NHTSA vehicle safety data

1999 Pontiac Sunfire Recalls, Ratings & Complaints

The 1999 Pontiac Sunfire has 5 NHTSA recall campaigns and 93 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Pontiac dealer.

NHTSA recall and complaint data for the 1999 Pontiac Sunfire, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1999 Pontiac Sunfire owner complaints

Owners have filed 93 complaints with NHTSA about the 1999 Pontiac Sunfire, describing incidents dated December 15, 1998 to October 1, 2013.

Most-cited components

Electrical System 20 complaints
Engine 18 complaints
Service Brakes 13 complaints
Air Bags 10 complaints
Power Train 8 complaints
Unknown or Other 7 complaints

Of the 93 complaints on file, 9 report a crash and 4 a fire; across all 93 complaints, owners report 4 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10631179 · Filed September 5, 2014
I WAS PURCHASING THIS USED CAR FROM A DEALER. THEY REPLACED THE IGNITION ASSEMBLY 3 TIMES. THE CAR WOULD MYSTERIOUSLY SHUT OFF, THE IGNITION ASSEMBLY WOULD NOT ALLOW THE KEY TO BE REMOVED AND MULTIPLE TIMES THIS HAPPENED. I LOST ALLOT OF MONEY I PUT ON THE CAR AS IT BECAME OBVIOUS THEY COULD NOT FIX…
ODI #10501229 · Filed March 4, 2013
I WAS DRIVING THE CAR JUST AFTER I PURCHASED IT AND BECAME COLD SO I TURNED ON THE HEATER AND WITHIN 30 SECONDS SMOKE FILLED THE CAR. I THOUGHT THE ENGINE WAS ON FIRE. IT SMELLED LIKE BURNING OIL OR GAS. I CALLED DELPHI ABOUT RECALLS AND BEFORE I COULD FINISH A SENTENCE THE MAN CUT ME OFF SAYING…
ODI #10466611 · Filed July 19, 2012
TL* THE CONTACT OWNS A 1999 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE DECELERATED. THE CONTACT WAS ABLE TO SAFELY MANEUVER TO THE SHOULDER AND SHUT THE VEHICLE OFF. THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS THEN TOWED TO A DEALER FOR DIAGNOSIS. THE DEALER STATED…

Read all 93 complaints

INTERMEDIATE STEERING SHAFT/LOSS OF STEERING

NHTSA #08E063000 · Steering · NHTSA notice

Reported October 17, 2008 · DORMAN PRODUCTS, INC.

Potentially affected: 3,855 vehicles

Owners notified October 16, 2008

Defect description

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Safety consequence

IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

Notes

THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL PRESSURE REGULATORS

NHTSA #07E021000 · Fuel System, Other — Storage — Tank Assembly — Pressure Relief Devices · NHTSA notice

Reported March 12, 2007 · DELPHI

Potentially affected: 742 vehicles

Owners notified April 27, 2007

Defect description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Safety consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/IGNITION SWITCH

NHTSA #04V036000 · Electrical System — Ignition — Switch · NHTSA notice

Reported January 27, 2004 · GENERAL MOTORS CORP.

Potentially affected: 1,415,231 vehicles

Manufacturer campaign 04002 · Owners notified March 1, 2004 · Vehicles built March 1, 1998 – June 30, 1999 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.

Safety consequence

IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.

Manufacturer remedy

DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.

Notes

GM RECALL NO. 04002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/FMVSS 101

NHTSA #99V218000 · Interior Lighting · NHTSA notice

Reported August 11, 1999 · GENERAL MOTORS CORP.

Potentially affected: 6,584 vehicles

Manufacturer campaign 99047 · Owners notified September 2, 1999 · Vehicles built May 1, 1999 – August 31, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION." THE INSTRUMENT PANEL BACKLIGHTING MAY NOT FUNCTION AFTER ADJUSTING THE INTERIOR LIGHT INTENSITY.

Safety consequence

IF THE INSTRUMENT PANEL IS NOT LIT AT NIGHT, THE DRIVER MAY NOT BE ABLE TO SEE THE CONTROLS AND DISPLAYS.

Manufacturer remedy

DEALERS WILL TEST THE BODY CONTROL MODULE, AND IF NECESSARY, REPLACE IT.

Notes

OWNER NOTIFICATION BEGAN SEPTEMBER 2, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

1999 Pontiac Sunfire 2-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 4

Side Crash

Not Rated

Driver: 1, Passenger: 2

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

1999 Pontiac Sunfire 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 1, Passenger: 3

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

93 owner complaints have been filed with NHTSA for the 1999 Pontiac Sunfire.

