presents a foreseeable risk

Incident: June 12, 2026 · Filed: August 27, 2026

Small object came through the front grill and put a hole in AC condensing unit. Grill does not protect from small road objects.

Incident: August 24, 2026 · Filed: August 26, 2026

While stopped waiting to takeoff (turn into a road or area), during takeoff acceleration, the car will sometimes have a dead pedal and slow or stop acceleration leaving you a sitting duck in an intersection or road.

Incident: July 1, 2026 · Filed: August 24, 2026

road debris entered into front grill though the holes in grill adn damaged condensor fins causing vehicle to loose propulsion. Vehicle would not travel over 25 mph after the incidnet. This is safety issue as vehicle slowed from 55MPH to 25MPH rather abruptly on highway. Multiple lamps came on dash at time of incident and were reatained untill fixed (non warranty repair)

Incident: August 23, 2026 · Filed: August 24, 2026

For no reason at all windshield has two parallel lines crack in upper right side, no signs of impact and not sure what caused this.

Incident: August 19, 2026 · Filed: August 24, 2026

During normal highway driving, a small road rock/debris entered through the front grille and damaged the radiator/heat exchanger. The damage caused coolant to leak, and the vehicle subsequently lost propulsion and became disabled. I had to stop driving the vehicle and have it inspected and repaired by a Toyota dealer. The Toyota dealer inspected the vehicle and confirmed that the radiator/heat exchanger was damaged by an outside object and was leaking. The dealer indicated that rocks or road debris can cause this type of damage. The total repair cost was approximately $1,350. I am concerned that the large openings in the front grille allow ordinary road debris to reach the radiator/heat exchanger, which is not adequately protected. A relatively small road object resulted in a critical cooling system failure and sudden loss of vehicle propulsion, creating a significant safety risk, particularly if this occurs while traveling at highway speed. I understand that NHTSA is currently reviewing similar reports involving the grille design and damage to the heat exchanger/radiator on Toyota Grand Highlander vehicles. My vehicle experienced a similar failure. I believe this issue should be investigated as a potential design-related safety defect and that an appropriate protective solution should be considered.

Incident: July 26, 2026 · Filed: August 22, 2026

My 2026 Toyota Grand Highlander Platinum has an issue that is commonly referred to as "cabin boom". It occurs at approximately 30mph going over bumps or rough patches in the road. When it occurs it creates a droning noise that amplifies the bump or rough surface you drove over and also creates a cabin pressure similar to flying on an airplane. This issue has caused significant ear pressure and headaches from driving my brand new vehicle. As a chronic migraine sufferer, this is unacceptable when you commute 25 miles to and from work. The issue has been reproduced by the Toyota dealership and they are currently in a waiting phase of next steps from Toyota corporate engineers on how to fix the issue, however there is no timeline on a resolution. Considering this has been an issue for over two years I find it unacceptable. They have added sound proofing materials around the spare tire and that didn't help the issue at all. This has apparently been an issue since the first Grand Highlander model was released, however it seems to not affect all of them but does affect across all trim levels.My dealership just got two brand new Grand Highlanders in this past week, and they make the same exact sound. I'm hoping with more reports of the issue Toyota will actually address it because I know of many other owners who have this problem. Other owners have taken these same steps over the past two years with no results. Please help make Toyota recognize and figure this out.