NHTSA vehicle safety data

2006 Mercury Monterey Recalls, Ratings & Complaints

The 2006 Mercury Monterey has 3 NHTSA recall campaigns and 44 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Mercury dealer.

NHTSA recall and complaint data for the 2006 Mercury Monterey, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Mercury Monterey owner complaints

Owners have filed 44 complaints with NHTSA about the 2006 Mercury Monterey, describing incidents dated June 9, 2007 to October 26, 2020.

Most-cited components

Power Train 34 complaints
Service Brakes 4 complaints
Engine 3 complaints
Vehicle Speed Control 3 complaints
Electrical System 2 complaints
Traction Control System 2 complaints

Together, the 44 complaints on file report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11372494 · Filed November 1, 2020
I WAS DRIVING DOWN THE ROAD AT APPROX. 30-35 MPH, WHEN ALL OF A SUDDEN A HIGH PITCHED SQUEALING SOUND, OCCURED AND MY VEHICLE WOULD NOT ACCELERATE FORWARD ANYMORE. I COASTED INTO A PARKING LOT, PUT THE VEHICLE IN PARK, AND THEN SHIFTED THE CAR INTO R,D, AND OD AND NOTHING ENGAGED... THIS HAPPENED ON…
ODI #11321674 · Filed April 20, 2020
MY 2006 MERCURY MMONTEREY STARTED JUMPING WHILE GOING DOWN THE ROAD AND MAKING A NOISE WHEN YOU PRESS THE GAS. MECHANIC SAID IT WAS THE TCC SELENOID SO WE REPLACED IT AN THAT DID NOT FIX THE ISSUE SO TOOK IT BACKTO FIND THE TORQUE CONVETER IS BAD.
ODI #11283100 · Filed December 1, 2019
MY FAMILY WAS TRAVELING ON THE I-65 SOUTH INTERSTATE AND THE VAN, 2006 MERCURY MONTEREY, STOP RESPONDING IN THE MIDDLE OF FAST TRAFFIC. IT TOOK ME BY TOTAL SURPRISE. THE ENGINE WAS STILL RUNNING. SO, I INITIALLY THOUGHT IT HAD ACCIDENTLY WENT IN NEUTRAL BUT THAT WASN'T THE CASE. I TRIED A LOWER GEAR…

Read all 44 complaints

Owner-reported

2006 Mercury Monterey mileage at failure

43 of the 44 complaints on file for the 2006 Mercury Monterey give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Power Train	Median 85,000 miles	Middle half 70,000–115,000 miles	Based on 34 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Mercury Monterey in 3 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA12-003: Corrosion of Third-Row Seat Attachment
Closed May 2, 2013
- Recall 13V-081
Equipment Query EQ12-010: Stabilus Rear Liftgate Struts Failing
Closed December 31, 2012
Preliminary Evaluation PE10-033: Engine Stalling
Closed July 15, 2011

Open and recently closed NHTSA defect investigations

Corrosion of Third Row Seat Attachment

NHTSA #13V081000 · Seats · NHTSA notice

Reported March 7, 2013 · Ford Motor Company

Potentially affected: 196,667 vehicles

Manufacturer campaign 13S01 · Owners notified March 28, 2013 · Vehicles built March 24, 2003 – November 7, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Ford is recalling certain model year 2004-2007 Freestar and Mercury Monterey vehicles manufactured from March 24, 2003, through November 7, 2006, equipped with a third row seat and originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. The third row stowable seat can experience corrosion and structural degradation at the seat anchor mechanism mounted to the rear wheel wells. As a result of the corrosion, the third row seat may not fully latch into its seating position.

Safety consequence

In the event that the vehicle is crashed into from the rear, an unlatched seat may increase the risk of personal injury.

Manufacturer remedy

Ford will notify owners, and dealers will install new third row seat latch striker mounting brackets, free of charge. The recall began on March 28, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.

Notes

Ford's recall campaign number is 13S01.Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FUEL LEAK/FIRE

NHTSA #06E056000 · Fuel System, Gasoline · NHTSA notice

Reported June 13, 2006 · UFI FILTERS USA

Potentially affected: 58,640 vehicles

Owners notified August 4, 2006

Defect description

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Safety consequence

FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Notes

THIS RECALL ONLY PERTAINS TO UFI FILTERS USA (PUROLATOR) AFTERMARKET FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

POWER LIFTGATES

NHTSA #06V069000 · Structure — Body — Hatchback/Liftgate · NHTSA notice

Reported March 9, 2006 · FORD MOTOR COMPANY

Potentially affected: 12,728 vehicles

Manufacturer campaign 06S42 · Owners notified March 15, 2006 · Vehicles built April 13, 2004 – December 13, 2005 (per NHTSA)

Defect description

ON CERTAIN VANS EQUIPPED WITH THE POWER LIFTGATE OPTION, THE POWER LIFTGATE MOTOR AUTOMATICALLY DISENGAGES AFTER THE LIFTGATE IS POWERED OPEN.

