NHTSA vehicle safety data

2002 Mini Cooper Recalls, Ratings & Complaints

The 2002 Mini Cooper has 5 NHTSA recall campaigns and 186 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Mini dealer.

NHTSA recall and complaint data for the 2002 Mini Cooper, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2002 Mini Cooper owner complaints

Owners have filed 186 complaints with NHTSA about the 2002 Mini Cooper, describing incidents dated January 2, 2002 to August 27, 2024.

Most-cited components

Steering 61 complaints
Power Train 43 complaints
Visibility/Wiper 29 complaints
Air Bags 26 complaints
Electrical System 13 complaints
Engine 12 complaints

Of the 186 complaints on file, 4 report a crash and 8 a fire; across all 186 complaints, owners report 8 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11644969 · Filed February 26, 2025
Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't…
ODI #11644968 · Filed February 26, 2025
I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer…
ODI #11625676 · Filed November 16, 2024
Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It…

Read all 186 complaints

Owner-reported

2002 Mini Cooper mileage at failure

157 of the 186 complaints on file for the 2002 Mini Cooper give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Steering	Median 75,000 miles	Middle half 50,000–105,000 miles	Based on 58 complaints
Power Train	Median 60,000 miles	Middle half 45,000–80,000 miles	Based on 37 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2002 Mini Cooper in 5 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA11-005: Loss of power steering assist
Closed January 5, 2016
- Recall 15V-660
Engineering Analysis EA07-011: ENGINE COMPARTMENT FIRE
Closed August 13, 2008
Preliminary Evaluation PE07-022: ENGINE COMPARTMENT FIRE
Closed August 15, 2007
Preliminary Evaluation PE05-053: AIR BAG WARNING LAMP ILLUMINATION
Closed March 1, 2006
Defect Petition DP05-006: AIR BAG WARNING LAMP ILLUMINATION
Closed October 6, 2005

Open and recently closed NHTSA defect investigations

Electro-Hydraulic Power Steering Loss

NHTSA #15V660000 · Steering — Electric Power Assist System · NHTSA notice

Reported October 15, 2015 · BMW of North America, LLC

Potentially affected: 86,018 vehicles

Repair completion: 31.31% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified March 4, 2016 · Vehicles built September 19, 2001 – February 9, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.

Safety consequence

If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.

Manufacturer remedy

MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/HEADLAMPS/MISSING AMBER SIDE REFLECTORS

NHTSA #08E050000 · Exterior Lighting — Headlights · NHTSA notice

Reported August 11, 2008 · K2 MOTOR CORPORATION

Potentially affected: 1,921 vehicles

Owners notified December 17, 2008

Defect description

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Safety consequence

WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

TIRE INFORMATION LABEL/FMVSS 110

NHTSA #05V470000 · Equipment — Other — Labels · NHTSA notice

Reported October 12, 2005 · BMW OF NORTH AMERICA, LLC

Potentially affected: 960 vehicles

Owners notified November 30, 2005 · Vehicles built June 6, 2002 – July 12, 2002 (per NHTSA)

Defect description

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE STANDARD REQUIRES THAT THE RELATIONSHIP BETWEEN THE TIRE SIZE AND MAXIMUM TIRE PRESSURE BE INDICATED ON THE VEHICLE'S TIRE INFORMATION LABEL. THIS RELATIONSHIP IS NOT PRESENT.

Safety consequence

TOO LOW OR TOO HIGH TIRE PRESSURE CAN CAUSE PREMATURE WEAR AND/OR TIRE DAMAGE, AND COULD LEAD TO UNFAVORABLE DRIVING CONDITIONS.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH NEW TIRE INFORMATION PLACARDS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT MINI AT 1-866-275-6464.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

BMW/TRANSMISSION SHIFT CABLE

NHTSA #02V201000 · Power Train — Manual Transmission — Floor Shift Assembly · NHTSA notice

Reported July 25, 2002 · BAYERISCHE MOTOREN WERKE

Potentially affected: 3,531 vehicles

Owners notified August 6, 2002 · Vehicles built September 29, 2001 – May 10, 2002 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE TRANSMISSION SHIFT CABLE CONNECTS THE GEARSHIFT LEVER IN THE VEHICLE INTERIOR TO THE SHIFT LINKAGE ON THE TRANSMISSION. IT IS POSSIBLE FOR THE SHIFT CABLE TO DETACH FROM THE TRANSMISSION SHIFT LINKAGE WHILE THE DRIVER IS ATTEMPTING TO CHANGE GEARS. IF THE CABLE DETACHES FROM THE SHIFT LINKAGE, GEAR CHANGES WILL NO LONGER BE POSSIBLE AND THE TRANSMISSION WILL REMAIN IN THE LAST GEAR SELECTED.

Safety consequence

IF SHIFT CABLE DETACHMENT OCCURS AND THE TRANSMISSION REMAINS IN ANY FORWARD GEAR, THE VEHICLE CAN STILL BE DRIVEN IN THAT GEAR ONLY. HOWEVER, IF THE TRANSMISSION MOVES INTO NEUTRAL AND REMAINS THERE, THE ABILITY TO ACCELERATE OR MAINTAIN SPEED WILL BE LOST, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE SHIFT CABLE AND, IF NECESSARY, INSTALL A RETAINING CLIP OVER THE END OF THE SHIFT CABLE TO PREVENT IT FROM DETACHING FROM THE TRANSMISSION. OWNER NOTIFICATION BEGAN AUGUST 6, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-866-ASK-MINI (1-866-275-6464).

Notes

ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2002 MINI Cooper w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 4, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

5 investigations

186 owner complaints have been filed with NHTSA for the 2002 Mini Cooper.

