NHTSA vehicle safety data

2005 Mini Cooper S Recalls & Complaints

The 2005 Mini Cooper S has 2 NHTSA recall campaigns and 314 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Mini dealer.

NHTSA recall and complaint data for the 2005 Mini Cooper S. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Mini Cooper S owner complaints

Owners have filed 314 complaints with NHTSA about the 2005 Mini Cooper S, describing incidents dated May 9, 2005 to February 15, 2025.

Most-cited components

Steering 212 complaints
Air Bags 71 complaints
Electrical System 23 complaints
Engine 16 complaints
Power Train 13 complaints
Seats 8 complaints

Of the 314 complaints on file, 6 report a crash and 17 a fire; across all 314 complaints, owners report 3 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11655045 · Filed April 16, 2025
The contact owns a 2005 Mini Cooper S. The contact stated while driving 25 MPH, the steering wheel became difficult to maneuver. The contact stated that the vehicle had lost power steering assist. The vehicle was not diagnosed or repaired. The contact stated that a software update was performed on…
ODI #11458164 · Filed March 24, 2022
The contact owns a 2005 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 15V660000 (Steering) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The…
ODI #11362085 · Filed September 30, 2020
BATTERY LIGHT FLASHING, POWER STEERING CUTTING OUT INTERMITTENTLY WHILE DRIVING. ALTERNATOR AND SERPINTINE BELT REPLACED BUT PROBLEM CONTINUES. ELECTRIC POWER STEERING SEEMS TO BE DRAINING ELECTRICAL SYSTEM.

Read all 314 complaints

Owner-reported

2005 Mini Cooper S mileage at failure

300 of the 314 complaints on file for the 2005 Mini Cooper S give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Steering	Median 70,000 miles	Middle half 55,000–95,000 miles	Based on 204 complaints
Air Bags	Median 60,000 miles	Middle half 40,000–75,000 miles	Based on 64 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Mini Cooper S in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA11-005: Loss of power steering assist
Closed January 5, 2016
- Recall 15V-660
Preliminary Evaluation PE10-038: Loss of Power Steering Assist
Closed May 10, 2011

Open and recently closed NHTSA defect investigations

Electro-Hydraulic Power Steering Loss

NHTSA #15V660000 · Steering — Electric Power Assist System · NHTSA notice

Reported October 15, 2015 · BMW of North America, LLC

Potentially affected: 86,018 vehicles

Repair completion: 31.31% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified March 4, 2016 · Vehicles built July 18, 2001 – February 9, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.

Safety consequence

If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.

Manufacturer remedy

MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Front Passenger Seat Occupant Detection Mat

NHTSA #15V205000 · Air Bags — Frontal · NHTSA notice

Reported April 6, 2015 · BMW of North America, LLC

Potentially affected: 91,800 vehicles

Repair completion: 36.91% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified October 12, 2015 · Vehicles built January 5, 2005 – November 28, 2006 (per NHTSA)

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.

Safety consequence

An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.

Manufacturer remedy

MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

try.vin has no NCAP crash-test rating on file for the 2005 Mini Cooper S. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

314 owner complaints have been filed with NHTSA for the 2005 Mini Cooper S.

Steering

ODI #11655045

Incident: February 15, 2025 · Filed: April 16, 2025

The contact owns a 2005 Mini Cooper S. The contact stated while driving 25 MPH, the steering wheel became difficult to maneuver. The contact stated that the vehicle had lost power steering assist. The vehicle was not diagnosed or repaired. The contact stated that a software update was performed on the back over prevention camera. The manufacturer was notified of the failure but offered no assistance. The contact related the failure to NHTSA Campaign Number: 15V660000 (STEERING); however, the VIN was not included in the recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 175,830.

Steering

ODI #11458164

Incident: March 22, 2022 · Filed: March 24, 2022

The contact owns a 2005 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 15V660000 (Steering) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact also stated that he was advised by the dealer that he had to pay out of pocket for a diagnostic test. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Steering; Electrical System

ODI #11362085

Incident: September 26, 2020 · Filed: September 30, 2020

BATTERY LIGHT FLASHING, POWER STEERING CUTTING OUT INTERMITTENTLY WHILE DRIVING. ALTERNATOR AND SERPINTINE BELT REPLACED BUT PROBLEM CONTINUES. ELECTRIC POWER STEERING SEEMS TO BE DRAINING ELECTRICAL SYSTEM.

