NHTSA vehicle safety data
1999 Navistar 5000 Recalls & Complaints
The 1999 Navistar 5000 has 4 NHTSA recall campaigns on file as of October 21, 2026. try.vin has no NHTSA owner complaints on file for the 1999 Navistar 5000. Recall repairs are usually free at an authorized Navistar dealer.
NHTSA recall and complaint data for the 1999 Navistar 5000. Recall data is refreshed daily from NHTSA.
INTERNATIONAL/ABS TRACTION VALVE
NHTSA #00V022000 · Service Brakes, Hydraulic — Antilock/Traction Control/Electronic Limited Slip · NHTSA notice
Reported January 24, 2000 · INTERNATIONAL TRUCK AND ENGINE
Potentially affected: 829 vehicles
Manufacturer campaign 00501 · Owners notified January 31, 2000 · Vehicles built March 29, 1999 – May 31, 1999 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE ANTILOCK TRACTION RELAY VALVES WERE INCORRECTLY ASSEMBLED BY THE SUPPLIER. AN EXTRA CHECK VALVE WAS INSTALLED WHICH WILL NOT ALLOW THE TRACTION CONTROL SYSTEM TO FUNCTION PROPERLY.
Safety consequence
THE REAR BRAKES CAN BE APPLIED AUTOMATICALLY DURING A TRACTION EVENT AND NOT RELEASE UNTIL THE AIR SYSTEM PRESSURE IS DEPLETED.
Manufacturer remedy
DEALERS WILL INSPECT THESE VEHICLES AND ALL ANTILOCK TRACTION RELAY VALVES FOUND DEFECTIVE WILL BE REPLACED.
Notes
INTERNATIONAL RECALL NO. 00501.OWNER NOTIFICATION BEGAN JANUARY 31, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NAVISTAR/WINDSHIELD WIPER ASSEMBLY
NHTSA #99V102000 · Visibility — Windshield Wiper/Washer — Linkages · NHTSA notice
Reported May 4, 1999 · INTERNATIONAL TRUCK AND ENGINE
Potentially affected: 4,553 vehicles
Owners notified May 18, 1999 · Vehicles built October 26, 1998 – December 15, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH DANA/SPRAGUE WINDSHIELD WIPER ASSEMBLIES. THE KNURLED PIVOT SHAFT (WHICH OPERATES THE WINDSHIELD WIPER ARM) IS WELDED TO A LEVER, WHICH CONNECTS TO LINKAGE FROM THE WIPER MOTOR. THE WELD AT THE PIVOT SHAFT TO LEVER CAN FAIL.
Safety consequence
SHOULD A FAILURE OCCUR DURING INCLEMENT WEATHER ON THE DRIVER'S SIDE WHILE THE VEHICLE IS IN MOTION, THE OPERATOR'S VISION WOULD BE PARTIALLY OBSCURED.
Manufacturer remedy
DEALERS WILL INSPECT THE WIPER SYSTEM, CONDUCTING A "STALL" TEST TO VALIDATE THE INTEGRITY OF THE WELD. ALL WIPER ASSEMBLIES FAILING THIS TEST WILL BE REPLACED.
Notes
OWNER NOTIFICATION BEGAN MAY 18, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NAVISTAR AT 1-800-448-7825.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NAVISTAR/AIR BRAKES
NHTSA #99V055001 · Service Brakes, Air · NHTSA notice
Reported March 16, 1999 · INTERNATIONAL TRUCK AND ENGINE
Potentially affected: 1,547 vehicles
Manufacturer campaign 99504 · Owners notified March 22, 1999 · Vehicles built January 11, 1999 – January 20, 1999 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, TRANSIT AND SCHOOL BUSES, EQUIPPED WITH MERITOR AIR BRAKE AUTOMATIC SLACK ADJUSTERS. SOME OF THE AUTOMATIC SLACK ADJUSTERS HAD INSUFFICIENT TORQUE APPLIED TO THE GUIDE PAWL CAP SCREW.
Safety consequence
WITHOUT SUFFICIENT TORQUE ON THE GUIDE PAWL CAP SCREW, THE BRAKES COULD GRADUALLY LOSE ADJUSTMENT, INCREASING THE VEHICLE STOPPING DISTANCE.
Manufacturer remedy
DEALERS WILL CHECK THE TORQUE ON THE AUTOMATIC SLACK ADJUSTER GUIDE PAWL. IF THERE IS NO TORQUE, THE BRAKES WILL BE ADJUSTED AND THE GUIDE PAWL WILL BE TIGHTENED TO 15-20 FT. LBS.
Notes
OWNER NOTIFICATION BEGAN MARCH 22, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NAVISTAR AT 1-800-448-7825. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
NAVISTAR/INNER WHEEL CONE
NHTSA #99V014002 · Suspension — Front — Wheel Bearing · NHTSA notice
Reported March 15, 1999 · INTERNATIONAL TRUCK AND ENGINE
Potentially affected: 4,024 vehicles
Manufacturer campaign 99503 · Owners notified March 29, 1999 · Vehicles built March 1, 1998 – October 16, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCK CHASSIS EQUIPPED WITH 16,000 LB., 18,000 LB., OR 20,000 LB. HEAVY DUTY STEERING AXLES. THE INNER WHEEL BEARING CONE FOR THE STEERING AXLE WHEEL HUB ASSEMBLY DOES NOT PROPERLY FIT ONTO THE NAVISTAR STEERING AXLE SPINDLE ASSEMBLY. IMPROPER FIT OF THE BEARING TO THE SPINDLE INCREASES THE STRESS LEVELS TO THE STEERING AXLE SPINDLE WHICH COULD CAUSE SPINDLE FAILURE.
Safety consequence
IF THE SPINDLE FAILS, A LOSS OF DRIVER CONTROL COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Manufacturer remedy
DEALERS WILL REMOVE THE LEFT AND RIGHT HUB/DRUM ASSEMBLIES FROM THE STEERING AXLES AND REPLACE THE INNER WHEEL BEARING CONES AND CUPS.
Notes
OWNER NOTIFICATION BEGAN MARCH 29, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NAAVISTAR AT 1-800-448-7825.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Other Navistar 5000 model years
Check your 1999 Navistar 5000 VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Navistar 5000 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Navistar VIN