NHTSA vehicle safety data

2008 Suzuki VL800 Recalls & Complaints

The 2008 Suzuki VL800 has 1 NHTSA recall campaign and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Suzuki dealer.

NHTSA recall and complaint data for the 2008 Suzuki VL800. Recall data is refreshed daily from NHTSA.

2008 Suzuki VL800 owner complaints

Owners have filed 3 complaints with NHTSA about the 2008 Suzuki VL800, describing incidents dated August 1, 2009 to May 7, 2015.

Most-cited components

Electrical System 2 complaints
Fuel/Propulsion System 1 complaint

Newest complaints

ODI #10864377 · Filed May 11, 2016
TL* THE CONTACT OWNS A 2008 SUZUKI VL800TK8. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING THE SAME FAILURE AS INDICATED IN A RECALL FOR THE ELECTRICAL SYSTEM. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN THE…
ODI #10407575 · Filed June 20, 2011
TL*THE CONTACT OWNS A 2008 SUZUKI BOULEVARD M109R VL800 MOTORCYCLE. THE CONTACT STATED THAT WHEN THE FUEL TANK WAS LOW ON FUEL, THE VEHICLE WOULD STALL SPORADICALLY. THE FUEL TANK WAS NOT EMPTY AND THE VEHICLE WOULD OFTEN FAIL TO RESTART UNLESS THE FUEL TANK WAS FULL TO CAPACITY. THE VEHICLE WAS…
ODI #10394049 · Filed April 2, 2011
SUZUKI SAFETY RECALL CAMPAIGN (RECTIFIER ASSEMBLIES) I TOOK MY MOTORCYCLE IN TO THE DEALER FOR THIS SAFETY RECALL ASSUMING THEY WOULD BE ABLE TO TAKE CARE OF IT QUICKLY. THE BIKE HAS NOW BEEN IN THEIR SHOP GOING ON THREE WEEKS WAITING FOR THE RECALL PART TO BE REPLACED. SUZUKI IS BEING VERY SLOW TO…

Read all 3 complaints

REGULATOR ASSEMBLIES

NHTSA #11V108000 · Electrical System — Alternator/Generator/Regulator · NHTSA notice

Reported February 23, 2011 · AMERICAN SUZUKI MOTOR CORP.

Potentially affected: 73,426 vehicles

Owners notified March 2, 2011 · Vehicles built July 1, 2007 – April 30, 2008 (per NHTSA)

Defect description

SUZUKI IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MOTORCYCLES MANUFACTURED FROM JULY 2007 THROUGH SEPTEMBER 2009, EQUIPPED WITH REGULATOR/RECTIFIER ASSEMBLIES, SUZUKI PART NUMBERS 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. SOME REGULATOR/RECTIFIER ASSEMBLIES WERE PRODUCED WITH INSUFFICIENT ADHESION BETWEEN THE POWER MODULE (CIRCUIT BOARD) AND THE RECTIFIER CASE THAT CONTAINS A HEAT SINK TO DISSIPATE HEAT. DUE TO INSUFFICIENT ADHESION, HEAT GENERATED ON THE POWER MODULE CIRCUIT BOARD CAN CAUSE THE CIRCUIT BOARD TO DEFORM, AND LIFT OF THE CASE.

Safety consequence

THIS CONDITION CAUSES EXCESSIVE HEAT ON THE CIRCUIT BOARD AND UNCONTROLLED ELECTRIC CURRENT OUTPUT, WHICH CAN RESULT IN INSUFFICIENT CHARGING CURRENT BEING PROVIDED TO THE MOTORCYCLE BATTERY. THIS CAN CAUSE DISCHARGE OF THE BATTERY AND CAN LEAD TO ENGINE STALLING AND/OR A NO-START CONDITION. ENGINE STALLING WHILE RIDING CAN INCREASE THE RISK OF A CRASH.

Manufacturer remedy

SUZUKI WILL NOTIFY OWNERS AND SUZUKI DISTRIBUTORS WILL REPLACE THE REGULATOR/RECTIFIER WITH AN IMPROVED PART FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2011. OWNERS MAY CONTACT SUZUKI AT 1-714-572-1490.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2008 Suzuki VL800. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2008 Suzuki VL800.

Electrical System

ODI #10864377

Incident: May 7, 2015 · Filed: May 11, 2016

TL* THE CONTACT OWNS A 2008 SUZUKI VL800TK8. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING THE SAME FAILURE AS INDICATED IN A RECALL FOR THE ELECTRICAL SYSTEM. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN THE RECALL, ALTHOUGH THE VEHICLE EXPERIENCED THE SAME FAILURES LISTED IN THE RECALL. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 11,000. ..UPDATED 06/08/16 *BF THE CONSUMER STATED THE BATTERY WOULD DIE FOR NO APPARENT REASON. THE BATTERY WAS REPLACED. HOWEVER, THE PROBLEM CONTINUED.

Fuel System, Gasoline

ODI #10407575

Incident: August 1, 2009 · Filed: June 20, 2011

TL*THE CONTACT OWNS A 2008 SUZUKI BOULEVARD M109R VL800 MOTORCYCLE. THE CONTACT STATED THAT WHEN THE FUEL TANK WAS LOW ON FUEL, THE VEHICLE WOULD STALL SPORADICALLY. THE FUEL TANK WAS NOT EMPTY AND THE VEHICLE WOULD OFTEN FAIL TO RESTART UNLESS THE FUEL TANK WAS FULL TO CAPACITY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE OR REPAIR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 3,000.

Electrical System

ODI #10394049

Incident: March 2, 2011 · Filed: April 2, 2011

SUZUKI SAFETY RECALL CAMPAIGN (RECTIFIER ASSEMBLIES) I TOOK MY MOTORCYCLE IN TO THE DEALER FOR THIS SAFETY RECALL ASSUMING THEY WOULD BE ABLE TO TAKE CARE OF IT QUICKLY. THE BIKE HAS NOW BEEN IN THEIR SHOP GOING ON THREE WEEKS WAITING FOR THE RECALL PART TO BE REPLACED. SUZUKI IS BEING VERY SLOW TO PROVIDE THEIR DEALERS WITH THIS PART. THEY(THE DEALER) HAVE NO IDEA WHEN THEY WILL GET THE PARTS. THIS IN TURN MEANS THAT I DO NOT HAVE USE OF MY BIKE. SUZUKI NEEDS TO MAKE THESE RECALL PARTS AVAILABLE TO THEIR DEALS AS SOON AS POSSIBLE. *TR

Other Suzuki VL800 model years

Check your 2008 Suzuki VL800 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Suzuki VL800 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Suzuki VIN