2024 Mitsubishi Outlander Recalls, Ratings & Complaints

Incident: November 1, 2025 · Filed: August 10, 2026

The contact owns a 2024 Mitsubishi Outlander. The contact stated that while driving approximately 30 MPH, the Forward Collision Avoidance system failed to activate as needed and the vehicle nearly crashed into the rear of another vehicle. The contact stated that during the failure, the vehicle in front struck a pedestrian, and the pedestrian went airborne and landed on the hood of the contact's vehicle. The contact stated that the Forward Collision Avoidance system failed to immediately activate, and the brake pedal was depressed to avoid crashing into the rear of the vehicle ahead. The pedestrian sustained unknown injuries and was transported to the hospital. The contact mentioned that the vehicle was taken to a dealer on several occasions for the seat belts failing to latch and secure the occupants. The dealer mentioned that there might be crumbs preventing the latch however, the contact mentioned that theory was not possible for the driver's seat belt. The failure was present with the seat belts in the second and third row seats. The cause of the failure was not yet determined. A Police report was filed at the scene. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 3,000.

Incident: August 10, 2026 · Filed: August 10, 2026

My 2024 Outlander locked all the doors while the engine was running and the FAST key was inside the vehicle. I exited normally through the driver’s door and did not intentionally lock the vehicle. I want this documented on the repair order and I’d like the keyless-operation system checked, including the interior key antenna and any BCM/keyless-system faults or available software updates. I am available for inspection. Not reproduced except by myself. Vehicle has been inspected by no one. No warning. This is a hazard because a child or pet could have been locked inside. I could be stranded in an unsafe location or in severe weather that would pose a risk to myself. The car could run out of gas by the time I’d figure out how to get back inside.

Incident: June 1, 2025 · Filed: July 31, 2026

The vehicle exhibits an intense, overpowering raw gasoline smell inside the passenger cabin, specifically originating from beneath the rear seat area. When the climate control/AC fan is turned on, raw fuel vapors are siphoned directly out of the dashboard air vents into the faces of the occupants, causing headaches and dizziness.Two independent mechanics have pressure-tested the fuel lines and confirmed there are no liquid fuel leaks, proving this is a structural vapor siphoning defect. Mitsubishi has documented this exact factory defect under TSB TS-25-13-001 (NHTSA ID: MC-11018002-0001), but the local dealership refuses to perform the safety repair without a massive out-of-pocket payment because the vehicle has 87,000 miles. This is an immediate fire and health hazard for anyone inside the vehicle.

Incident: May 18, 2026 · Filed: July 31, 2026

The contact rented a 2024 Mitsubishi Outlander from Drivo Car Rental. The contact stated that while driving at an undisclosed speed, there was an abnormal sound. The contact stated that there was a vibrating sound coming from the hood. The front windshield was fractured on the passenger's side, and the instrument cluster failed to function as intended. The contact stated that the safety features were inoperable, and the vehicle was almost involved in a crash. No warning lights were illuminated. The contact stated that the failure had occurred while traveling with the family. The contact stated that the vehicle was unsafe to drive. The vehicle was returned to Drivo Car Rental. The contact stated that while returning the vehicle to the agency, the contact was informed that the vehicle should not have been rented. In addition, the contact researched and became aware of an unrepaired recall associated with the VIN under NHTSA Campaign Number: 25V369000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000.

Incident: December 1, 2025 · Filed: June 20, 2026

Front driver seat belt does not retract and has caused damage to door. Vehicle is available for inspection. We are worried that the seatbelt will not function properly in an accident since is does not function properly now. No confirmation by dealer, going in next week for service, however, dealer representative did say on phone that Mitsibishi s don't have seat belt problems??? First noticed problem last winter when I noticed the dents in the door frame being caused by non retracting seatbelt.

