NHTSA vehicle safety data

2006 Nissan Frontier Recalls, Ratings & Complaints

The 2006 Nissan Frontier has 7 NHTSA recall campaigns and 617 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Nissan dealer.

NHTSA recall and complaint data for the 2006 Nissan Frontier, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Nissan Frontier owner complaints

Owners have filed 617 complaints with NHTSA about the 2006 Nissan Frontier, describing incidents dated September 20, 2005 to September 16, 2026.

Most-cited components

Fuel/Propulsion System 251 complaints
Power Train 220 complaints
Engine 155 complaints
Steering 34 complaints
Electrical System 31 complaints
Air Bags 26 complaints

Of the 617 complaints on file, 13 report a crash and 2 a fire; across all 617 complaints, owners report 13 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11764830 · Filed September 16, 2026
I have two recalls, I´m living in [XXX] and I drive this vehicle here. I don´t know where they can solve this problems. NHTSA Recall Number23E-012 NHTSA Recall Number10V-517 I have set a letter in the Upload Files section INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5…
ODI #11728571 · Filed April 1, 2026
See attached document for complaint.
ODI #11728559 · Filed April 1, 2026
Whenever I fill ip the tank I get a fuel smell inside the vehicle. I do not overfill the tank and always stop filling when the fuel pump stops the first time. I have not been able to identify a leak and have not seen fuel leaking under the vehicle. The smell is strong for about the first 1/4 tank of…

Read all 617 complaints

Owner-reported

2006 Nissan Frontier mileage at failure

547 of the 617 complaints on file for the 2006 Nissan Frontier give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Fuel/Propulsion System	Median 55,000 miles	Middle half 45,000–80,000 miles	Based on 220 complaints
Power Train	Median 105,000 miles	Middle half 85,000–125,000 miles	Based on 206 complaints
Engine	Median 100,000 miles	Middle half 80,000–125,000 miles	Based on 135 complaints
Steering	Median 45,000 miles	Middle half 16,000–75,000 miles	Based on 32 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Nissan Frontier in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP26-003: Fuel smell and loss of motive power
Closed October 9, 2026
Defect Petition DP12-004: Transmission Failures
Closed October 22, 2016

Open and recently closed NHTSA defect investigations

ENGINE CONTROL MODULE

NHTSA #10V517000 · Engine and Engine Cooling · NHTSA notice

Reported October 28, 2010 · NISSAN NORTH AMERICA, INC.

Potentially affected: 747,480 vehicles

Owners notified December 6, 2010 · Vehicles built August 5, 2004 – June 15, 2006 (per NHTSA)

Defect description

NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.

Safety consequence

THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOWER LINK REPLACEMENT PARTS

NHTSA #10E019000 · Suspension — Front — Control Arm — Lower Arm · NHTSA notice

Reported May 20, 2010 · NISSAN NORTH AMERICA, INC.

Potentially affected: 1,873 vehicles

Owners notified July 12, 2010

Defect description

NISSAN IS RECALLING CERTAIN FRONT AND REAR LOWER LINKS, P/NOS. 54501ZQ00A, 54500ZQ00A, 551A1ZQ00A, 551A0ZQ00A , 54501EA00A, 54500EA00A, 551A1EA500, 551A0EA500, 54501ZR00A, AND 54500ZR00A, SOLD BETWEEN NOVEMBER 25, 2009 AND MAY 14, 2010 AS REPLACEMENT PARTS FOR MODEL YEAR 2004 THROUGH 2010 TITAN, ARMADA, AND QX56, AND MODEL YEARS 2005 THROUGH 2010 FRONTIER, XTERRA, AND PATHFINDER VEHICLES. THE LOWER CONTROL LINK ASSEMBLY HAS TWO CYLINDRICAL COLLARS FORMING THE INBOARD ATTACHMENT POINTS TO THE CHASSIS. DUE TO AN IMPROPER WELDING PROCESS SOME COLLARS MAY CONTAIN WELDS THAT DO NOT MEET STRENGTH SPECIFICATIONS.