Electrical System; Exterior Lighting

ODI #11644969

Incident: December 20, 2023 · Filed: February 26, 2025

Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.

Electrical System; Air Bags; Seats

ODI #11644968

Incident: December 20, 2023 · Filed: February 26, 2025

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.

Air Bags

ODI #11625676

Incident: August 27, 2024 · Filed: November 16, 2024

Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It was night, I was sitting in middle of my lane, unable to start Mini. Good samaritans helped push it into parking lot while waiting for assistance. After 15 minutes, car started and was driven home. I had slight injuries from being hit by hard material projectiled across cabin. Very thankful I was the only occupant because if a passenger had been in the seat, they would have most definitely sustained injuries. I had to cut the airbags out in order to have clear lines of sight before driving the following day. I’m fearful that the drivers side air bags may do this as well. I have owned this vehicle since 2004. Not aware of history prior to 2004;(accidents, original airbags?). only know it came from a Dealer in CA. (Possibly “Friendship” may be name of town or dealership). I have not had repairs made yet. I don’t drive this vehicle daily. There are no police reports since there was no need. No insurance claims since 2002 model. There were no malfunctions with the warning light prior to incident. However, the following day when I drove, the airbag indicator light came on for passenger side. I did not find a recall but not sure if I would for a 22 year old vehicle.

Unknown or Other

ODI #11400410

Incident: March 11, 2021 · Filed: March 11, 2021

MY MINI COOPER NEEDS RECALL WORK DONE. I AM IN BILLINGS, MT AND 392 MILES FROM THE CLOSEST CERTIFIED PLACE TO GET IT REPAIRED. I CAN'T TRAVEL THAT FAR IN A 2002 VEHICLE WITH HIGH MILES DURING A PANDEMIC. I AM A SENIOR CITIZEN AND HAVE ISSUES THAT DO NOT ALLOW ME TO TRAVEL THAT FAR. I AM STUCK WITH A VEHICLE THAT MAY HAVE A POTENTIAL STEERING ISSUE WITH NO WAY TO RESOLVE IT. I NOW CAN'T SELL THIS VEHICLE EITHER BECAUSE IT WOULD BE MORALLY WRONG TO PASS THIS PROBLEM ON TO A NEW OWNER. I CAN'T AFFORD THIS KIND OF SAFETY AND FINANCIAL PROBLEM. I NEED HELP TO GET THIS WORK DONE AND MINI COOPER CALLED ME AFTER MY INQUIRY AND SAID I AM BASICALLY OUT OF LUCK. THEY HAVE NO RESOLUTION FOR ME OR ANY OTHER MINI COOPER OWNERS THAT LIVE IN RURAL STATES AND ARE NOT NEAR A CERTIFIED DEALERSHIP. I NEED THIS REPAIRED AND AM HOPING YOU CAN HELP ME AND ALL THE OTHER MINI COOPER OWNERS IN THIS DANGEROUS SITUATION. THE NUMBER THE MINI REPRESENTATIVE CALLED ME FROM WAS 800-831-1117.

Steering

ODI #11222671

Incident: June 15, 2019 · Filed: June 26, 2019

SO I BOUGHT A 2002 MINI COOPER LESS THAN A YEAR AGO AND IT CURRENTLY HAS 74K MILES AND ATTEMPTING TO PULL INTO A PARKING SPOT AT THE GROCERY MY STEERING GOES COMPLETELY OUT WHILE I WAS TRYING TO TURN INTO MY SPOT AND RIPPED OFF A BLACK MOLDING THAT GOES OVER THE FRONT PASSENGER WHEEL AND A SIGNIFICANT DING AND SCRATCH.

Steering

ODI #11078341

Incident: January 17, 2018 · Filed: March 9, 2018

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. THE CONTACT, A CERTIFIED MECHANIC, DIAGNOSED THAT THE STEERING PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

Structure

ODI #10956781

Incident: January 1, 2017 · Filed: February 24, 2017

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WATER WAS ENTERING THE VEHICLE FROM THE SUN ROOF, WHICH CAUSED THE COMPUTER IN THE VEHICLE TO GET MOIST AND NOT OPERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF RUBBER CONNECTOR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

Power Train

ODI #10896429

Incident: August 16, 2016 · Filed: August 16, 2016

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING 15 MPH OUT OF A PARKING LOT, THE VEHICLE MADE A LEFT TURN AND THE GEAR SHIFTER FAILED. IN ADDITION, THE GEAR SHIFTER CABLE DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V201000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

Wheels

ODI #10881466

Incident: March 15, 2016 · Filed: June 29, 2016

THE DASH LOW TIRE AIR LIGHT SUDDENLY CAME ON; IT COMES ON AFTER DRIVING FOR ABOUT 5 MINUETS. I'VE CHECKED ALL TIRES AND THEY ARE IN COMPLIANCE. I SEE THAT ON-LINE BLOGS THIS IS A MAJOR ISSUE

Service Brakes

ODI #10881464

Incident: March 15, 2016 · Filed: June 29, 2016

ABS DASH LIGHT AND BREAK LIGHT SUDDENLY CAME ON. IN ADDITION TO THE AIR BAG LIGHT THAT SUDDENLY CAME ON, THE DEALER SAID THE COMPUTER MODULE FOR THE ABS WILL COST $1,000 (IN ADDITION TO THE AIRBAG MODULE OF $1.000). I SEE ON INTERNET BLOGS AND NHTSA THAT THIS IS A COMMON INCIDENT TOTAL AIR BAG AND ABS COST WILL BE $2,000

Other Mini Cooper model years

Check your 2002 Mini Cooper VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Mini Cooper at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Mini VIN