NHTSA vehicle safety data

2009 Suzuki VL800 Recalls & Complaints

The 2009 Suzuki VL800 has 1 NHTSA recall campaign and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Suzuki dealer.

NHTSA recall and complaint data for the 2009 Suzuki VL800. Recall data is refreshed daily from NHTSA.

2009 Suzuki VL800 owner complaints

Owners have filed 4 complaints with NHTSA about the 2009 Suzuki VL800, describing incidents dated July 2, 2010 to May 11, 2016.

Most-cited components

Power Train 2 complaints
Unknown or Other 1 complaint
Vehicle Speed Control 1 complaint

Of the 4 complaints on file, 1 reports a crash (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10870646 · Filed May 24, 2016
MAKING A DOWNSHIFT FROM 3RD TO 2ND AROUND A CORNER I APPLIED THROTTLE THEN A BIG CLUNK OCCURRED AND I LOST POWER TO MY REAR DRIVE. I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD, ELUDING TRAFFIC TO MOVE TO THE RIGHT LANE. UPON INVESTIGATION I'VE FOUND OUT THE PROBLEM TO BE THE FINAL DRIVE PROPELLER…
ODI #10537186 · Filed August 26, 2013
COMING AROUND A CORNER UP A HILL I APPLIED THROTTLE TO GO UP HILL. A LARGE CLUNK OCCURRED AND I LOST ALL FORWARD ABILITY. NOT HAVING POWER I BARELY MADE IT TO THE SIDE OF THE ROAD ALMOST GETTING HIT. I SWERVED TO AVOID A CAR AND WENT DOWN. NOTHING OTHER THAN MINOR SCRAPES AS A RESULT. UPON…
ODI #10406374 · Filed June 8, 2011
2009 SUZUKI VL800TK9. CONSUMER WRITES IN REGARDS TO REPAIR REIMBURSEMENT AND RECALL *TGW THE CONSUMER STATED SHE RETURNED THE BIKE TO THE DEALER, BECAUSE THE SPEEDOMETER WAS OFF BY 9 MPH. THE DEALER REPLACED THE COMPONENT, BUT IT DIDN'T CORRECT THE PROBLEM. THE CONSUMER WAS INFORMED THERE WASN'T…

Read all 4 complaints

REGULATOR ASSEMBLIES

NHTSA #11V108000 · Electrical System — Alternator/Generator/Regulator · NHTSA notice

Reported February 23, 2011 · AMERICAN SUZUKI MOTOR CORP.

Potentially affected: 73,426 vehicles

Owners notified March 2, 2011 · Vehicles built May 1, 2008 – March 31, 2009 (per NHTSA)

Defect description

SUZUKI IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MOTORCYCLES MANUFACTURED FROM JULY 2007 THROUGH SEPTEMBER 2009, EQUIPPED WITH REGULATOR/RECTIFIER ASSEMBLIES, SUZUKI PART NUMBERS 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. SOME REGULATOR/RECTIFIER ASSEMBLIES WERE PRODUCED WITH INSUFFICIENT ADHESION BETWEEN THE POWER MODULE (CIRCUIT BOARD) AND THE RECTIFIER CASE THAT CONTAINS A HEAT SINK TO DISSIPATE HEAT. DUE TO INSUFFICIENT ADHESION, HEAT GENERATED ON THE POWER MODULE CIRCUIT BOARD CAN CAUSE THE CIRCUIT BOARD TO DEFORM, AND LIFT OF THE CASE.

Safety consequence

THIS CONDITION CAUSES EXCESSIVE HEAT ON THE CIRCUIT BOARD AND UNCONTROLLED ELECTRIC CURRENT OUTPUT, WHICH CAN RESULT IN INSUFFICIENT CHARGING CURRENT BEING PROVIDED TO THE MOTORCYCLE BATTERY. THIS CAN CAUSE DISCHARGE OF THE BATTERY AND CAN LEAD TO ENGINE STALLING AND/OR A NO-START CONDITION. ENGINE STALLING WHILE RIDING CAN INCREASE THE RISK OF A CRASH.

Manufacturer remedy

SUZUKI WILL NOTIFY OWNERS AND SUZUKI DISTRIBUTORS WILL REPLACE THE REGULATOR/RECTIFIER WITH AN IMPROVED PART FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2011. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2009 Suzuki VL800. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

4 owner complaints have been filed with NHTSA for the 2009 Suzuki VL800.