Steering; Service Brakes; Engine

ODI #10631179

Incident: October 1, 2013 · Filed: September 5, 2014

I WAS PURCHASING THIS USED CAR FROM A DEALER. THEY REPLACED THE IGNITION ASSEMBLY 3 TIMES. THE CAR WOULD MYSTERIOUSLY SHUT OFF, THE IGNITION ASSEMBLY WOULD NOT ALLOW THE KEY TO BE REMOVED AND MULTIPLE TIMES THIS HAPPENED. I LOST ALLOT OF MONEY I PUT ON THE CAR AS IT BECAME OBVIOUS THEY COULD NOT FIX IT AND I HAD TO LET THEM TAKE IT BACK WITH NO REFUND TO ME.........THEY SAID AT THE DEALER THAT I WAS LUCKY THAT I DIDN'T HAVE A FIRE. *TR

Engine and Engine Cooling; Exterior Lighting

ODI #10501229

Incident: November 14, 2012 · Filed: March 4, 2013

I WAS DRIVING THE CAR JUST AFTER I PURCHASED IT AND BECAME COLD SO I TURNED ON THE HEATER AND WITHIN 30 SECONDS SMOKE FILLED THE CAR. I THOUGHT THE ENGINE WAS ON FIRE. IT SMELLED LIKE BURNING OIL OR GAS. I CALLED DELPHI ABOUT RECALLS AND BEFORE I COULD FINISH A SENTENCE THE MAN CUT ME OFF SAYING THAT THE ONLY RECALL ON MY CAR WAS FOR THE O RING ON THE FUEL. HE SAID IF I HAVE A 1999 AND THAT WAS DEFECTIVE I WOULD BE SPEWING FUEL EVERYWHERE. I DESCRIBED WHAT HAPPENED AND HE JUST CUT ME OFF. MY BROTHER PURCHASED THE CAR FROM A DEALER FOR OVER 3,000 DOLLARS AND I HAVE NO IDEA WHAT THE ODOMETER IS SUPPOSE TO BE BECAUSE HE SAID THE DEALER TOLD HIM TO BRING IT BACK AND HE WOULD FIX IT. AFTER HE PAID THE DEALER HE CONTACTED THE DEALER AND THE DEALER TOLD HIM THAT HE WILL CONTACT MY BROTHER WHEN HE CAN FIX IT. ACCORDING TO THE ODOMETER IT HAS A LITTLE OVER 23,000 MILES. I ALSO NOTICED THE HEADLIGHTS KEEP GOING OUT AND THERE IS YELLOW HOT WIRE HANGING OUT OF THE FUSE BOX. *TR

Electrical System

ODI #10466611

Incident: July 15, 2012 · Filed: July 19, 2012

TL* THE CONTACT OWNS A 1999 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE DECELERATED. THE CONTACT WAS ABLE TO SAFELY MANEUVER TO THE SHOULDER AND SHUT THE VEHICLE OFF. THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS THEN TOWED TO A DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THEY HAD TO REPLACE THE IGNITION SWITCH. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V036000 (ELECTRICAL SYSTEM). THE FAILURE AND THE CURRENT MILEAGES WERE 86,000.

Electrical System

ODI #10446306

Incident: October 22, 2011 · Filed: February 2, 2012

THE INSTRUMENTAL PANEL ON MY 1999 PONTIAC SUNFIRE RECENTLY STARTED FUNCTIONING ERRATICALLY I.E. GAUGES (GAS GAUGE, TEMPERATURE GAUGE, SPEEDOMETER) WOULD START FLUCTUATING WILDLY. LOCAL PONTIAC DEALERSHIP HAS DIAGNOSED THE VEHICLE AS HAVING A DEFECTIVE (OR BURNED OUT) INSTRUMENTAL PANEL CLUSTER. I WAS TOLD THAT THIS COMPONENT WAS NOT COVERED UNDER ANY TYPE OF LIFETIME WARRANTY AND THAT THE REPAIRS WOULD COST $472.31. IN RESEARCHING THIS PROBLEM ON THE INTERNET, IT APPEARS TO BE SYSTEMIC AMONG LATE 1990 TO EARLY 2000 PONTIAC VEHICLES. FROM A SAFETY STANDPOINT, IT IS A DANGEROUS CIRCUMSTANCE TO BE DRIVING 70-75 MPH ON THE HIGHWAY AND TO HAVE YOUR INSTRUMENT PANEL START MALFUNCTIONING. PONTIAC SHOULD BE FORCED TO RECALL THESE DEFECTIVE INSTRUMENT PANEL CLUSTERS AND REPAIR THEM AT NO CHARGE. *KB

Service Brakes, Hydraulic

ODI #10368095

Incident: November 15, 2010 · Filed: November 29, 2010

TL*THE CONTACT OWNS A 1999 PONTIAC SUNFIRE. WHILE DRIVING AT AN UNKNOWN SPEED DOWN A HILL DURING RAINY WEATHER, THE BRAKES LOCKED WHEN ENGAGED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THERE WAS BRAKE DUST WHICH CAUSED THE FAILURE. THE DUST WAS REMOVED BUT THE FAILURE OCCURRED AGAIN TWO WEEKS LATER DURING RAINY CONDITIONS. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN. THE VIN WAS UNAVAILABLE.

