NHTSA vehicle safety data

2005 Nissan Armada Recalls & Complaints

The 2005 Nissan Armada has 5 NHTSA recall campaigns and 373 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Nissan dealer.

NHTSA recall and complaint data for the 2005 Nissan Armada. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Nissan Armada owner complaints

Owners have filed 373 complaints with NHTSA about the 2005 Nissan Armada, describing incidents dated November 5, 2004 to August 13, 2024.

Most-cited components

Service Brakes 218 complaints
Fuel/Propulsion System 77 complaints
Engine 40 complaints
Air Bags 34 complaints
Electrical System 24 complaints
Power Train 16 complaints

Of the 373 complaints on file, 8 report a crash and 5 a fire; across all 373 complaints, owners report 7 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11608204 · Filed August 13, 2024
Unknown the light for air bags is on
ODI #11580356 · Filed April 1, 2024
For several years now since I received this car from a family member gas gauge has been not working I contacted Nissan they said my year or VIN number was it affected but that's not accurate because it is so what can I do
ODI #11575580 · Filed March 5, 2024
My breaking system has a malfunction that comes on and off. Sometimes the brakes automatically stop working and start grinding as if I have no brakes, but when I brought it to be looked at they couldn't find the problem. I notice that when you turn the car off and turn it back on the problems of…

Read all 373 complaints

Owner-reported

2005 Nissan Armada mileage at failure

333 of the 373 complaints on file for the 2005 Nissan Armada give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Service Brakes	Median 70,000 miles	Middle half 35,000–110,000 miles	Based on 198 complaints
Fuel/Propulsion System	Median 115,000 miles	Middle half 95,000–140,000 miles	Based on 68 complaints
Engine	Median 90,000 miles	Middle half 70,000–105,000 miles	Based on 34 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Nissan Armada in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE08-037: ENGINE COMPARTMENT FIRE
Closed August 25, 2008
- Recall 08V-284
Preliminary Evaluation PE08-004: SIDE AIR BAG NON-DEPLOYMENT
Closed May 30, 2008

Open and recently closed NHTSA defect investigations

ENGINE CONTROL MODULE

NHTSA #10V517000 · Engine and Engine Cooling · NHTSA notice

Reported October 28, 2010 · NISSAN NORTH AMERICA, INC.

Potentially affected: 747,480 vehicles

Owners notified December 6, 2010 · Vehicles built February 5, 2004 – May 15, 2006 (per NHTSA)

Defect description

NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.

Safety consequence

THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOWER LINK REPLACEMENT PARTS

NHTSA #10E019000 · Suspension — Front — Control Arm — Lower Arm · NHTSA notice

Reported May 20, 2010 · NISSAN NORTH AMERICA, INC.

Potentially affected: 1,873 vehicles

Owners notified July 12, 2010

Defect description

NISSAN IS RECALLING CERTAIN FRONT AND REAR LOWER LINKS, P/NOS. 54501ZQ00A, 54500ZQ00A, 551A1ZQ00A, 551A0ZQ00A , 54501EA00A, 54500EA00A, 551A1EA500, 551A0EA500, 54501ZR00A, AND 54500ZR00A, SOLD BETWEEN NOVEMBER 25, 2009 AND MAY 14, 2010 AS REPLACEMENT PARTS FOR MODEL YEAR 2004 THROUGH 2010 TITAN, ARMADA, AND QX56, AND MODEL YEARS 2005 THROUGH 2010 FRONTIER, XTERRA, AND PATHFINDER VEHICLES. THE LOWER CONTROL LINK ASSEMBLY HAS TWO CYLINDRICAL COLLARS FORMING THE INBOARD ATTACHMENT POINTS TO THE CHASSIS. DUE TO AN IMPROPER WELDING PROCESS SOME COLLARS MAY CONTAIN WELDS THAT DO NOT MEET STRENGTH SPECIFICATIONS.

Safety consequence

IF THE COLLAR WELD SEPARATES, THE VEHICLE HANDLING WILL DETERIORATE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

NISSAN WILL NOTIFY OWNERS AND DEALERS WILL REPLACE ANY AFFECTED LOWER LINK FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 12, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

INSTRUMENT PANEL FUEL GAUGE

NHTSA #10V074000 · Fuel System, Other — Storage — Fuel Gauge System · NHTSA notice

Reported March 3, 2010 · NISSAN NORTH AMERICA, INC.