Safety consequence

IF THE COLLAR WELD SEPARATES, THE VEHICLE HANDLING WILL DETERIORATE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

NISSAN WILL NOTIFY OWNERS AND DEALERS WILL REPLACE ANY AFFECTED LOWER LINK FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 12, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

FUEL TANK SHELLS

NHTSA #10V075000 · Fuel System, Gasoline — Storage — Auxillary Tank · NHTSA notice

Reported March 3, 2010 · NISSAN NORTH AMERICA, INC.

Potentially affected: 80,689 vehicles

Owners notified March 22, 2010 · Vehicles built January 23, 2006 – March 16, 2006 (per NHTSA)

Defect description

NISSAN IS RECALLING CERTAIN MODEL YEAR 2006 AND MODEL YEAR 2008 FRONTIER, XTERRA AND PATHFINDER VEHICLES. THE MOLDED FUEL TANK SHELLS CAN DEFORM, CAUSING THE FUEL SENDER FLOAT ARM TO CONTACT AN EMBOSSMENT MOLDED INTO THE TANK SHELL CAUSING THE INSTRUMENT PANEL FUEL GAUGE TO SHOW THAT THE VEHICLE HAS APPROXIMATELY ONE QUARTER TANK WHEN THE FUEL TANK IS EMPTY.

Safety consequence

THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL IN TRAFFIC, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL LEVEL SENDING UNIT INSIDE THE FUEL TANK WITH A NEW ONE THAT HAS A MODIFIED FLOAT ARM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

FRONT CRASH ZONE SENSOR HOUSING/ROAD SALT

NHTSA #08V690000 · Air Bags — Frontal · NHTSA notice

Reported December 29, 2008 · NISSAN NORTH AMERICA, INC.

Potentially affected: 242,720 vehicles

Owners notified January 26, 2009 · Vehicles built June 1, 2004 – November 19, 2008 (per NHTSA)

Defect description

NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.

Safety consequence

THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.

Manufacturer remedy

DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

TRAILER BRAKE CONTROL CONNECTION HARNESS

NHTSA #07E046000 · Equipment · NHTSA notice

Reported July 3, 2007 · HOPKINS MANUFACTURING CORP.

Potentially affected: 3,500 vehicles

Owners notified August 17, 2007

Defect description

CERTAIN HOPKINS AFTERMARKET TRAILER BRAKE CONTROL CONNECTION HARNESSES SOLD FOR USE ON CERTAIN MODELS OF NISSAN VEHICLES WHICH ARE LISTED ABOVE. THE INTERNAL PART NUMBERS WITHIN HOPKINS ARE: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, AND 1290376035. A WIRE MAY HAVE BEEN PLACED IN AN INCORRECT POSITION IN THE ELECTRICAL CONNECTOR HOUSING. THIS RESULTS IN AN INCORRECT ROUTING OF WIRES BETWEEN THE TRAILER BRAKE CONTROLLER AND THE TOWING VEHICLE WIRING SYSTEM.

Safety consequence

THIS HARNESS WOULD RESULT IN POWER FROM THE TRAILER BRAKE CONTROLLER GOING TO THE TOWING VEHICLE DASH LIGHT CIRCUIT RATHER THAN THE TRAILER BRAKES. THIS RESULT WOULD BE THE LACK OF TRAILER BRAKING WHEN THE TOWING VEHICLE BRAKES WERE APPLIED. IT WOULD ALSO RESULT IN THE TOWING VEHICLES DASH LIGHTS BEING ACTIVATED WHEN THE VEHICLE BRAKES WERE APPLIED. THE FAILURE OF THE APPLICATION OF THE TRAILER BRAKE COULD RESULT IN REDUCED ABILITY TO STOP AND CONTRIBUTE TO A POSSIBLE CRASH.

Manufacturer remedy

HOPKINS WILL NOTIFY OWNERS AND REPLACE THE ORIGINAL HARNESS WITH A REVISED HARNESS FREE OF CHARGE. THE RECALL BEGAN AUGUST 17, 2007. OWNERS CAN CONTACT HOPKINS AT 800-835-0129.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET HARNESSES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY NISSAN.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLECTORS

NHTSA #06E064000 · Exterior Lighting · NHTSA notice

Reported July 17, 2006 · TRADESONIC

Potentially affected: 4,029 vehicles

Defect description

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Notes

THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL CAP TETHER PIN

NHTSA #06V092000 · Fuel System, Gasoline — Storage — Tank Assembly — Filler Pipe and Cap · NHTSA notice

Reported March 30, 2006 · NISSAN NORTH AMERICA, INC.