Safety consequence

IN THE EVENT OF A LIFTGATE STRUT MALFUNCTION, THE LIFTGATE CAN FALL FREELY WITH NO PRIOR WARNING. ANYONE STANDING BENEATH THE LIFTGATE MAY BE INJURED IF THE LIFTGATE FALLS.

Manufacturer remedy

DEALERS WILL REPROGRAM THE POWER LIFTGATE MODULE TO REDUCE THE LIKELIHOOD THAT THE LIFTGATE COULD FALL FREE OF CHARGE. THE RECALL BEGAN ON MARCH 15, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Notes

FORD RECALL NO. 06S42.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Mercury Monterey

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 4, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

3 investigations

44 owner complaints have been filed with NHTSA for the 2006 Mercury Monterey.

Power Train

ODI #11372494

Incident: October 26, 2020 · Filed: November 1, 2020

I WAS DRIVING DOWN THE ROAD AT APPROX. 30-35 MPH, WHEN ALL OF A SUDDEN A HIGH PITCHED SQUEALING SOUND, OCCURED AND MY VEHICLE WOULD NOT ACCELERATE FORWARD ANYMORE. I COASTED INTO A PARKING LOT, PUT THE VEHICLE IN PARK, AND THEN SHIFTED THE CAR INTO R,D, AND OD AND NOTHING ENGAGED... THIS HAPPENED ON A CITY STREET...HAD IT TOWED TO REPAIR SHOP AND WAS TOLD IT WAS SOMETHING WITH MY TRANSMISSION, BUT THEY DIDNT SAY WHAT, ONLY THAT IS WAS GOING TO COST $2250 TO REPLACE IT.....HAD IT TOWED HOME..NOT REPAIRED

Power Train

ODI #11321674

Incident: February 29, 2020 · Filed: April 20, 2020

MY 2006 MERCURY MMONTEREY STARTED JUMPING WHILE GOING DOWN THE ROAD AND MAKING A NOISE WHEN YOU PRESS THE GAS. MECHANIC SAID IT WAS THE TCC SELENOID SO WE REPLACED IT AN THAT DID NOT FIX THE ISSUE SO TOOK IT BACKTO FIND THE TORQUE CONVETER IS BAD.

Power Train

ODI #11283100

Incident: November 29, 2019 · Filed: December 1, 2019

MY FAMILY WAS TRAVELING ON THE I-65 SOUTH INTERSTATE AND THE VAN, 2006 MERCURY MONTEREY, STOP RESPONDING IN THE MIDDLE OF FAST TRAFFIC. IT TOOK ME BY TOTAL SURPRISE. THE ENGINE WAS STILL RUNNING. SO, I INITIALLY THOUGHT IT HAD ACCIDENTLY WENT IN NEUTRAL BUT THAT WASN'T THE CASE. I TRIED A LOWER GEAR WITH NOT LUCK. NOT WANTING TO BE STUCK IN THE MIDDLE OF THE INTERSTATE I THEN TURNED ON MY HAZARD LIGHTS AND FRANTICALLY MANEUVERED THE VAN TO THE SIDE OF THE BUSY INTERSTATE ROAD. ONCE ON THE SIDE OF THE ROAD MY HUSBAND TRIED EVERY GEAR AND THE VAN WASN'T RESPONDING IN ANY OF THEM. WE ENDED UP GETTING IT TOWED TO OUR HOUSE. AFTER WE GOT HOME MY HUSBAND STARTED RESEARCHING THE PROBLEM BECAUSE HE HAD NEVER HEARD OF A VEHICLE STOP RESPONDING LIKE THAT WITHOUT ANY WARNING SIGNS. HE SAID THIS HAS TO BE VEHICLE DEFECT AND LOOKED UP RECALLS FOR THE VAN ON THE NHTSA.ORG WEBSITE. THERE WASN'T A RECALL FOR THIS ISSUE BUT THERE WERE PLENTY OF COMPLAINTS ABOUT THIS EXACT SAFETY ISSUE. AFTER DOING MORE RESEARCH WE FOUND THAT THE 2004 MODEL OF THIS VAN HAD THE SAME ISSUE WHICH FORD DID DO A RECALL FOR THE TORQUE CONVERTER. THE FORD COMPANY NEEDS TO BE IMMEDIATELY NOTIFIED THAT THIS IS ALSO A BIG SAFETY ISSUE WITH THE 2006 MODEL. ONE THE REASONS MY HUSBAND BOUGHT THE VEHICLE WAS BECAUSE IT WAS BUILT BY FORD AND HE TRUSTED THEIR PRODUCTS. I HOPE FORD WILL TAKE THE COMPLAINT SERIOUSLY AND STAND BEHIND THEIR PRODUCT AND GET THIS SAFETY ISSUE WITH THE TORQUE CONVERTER ON THE MERCURY MONTEREY 2006 VEHICLES RESOLVED QUICKLY.