Potentially affected: 340,000 vehicles

Owners notified March 22, 2010

Defect description

NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.

Safety consequence

THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

AIR CONDITIONING CONDENSER FAN/VISTEON

NHTSA #08V284000 · Equipment — Appliance — Air Conditioner · NHTSA notice

Reported June 27, 2008 · NISSAN NORTH AMERICA, INC.

Potentially affected: 180,664 vehicles

Owners notified August 2, 2008 · Vehicles built March 17, 2005 – August 21, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.

Safety consequence

THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.

Manufacturer remedy

DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

TRAILER BRAKE CONTROL CONNECTION HARNESS

NHTSA #07E046000 · Equipment · NHTSA notice

Reported July 3, 2007 · HOPKINS MANUFACTURING CORP.

Potentially affected: 3,500 vehicles

Owners notified August 17, 2007

Defect description

CERTAIN HOPKINS AFTERMARKET TRAILER BRAKE CONTROL CONNECTION HARNESSES SOLD FOR USE ON CERTAIN MODELS OF NISSAN VEHICLES WHICH ARE LISTED ABOVE. THE INTERNAL PART NUMBERS WITHIN HOPKINS ARE: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, AND 1290376035. A WIRE MAY HAVE BEEN PLACED IN AN INCORRECT POSITION IN THE ELECTRICAL CONNECTOR HOUSING. THIS RESULTS IN AN INCORRECT ROUTING OF WIRES BETWEEN THE TRAILER BRAKE CONTROLLER AND THE TOWING VEHICLE WIRING SYSTEM.

Safety consequence

THIS HARNESS WOULD RESULT IN POWER FROM THE TRAILER BRAKE CONTROLLER GOING TO THE TOWING VEHICLE DASH LIGHT CIRCUIT RATHER THAN THE TRAILER BRAKES. THIS RESULT WOULD BE THE LACK OF TRAILER BRAKING WHEN THE TOWING VEHICLE BRAKES WERE APPLIED. IT WOULD ALSO RESULT IN THE TOWING VEHICLES DASH LIGHTS BEING ACTIVATED WHEN THE VEHICLE BRAKES WERE APPLIED. THE FAILURE OF THE APPLICATION OF THE TRAILER BRAKE COULD RESULT IN REDUCED ABILITY TO STOP AND CONTRIBUTE TO A POSSIBLE CRASH.

Manufacturer remedy

HOPKINS WILL NOTIFY OWNERS AND REPLACE THE ORIGINAL HARNESS WITH A REVISED HARNESS FREE OF CHARGE. THE RECALL BEGAN AUGUST 17, 2007. OWNERS CAN CONTACT HOPKINS AT 800-835-0129.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET HARNESSES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY NISSAN.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2005 Nissan Armada 4-DR

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

Electronic Stability Control

2 investigations

373 owner complaints have been filed with NHTSA for the 2005 Nissan Armada.

Air Bags

ODI #11608204

Incident: August 13, 2024 · Filed: August 13, 2024

Unknown the light for air bags is on

Fuel/Propulsion System

ODI #11580356

Incident: March 1, 2019 · Filed: April 1, 2024

For several years now since I received this car from a family member gas gauge has been not working I contacted Nissan they said my year or VIN number was it affected but that's not accurate because it is so what can I do

Seat Belts; Service Brakes

ODI #11575580

Incident: March 9, 2022 · Filed: March 5, 2024

My breaking system has a malfunction that comes on and off. Sometimes the brakes automatically stop working and start grinding as if I have no brakes, but when I brought it to be looked at they couldn't find the problem. I notice that when you turn the car off and turn it back on the problems of sides for a little while will eventually come back later. For someone to detect it, they cannot shut the car off at the time that is presenting itself.