Power Train

ODI #10870646

Incident: May 11, 2016 · Filed: May 24, 2016

MAKING A DOWNSHIFT FROM 3RD TO 2ND AROUND A CORNER I APPLIED THROTTLE THEN A BIG CLUNK OCCURRED AND I LOST POWER TO MY REAR DRIVE. I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD, ELUDING TRAFFIC TO MOVE TO THE RIGHT LANE. UPON INVESTIGATION I'VE FOUND OUT THE PROBLEM TO BE THE FINAL DRIVE PROPELLER GEAR AND THE COUPLING WERE RUSTED AND TOTALLY WORN OUT. THIS JOINT HAD NEVER BEEN LUBED DURING ORIGINAL MANUFACTURING ASSEMBLY. THIS LACK OF LUBE HAS CAUSED THE SHAFT TO RUST CAUSING THE FAILURE. THE GREASE CANNOT BE APPLIED UNLESS THE FINAL DRIVE IS TOTALLY REMOVED. THIS IS A KNOWN PROBLEM WITH THE 05-09 MODEL YEARS AS EVIDENCE BY A SIMPLE INTERNET SEARCH. NO RECALL HAS BEEN ISSUED YET. THE COST OF THE CHANGE IS AROUND $600 - $800 DOLLARS BUT THIS DEFFECT CAN CERTAINLY CAUSE AN ACCIDENT FOR THE LOSS OF POWER WHILE OPERATING THE MOTORCYCLE ON THE HIGHWAY.

Power Train

ODI #10537186

Crash

Incident: August 21, 2013 · Filed: August 26, 2013

COMING AROUND A CORNER UP A HILL I APPLIED THROTTLE TO GO UP HILL. A LARGE CLUNK OCCURRED AND I LOST ALL FORWARD ABILITY. NOT HAVING POWER I BARELY MADE IT TO THE SIDE OF THE ROAD ALMOST GETTING HIT. I SWERVED TO AVOID A CAR AND WENT DOWN. NOTHING OTHER THAN MINOR SCRAPES AS A RESULT. UPON DETERMINING THE PROBLEM TO BE THE FINAL DRIVE I REMOVED THE PART AND FOUND IT WAS NEVER LUBED DURING ASSEMBLY. THIS CAUSED THE SHAFT TO RUST CAUSING THE FAILURE. THERE IS NO WAY TO APPLY GREASE TO THE PART WITHOUT ENTERING THE NON MAINTENANCE AREA OF THE FINAL DRIVE. THIS IS A KNOWN PROBLEM WITH THE 05-09 MODEL YEARS AS EVIDENCE BY A SIMPLE INTERNET SEARCH. NO RECALL HAS BEEN ISSUED YET. I WAS LUCKY AND MADE IT OUT OF TRAFFIC, OTHERS MAY NOT BE AS LUCKY. *TR

Vehicle Speed Control

ODI #10406374

Incident: July 2, 2010 · Filed: June 8, 2011

2009 SUZUKI VL800TK9. CONSUMER WRITES IN REGARDS TO REPAIR REIMBURSEMENT AND RECALL *TGW THE CONSUMER STATED SHE RETURNED THE BIKE TO THE DEALER, BECAUSE THE SPEEDOMETER WAS OFF BY 9 MPH. THE DEALER REPLACED THE COMPONENT, BUT IT DIDN'T CORRECT THE PROBLEM. THE CONSUMER WAS INFORMED THERE WASN'T ANYTHING ELSE THAT COULD BE DONE AND IT WAS PROBABLY A MANUFACTURING DEFECT. *JB

Unknown or Other

ODI #10396272

Incident: March 18, 2011 · Filed: April 10, 2011

RECEIVED RECALL NOTICE FROM AMERICAN SUZUKI CORPORATION. MOTOR CYCLE TAKEN TO DEALERSHIP, IT HAS BEEN THERE A MONTH. I HAVE CHECKED EVERY WEEK. I AM TOLD THEY HAVE GOTTEN NO RESPONSE ABOUT A REPLACEMENT PART. CAN YOU HELP RESOLVE THIS MATTER IN A TIMELY FASHION? COMPONENT THAT NEEDS TO BE REPLACED: RECTIFIER ASSEMBLIES INSTALLED ON THE AFFECTED MODELS MAY HAVE A CONDITION WHICH CAN CAUSE THE INTERNAL CIRCUIT BOARD TO FAIL IN SERVICE DUE TO EXCESSIVE HEAT.

Other Suzuki VL800 model years

Check your 2009 Suzuki VL800 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Suzuki VL800 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Suzuki VIN