Incident: June 13, 2026 · Filed: June 15, 2026

I own a 2024 Mitsubishi Outlander that I purchased new on December 21, 2024. Since shortly after purchase, the vehicle has experienced ongoing problems involving the brakes, electrical system, and fuel fumes entering the passenger cabin. The most serious issue is the brake system. I have experienced hard braking, inconsistent brake response, brake warning lights, and at least one incident where the brakes suddenly failed and I had to take emergency action to stop the vehicle. The dealership has attempted multiple repairs, including replacing the brake booster, master cylinder, and other brake components, but the problem continues. The vehicle has also had repeated electrical problems, including warning lights, low-voltage issues, radio malfunctions, and steering wheel controls that stopped working. In addition, fuel fumes continue to enter the cabin while driving and when the vehicle is parked. The dealership has already replaced the fuel vapor canister and fuel filler neck, but the fuel odor persists. On June 13, 2026, I went to the emergency room because of symptoms related to inhaling the fuel vapors. I have reported these issues to both the dealership and Mitsubishi Motors North America on multiple occasions since the problems first began. Despite repeated repair attempts and ongoing communication, the defects remain unresolved. Based on the repeated failures, the number of repair visits, and the amount of time the vehicle has been out of service, I believe this vehicle qualifies as a lemon. The vehicle has been in the repair shop numerous times and has been out of service for approximately 45 days. I am filing this complaint because I am concerned that the brake failures and fuel vapor intrusion could put me, my passengers, and other drivers at risk. I am seeking assistance in resolving this issue as soon as possible to prevent further safety and health risks.

Incident: May 28, 2026 · Filed: June 5, 2026

2024 Mitsubishi Outlander PHEV brake-by-wire failure during a downhill U-turn at 100% battery state of charge. Pedal went completely soft to the floor, unable to stop, causing a crash.

Incident: May 6, 2026 · Filed: June 3, 2026

I took my outlander in on May 6 2026 for routine oil change , tire rotation, basic multi inspection to bruce walters service (same company i bought it from new 15 months ago). Inspection was flawless with green light on tires, brakes, the works. It had approx 24k miles on it. When I left the dealer that day I noticed A LOT of roaring, slight vibration, worse when I cut wheel left. I called them and they could not inspect the car for 28 days , appt they made was june 2nd 2026. This only started when they rotated tires. At my appt yesterday, June 2nd, 2026 they charged me 150 diagnostic and said I need 4 new tires even though my tread was awesome. 25k miles on it by the time of this appt. I've owned it year and half. The tire walls are bad but green light on tread..all 4 tires. The mitsubishi lot said that shouldn't happen and sane companies service dept should have done something. But no, they are wanting me to pay almost 1k for new tires, a 25k mile brand new car should not need tires. Service dept blames brand of tires. They did not check, to my knowledge, suspension or shocks etc. Something caused a new car to do this or faulty tires , all 4 , not just 1 or 2.

Incident: March 31, 2026 · Filed: May 6, 2026

The contact owns a 2024 Mitsubishi Outlander Equipped with Nexen Roadian GTX in size 255/45R20. The contact stated while driving the vehicle at 30 MPH she noted her tire pressure was very low, she pulled into a gas station to fill it with AIR, she drove the vehicle home, and next day the tire was flat again and was filled back up. The vehicle was taken to a independent mechanic where it was diagnosed to have pieces of tires coming off with no actual puncture of the tire. The tires were replaced at owners cost. The manufacturer was not notified of the failure. The failure mileage was 27,000.

Incident: May 1, 2026 · Filed: May 4, 2026

"Mi Outlander 2024 tiene falla de frenos desde 8/1/26. Está en [XXX] Mitsubishi Thornton. El dealer negó garantía. Hoy 8/4/26 llamé a Mitsubishi 3 veces a las 7am, 8am y 8:20am pidiendo español por ser falla de seguridad. Me negaron español y me colgaron 2 veces. La tercera vez me dejaron 15 minutos en espera sin contestar. Pido número de caso, grúa pagada a [XXX] que está más cerca de mi casa, y contacto del Gerente de Zona. Esto es discriminación de idioma en defecto de seguridad." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)