Power Train

ODI #11220581

Incident: June 7, 2019 · Filed: June 17, 2019

TL* THE CONTACT OWNS A 2006 MERCURY MONTEREY. WHILE DRIVING 70 MPH, THE VEHICLE FAILED TO RESPOND AS THE ACCELERATOR PEDAL WAS BEING DEPRESSED. ALSO, THE RPMS INCREASED TO HIGH. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TORQUE CONVERTER WAS STRIPPED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 141,000.

Power Train

ODI #11218671

Incident: June 6, 2019 · Filed: June 8, 2019

OUR VAN WAS DRIVING JUST FINE AND SUDDENLY, WITH NO WARNING AT ALL, WENT INTO NEUTRAL, STOPPING IN AN INTERSECTION. THE VEHICLE ONLY HAS AROUND 88000 MILES ON IT. IT WAS TOWED TO THE DEALER, AND THE LINCOLN DEALER DIAGNOSED THAT THE TORQUE CONVERTER HAD FAILED. I NOTICED FORD HAD ALREADY RECALLED ALL OF THE 2004 FREESTARS AND 2005 MONTEREYS FOR THIS PROBLEM, BUT YET SOMEHOW MY 2006 WITH A SEPTEMBER 2005 BUILD DATE WAS NOT PART OF THE RECALL. SO GUESS WHAT? FORD KNOWINGLY LEFT ME IN AN UNSAFE VEHICLE, AND NOW I'M RESPONSIBLE FOR THE REPAIR BILL. FORD SO VERY CLEARLY KNEW ABOUT THE PROBLEM AND NEVER CORRECTED THE PROBLEM BY THE TIME BY VEHICLE WAS BUILT. NHTSA NEEDS TO ENCOURAGE FORD TO RECALL ALL THE 2006 AND PROBABLY ALL THE 2007S AS WELL. FORD SHOULD BE PAYING FOR MY REPAIR, NOT ME.

Power Train

ODI #11121951

Incident: August 23, 2018 · Filed: August 23, 2018

DRIVING DOWN THE STREET...LOST ALL FORWARD MOVEMENT. EVERYTHING WAS RUNNING, JUST NO ENGAMENT OF TRANSMISSION

Power Train

ODI #11085104

Incident: February 14, 2018 · Filed: April 15, 2018

TAKATA INFLATORS. DRIVING IN TRAFFIC WITHOUT WARNING VEHICLE JUST STOPS MOVING IN HEAVY TRAFFIC.BELIEVE SOLENOID TO DRIVE TRANNY IS FAULTY.

Power Train; Unknown or Other

ODI #11074530

Incident: February 22, 2018 · Filed: February 23, 2018

I WAS DRIVING DOWN THE ROAD, JUST NORMAL DRIVING, POSTED SPEED OR BELOW,. HAD GAS PEDAL DOWN AND SUDDENLY THE VEHICLE HAS NO POWER. HAD TO PUSH TO THE SIDE. CAN MOVE GEAR SHIFT, BUT CAR DOESN'T GO INTO ANY DIRECTION, FORWARD OR BACKWARD.

Power Train; Vehicle Speed Control

ODI #10995719

Incident: June 12, 2017 · Filed: June 17, 2017

TRANSMISSION PROBLEM ITS RACING ALSO THE CRUSE CONTROL SPEED UP MORE THAN IT SHOULD MY FAMILY AND ARE NOT SAFE WHEN GOING ON A LONG ROAD TRIP HOW WOULD YOU FEEL HAVING A BREAK DOWN IN THE MIDDLE OF NO WHERE AND ON THE HIGH WAY BECAUSE OF THE BAD TRANSMISSION YOU PUT IN THE VEHICLE PLEASE FIX IT PLEASE

Power Train

ODI #10991189

Incident: May 16, 2017 · Filed: May 23, 2017

TL* THE CONTACT OWNS A 2006 MERCURY MONTEREY. WHILE DRIVING 20 MPH, THE VEHICLE FAILED TO ACCELERATE WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 71,080.

Other Mercury Monterey model years

Check your 2006 Mercury Monterey VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Mercury Monterey at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Mercury VIN