Steering; Engine

ODI #11317775

Incident: August 13, 2019 · Filed: March 12, 2020

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE VEHICLE OVERHEATED AND SMOKE BEGAN COMING FROM UNDER THE HOOD OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE WATER PUMP WAS REPLACED. AFTER THE REPAIR, THE POWER STEERING CEASED WITHOUT WARNING UPON STARTING THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) AS POSSIBLE CAUSE OF THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. MINI OF DES MOINES LOCATED AT (9900 HICKMAN RD, DES MOINES, IA 50325) WAS CONTACTED AND CONFIRMED THAT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

Steering

ODI #11243771

Incident: June 10, 2019 · Filed: August 13, 2019

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT EXPERIENCED INTERMITTENT POWER STEERING FAILURE. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, MINI OF MARIN (5880 PARADISE DR, CORTE MADERA, CA 94925, (415) 887-2194) AND THE MANUFACTURER WERE CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

Steering

ODI #11242896

Incident: February 22, 2019 · Filed: August 9, 2019

POWER STEERING NO LONGER WORKS.

Steering

ODI #11230307

Incident: July 4, 2019 · Filed: July 8, 2019

THE CAR WAS IN MOTION WHEN SUDDENLY THE STEERING WHEEL BECAME VERY HARD AND THE DRIVER LOST CONTROL, ALMOST CAUSING AN ACCIDENT. THERE HAS BEEN A RECALL FOR MINI COOPER S VEHICLES (15V-XXX SAFETY RECALL) INVOLVING THE ELECTRIC-HYDRAULIC POWER STEERING SYSTEM. THE RECALL INCLUDES 2002-2005 MODELS, AND EXTENDS THE WARRANTY UP TO 13 YEARS OR UP TO 150,000 MILES. OUR VEHICLE FALLS UNDER THOSE REQUIREMENTS, AND IS A 2005 MODEL AND HAS 69,751 MILES, YET WE WERE TOLD THAT THERE ARE NO EXISTING RECALLS FOR OUR VEHICLE, EVEN THOUGH WE SUSPECT THAT THE INCIDENT WE HAD INVOLVES THE HYDRAULIC STEERING SYSTEM.

Electrical System; Air Bags

ODI #11186059

Incident: March 9, 2019 · Filed: March 12, 2019

WHEN ADJUSTING THE DRIVER AND PASSENGER SEATS, THE AIRBAG LIGHT ILLUMINATED. AFTER RESEARCHING ONLINE, I CONDUCTED TROUBLESHOOTING. I VERIFIED THAT THE WIRING HARNESSES AND CONNECTORS FOR THE AIRBAG SENSORS UNDER BOTH SEATS HAD COME LOOSE, AND CERTAIN WIRES DE-PINNED. THE CAR WAS RUNNING, AND PARKED WHEN THIS OCCURRED.

Steering

ODI #11171823

Incident: January 24, 2019 · Filed: January 24, 2019

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHEN THE VEHICLE WAS STARTED, THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN AND THE SERVICE ENGINE SOON WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE STEERING FAILURE WORSENED SINCE DECEMBER OF 2017. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

Unknown or Other; Fuel/Propulsion System

ODI #11163802

Fire

Incident: December 11, 2018 · Filed: December 28, 2018

DRIVING ON INTERSTATE AND LOST POWER. I PULLED TO SHOULDER AND BLACK SMOKE CAME THRU AIR VENTS. I OPENED THE HOOD AND THERE WAS FIRE. MY CAR COMPLETELY BURNED UP. I NEVER HAD ANY MECHANICAL PROBLEMS. THE TOW TRUCK DRIVER SAID HE BELIEVED THE FIRE STARTED UNDER MY CAR.

Other Mini Cooper S model years

Check your 2005 Mini Cooper S VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Mini Cooper S at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Mini VIN