Potentially affected: 42,000 vehicles

Nissan campaign R0603 · Owners notified April 24, 2006 · Vehicles built July 28, 2004 – February 23, 2006 (per NHTSA)

Defect description

ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.

Safety consequence

THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

NISSAN RECALL NO. R0603.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Nissan Frontier 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

2 investigations

2006 Nissan Frontier Extended Cab

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 3

Side Crash

Not Rated

Driver: 5, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

2 investigations

617 owner complaints have been filed with NHTSA for the 2006 Nissan Frontier.

Electrical System; Air Bags

ODI #11764830

Incident: September 16, 2026 · Filed: September 16, 2026

I have two recalls, I´m living in [XXX] and I drive this vehicle here. I don´t know where they can solve this problems. NHTSA Recall Number23E-012 NHTSA Recall Number10V-517 I have set a letter in the Upload Files section INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine and Engine Cooling; Fuel System, Gasoline; Air Bags

ODI #11728571

Incident: February 27, 2026 · Filed: April 1, 2026

See attached document for complaint.

Fuel/Propulsion System

ODI #11728559

Incident: March 10, 2026 · Filed: April 1, 2026

Whenever I fill ip the tank I get a fuel smell inside the vehicle. I do not overfill the tank and always stop filling when the fuel pump stops the first time. I have not been able to identify a leak and have not seen fuel leaking under the vehicle. The smell is strong for about the first 1/4 tank of use.

Electrical System

ODI #11720086

Incident: February 19, 2026 · Filed: February 24, 2026

The truck has been stalling while driving or won't start. The ECM relay was recalled and was taken care of Thursday, February 19. However, the truck still stalls while driving and won't start at times. I've asked Nissan to look at the IPDM to see if there was any consequential damage, but they won't without paying a fee for a diagnostic test. This is a major safety issue that needs to be fixed. The recall was from 2010, but we have only owned the vehicle since 2024 and had no idea about the recall.

Engine and Engine Cooling; Engine

ODI #11571478

Incident: January 22, 2024 · Filed: February 12, 2024

The contact owns a 2006 Nissan Frontier. The contact stated that the vehicle was leaking oil. The contact stated that the check engine warning light was illuminated. The contact drove the vehicle to a local dealer who diagnosed that the valve cover gasket needed to be replaced. Additionally, the spark plugs needed to be replaced. The dealer later called the contact and informed the contact that the bank #1 and #2 cam sensors and the coil packs needed to be replaced. The contact stated that the dealer later called back and stated that the vehicle was making an abnormal sound and upon performing a diagnostic test, the dealer advised that the timing chain needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was informed of the failure. The failure mileage was approximately 110,000.

Electrical System; Engine

ODI #11568324

Incident: December 15, 2023 · Filed: January 28, 2024

Truck will turn on once in awhile and I was told it is the ipdm module and that there's a recall on the part. What can I do to get the part sent to me since there is a recall and the mechanic told me that with a recall I can get the part sent to me at no cost to me

Electrical System

ODI #11568323

Incident: December 15, 2023 · Filed: January 28, 2024

The truck will start once in awhile has been taken to the shop and they said they ipdm module is the problem and that there's a recall on that part.

Air Bags

ODI #11552103

Incident: October 26, 2023 · Filed: October 26, 2023

The contact owns a 2006 Nissan Frontier. The contact received notification of NHTSA Campaign Number: 23E012000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Air Bags

ODI #11547382

Incident: September 29, 2023 · Filed: September 29, 2023

The contact owns a 2006 Nissan Frontier. The contact received notification of NHTSA Campaign Number: 23E012000 (Air Bags) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Equipment

ODI #11521370

Incident: May 10, 2023 · Filed: May 10, 2023

The contact owns a 2006 Nissan Frontier equipped with an aftermarket Angel View rearview mirror from Bulbhead.com, P/N: L22-1722. The contact stated that after entering the vehicle and closing the front driver’s side door, the glass mirror detached from the mirror housing and fell to the floor of the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure.

Other Nissan Frontier model years

Check your 2006 Nissan Frontier VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Nissan Frontier at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Nissan VIN