Electrical System

ODI #10346427

Fire

Incident: March 9, 2010 · Filed: July 30, 2010

DURING NORMAL OPERATION OF A 1999 PONTIAC SUNFIRE, 4DR, 2.2 LITER ENGINE, AUTOMATIC TRANSMISSION. THE WIRING HARNESS AT THE DRIVERS DOOR FRAME, AT THE CONNECTION OF THE UNDERDASH HARNESS AND THE REAR OF VEHICLE HARNESS SHORTED, CAUSING THE INSULATION TO CATCH FIRE. THIS SITUATION SHORTED OTHER CIRCUITS IN THE HARNESS CAUSING BRAKING PROBLEMS WITH THE ANTI-LOCK SYSTEM. VEHICLE WAS ABLE TO BE STOPPED SAFELY, AND THE DRIVER, WITH GOOD SAMARITAN ASSISTANCE WAS ABLE TO EXTINGUISH THE FIRE. FIRE RENDERED THE HOOD LATCH INOPERATIVE. THIS PREVENTED THE DRIVER FROM DISCONNECTING THE BATTERY GROUND CABLE, TO PREVENT FURTHER DAMAGE AND/OR FIRE. *TR

Engine and Engine Cooling

ODI #10321990

Fire

Incident: July 24, 2009 · Filed: March 23, 2010

1999 PONTIAC SUNFIRE, VEHICLE CAUGHT FIRE. *BF WHILE DRIVING, THE CONSUMER FELT A THUMP AND BEGAN TO LOOSE POWER. ONCE THE CONSUMER STOPPED, HE NOTICED FIRE WAS COMING FROM UNDER THE FRONT END OF THE VEHICLE. OHIO TRAFFIC CRASH REPORT # 10-0699-90.*JB UPDATED 04/14/10 *BF

Exterior Lighting

ODI #10298920

Incident: November 1, 2009 · Filed: January 10, 2010

I HAVE 1999 PONTIAC SUNFIRE AND I HAVE HAD NOTHING BUT PROBLEMS WITH THE HEADLIGHTS. ONE IS THAT I HAVE NO HIGHBEAMS AND THE HEADLIGHTS GO OUT AFTER DRIVING IT FOR AWHILE,THE DRIVERSIDE LIGHT FLASHES ON AND OFF FROM TIME TO TIME I HAVE TALKED TO A MECHANIC ABOUT THIS PROBLEM AND THEY SAID IT WAS THE HEADLIGHT HARNESS. I WENT TO THE LOCAL JUNK YARD GOT A HARNESS AND IT SOLVED THE PROBLEM BUT JUST RECENTLY IT HAPPENED AGAIN. *TR

Electrical System

ODI #10277533

Fire

Incident: July 27, 2006 · Filed: July 20, 2009

I HAD A 1999 PONTIAC SUNFIRE. IT WAS PARKED OUTSIDE OF RESIDENCE WHEN IT CAUGHT ON FIRE. THIS WAS A FEW YEARS AGO APPROXIMATELY AROUND JULY OF 2006. PONTIAC DID NOT ACCEPT FAULT. THEY SAID THE FIRE DESTROYED ANY EVIDENCE OF A DEFECT. *TR

Exterior Lighting

ODI #10245339

Incident: October 10, 2008 · Filed: October 14, 2008

MY LOW BEAM HEADLIGHTS WILL NOT WORK. I HAVE REPLACED THE COMBINATION SWITCH ON THE STEERING COLUMN TWICE. EACH TIME THE LIGHTS WILL WORK FOR ABOUT 6 MONTHS THEN THEY QUIT. THE DEALER SAID THERE COULD BE A PROBLEM WITH THE FRONT WIRING HARNESS BUT A NEW HARNESS IS $600. I BELIEVE GM HAS A PROBLEM WITH THEIR DESIGN AND SHOULD REPLACE THE DEFECTIVE HARNESS. *TR

Other Pontiac Sunfire model years

Check your 1999 Pontiac Sunfire VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Pontiac Sunfire at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Pontiac VIN