Steering; Wheels; Visibility/Wiper

ODI #11489899

Incident: August 10, 2021 · Filed: October 19, 2022

I got this vehicle from a buy here pay here with 355,xxx miles the motor runs and drives great but when I went to go down the interstate after a month having the vehicle it was shaking really bad so I called auto parts and autozone and even took it to a mechanic they all told me alignment and if that doesn't work them put new rotors and breaks and we'll it's still there and if you go 35 you can hear something rubbing and when you hit 60 it starts shaking really bad and the steering wheel is very hard to hold when this happens so still don't know what it is!

Electrical System; Engine; Forward Collision Avoidance

ODI #11488456

Fire

Incident: May 5, 2021 · Filed: October 8, 2022

Engine brake transmission speed failure

Electrical System; Service Brakes; Engine

ODI #11488455

Fire

Incident: August 1, 2022 · Filed: October 8, 2022

The brakes light comes on frequently and brakes stop working properly when going over a bump in the road decrease speed then engine fails. Has to be turned off then on to start engine.

Service Brakes

ODI #11476159

Incident: July 27, 2022 · Filed: July 27, 2022

I have a 2005 Nissan Armada that has a known problem with its brakes. It has a faulty Delta Brake Sensor and Brake Booster. What happens is that the brake light comeson, the vehicle losses its braking ability and sounds like metal scraping when you apply the brakes. The issue will reset if you turn off the car. Nissan knows about this issue but has failed to send 2004-2006 Armada owners of information on how to get this fixed at a local dealer. Here is a link to the class action settlement: https://topclassactions.com/lawsuit-settlements/closed-settlements/nissan-brake-defect-class-action-settlement/ My complaint is this, there were 350,000 affected vehicles and mine was one of them. I was never notified by Nissan of this faulty part and did not know that Nissan would reimburse me for the repair. The settlement date is now closed but the problem still exists in many Nissan affected vehicles. I called Nissan USA and they said Nissan could do nothing for me. I called my local Nissan dealer and described the problem and they said they could do nothing for me but that I could pay out of pocket to have the brake booster replaced at qa cost of $1500f or parts and labor. The error code associated with this problem is C1179. This issue is a safety issue and it affects the vehicles ability to stop. If you do not see the brake warning light on you do not know that the issue is happening. This could result in a dangerous situation at highway speeds. I would like the NHTSA to get involved and to demand that Nissan repair this known problem free of charge. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Fuel System, Other

ODI #11462458

Incident: March 1, 2022 · Filed: April 27, 2022

The contact owns a 2005 Nissan Armada. The contact stated that the fuel gauge inaccurately displayed the fuel level in the tank while the fuel tank was empty; causing the vehicle to stall. The contact refueled the vehicle and was able to restart the vehicle. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact that there was no recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 10V074000 (Fuel System, Other) however, the VIN was not included in the recall. The failure mileage was approximately 192,000.

Steering; Air Bags

ODI #11429428

Crash 2 injuries

Incident: August 7, 2021 · Filed: August 17, 2021

The contact owned a 2005 Nissan Armada. The contact stated that while driving at 45 MPH, his steering wheel was locked without warning. Due to the failure, the contact veered off the road and hit two parked vehicles. The air bags did not deploy upon impact. The contact stated that a little girl was standing near one of the parked vehicles and was knocked into a tree and was airlifted to a child trauma center. The contact stated that from his knowledge, the girl was only treated for cuts and bruises. The contact stated that he was knocked out for a few minutes after impact but refused medical attention at the scene. He later went to the hospital and was treated for a concussion and whiplash. The contact stated that he believed that a police report was filed but was not certain. The vehicle was towed from the scene to an independent tow yard where it was deemed a total loss. The dealer nor the manufacturer have been notified of the failure. The vehicle had been destroyed. The failure mileage was approximately 215,000.

Fuel System, Other

ODI #11423279

Incident: June 7, 2021 · Filed: July 2, 2021

The contact owns a 2005 Nissan Armada. The contact stated that the fuel gauge was incorrectly reporting the amount of fuel in the vehicle. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 10V074000 (Fuel System, Other) however, the Vin was not included. The manufacturer was informed of the failure and confirmed that the Vin was not included in the recall. The failure mileage was approximately 172,000.

Other Nissan Armada model years

Check your 2005 Nissan Armada VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Nissan Armada at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Nissan VIN