NHTSA vehicle safety data

2006 Mercury Mariner Recalls, Ratings & Complaints

The 2006 Mercury Mariner has 4 NHTSA recall campaigns and 63 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Mercury dealer.

NHTSA recall and complaint data for the 2006 Mercury Mariner, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Mercury Mariner owner complaints

Owners have filed 63 complaints with NHTSA about the 2006 Mercury Mariner, describing incidents dated October 1, 2005 to November 14, 2022.

Most-cited components

Vehicle Speed Control 13 complaints
Power Train 11 complaints
Engine 10 complaints
Steering 9 complaints
Service Brakes 8 complaints
Suspension 8 complaints

Of the 63 complaints on file, 5 report a crash; across all 63 complaints, owners report 4 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11493405 · Filed November 14, 2022
Vehicle sub-frame broke at point where lower control arm attaches, causing Right front wheel to suddenly turn right. Sub-frame rusted through!
ODI #11404452 · Filed March 23, 2021
AS I AM DRIVING DOWN THE ROAD, ON A CITY STREET. THE VEHICLE WILL JUST SHUT OFF, FOR NO APPARENT REASON. IT DOES THIS SEVERAL TIMES. EVERY TIME THE CAR IS BEEN DRIVEN IT WILL SHUT OFF SEVERAL TIMES AND ME AND MY FAMILY HAVE BEEN IN TRAFFIC WHEN THIS HAS OCCURRED. IT CONTINUES TO DO THIS AT ANY SPEED…
ODI #11354429 · Filed September 11, 2020
TL* THE CONTACT CALLED ON BEHALF OF HIS DAUGHTER WHO OWNS A 2006 MERCURY MARINER. THE CONTACT STATED THAT AFTER HIS DAUGHTER TURNED INTO A PARKING LOT DRIVING APPROXIMATELY 15 -20 MPH, THE VEHICLE COLLAPSED WITHOUT WARNING ON THE FRONT PASSENGER'S SIDE. THE CONTACT MANAGED TO VEER TO THE SHOULDER OF…

Read all 63 complaints

Rebuilt Transmission Shift Lever May Disengage

NHTSA #15V606000 · Power Train — Automatic Transmission — Lever and Linkage — Floor Shift · NHTSA notice

Reported September 29, 2015 · Ford Motor Company

Potentially affected: 57 vehicles

Repair completion: 21.05% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 15S28 · Owners notified October 23, 2015 · Vehicles built March 31, 2001 – September 1, 2009 (per NHTSA)

Defect description

Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.

Safety consequence

If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Manufacturer remedy

Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Front Wheel Bearing has Wrong Dimensions

NHTSA #15E045000 · Suspension — Front — Wheel Bearing · NHTSA notice

Reported June 3, 2015 · Timken Company

Potentially affected: 576 vehicles

Repair completion: 58.24% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified May 20, 2015

Defect description

The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.

Safety consequence

Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.

Manufacturer remedy

Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Motor Electronics Coolant Pump Failure

NHTSA #14V526000 · Hybrid Propulsion System · NHTSA notice

Reported September 3, 2014 · Ford Motor Company

Potentially affected: 70,209 vehicles

Repair completion: 54.3% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14S19 · Owners notified October 30, 2014 · Vehicles built June 10, 2005 – June 20, 2008 (per NHTSA)

Defect description

Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.

Safety consequence

If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.

Manufacturer remedy

Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

WIPER MOTOR GREASE

NHTSA #05V520000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported November 9, 2005 · FORD MOTOR COMPANY

Potentially affected: 199,942 vehicles

Manufacturer campaign 05S40 · Owners notified November 22, 2005 · Vehicles built August 29, 2005 – October 17, 2005 (per NHTSA)

Defect description

ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Safety consequence

AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Manufacturer remedy

DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.

Notes

FORD RECALL NO. 05S40. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Mercury Mariner 4-DR

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

21% rollover risk

Safety Technology

63 owner complaints have been filed with NHTSA for the 2006 Mercury Mariner.

Steering; Suspension

ODI #11493405

Incident: November 14, 2022 · Filed: November 14, 2022

Vehicle sub-frame broke at point where lower control arm attaches, causing Right front wheel to suddenly turn right. Sub-frame rusted through!

Engine; Fuel/Propulsion System

ODI #11404452

Incident: February 27, 2021 · Filed: March 23, 2021

AS I AM DRIVING DOWN THE ROAD, ON A CITY STREET. THE VEHICLE WILL JUST SHUT OFF, FOR NO APPARENT REASON. IT DOES THIS SEVERAL TIMES. EVERY TIME THE CAR IS BEEN DRIVEN IT WILL SHUT OFF SEVERAL TIMES AND ME AND MY FAMILY HAVE BEEN IN TRAFFIC WHEN THIS HAS OCCURRED. IT CONTINUES TO DO THIS AT ANY SPEED AND EVERY TIME THE CAR IS DRIVEN. CAN'T DRIVE THE CAR NOT EVEN A MILE BEFORE IT TOTALLY SHUTS OFF.

Suspension

ODI #11354429

Incident: September 9, 2020 · Filed: September 11, 2020

TL* THE CONTACT CALLED ON BEHALF OF HIS DAUGHTER WHO OWNS A 2006 MERCURY MARINER. THE CONTACT STATED THAT AFTER HIS DAUGHTER TURNED INTO A PARKING LOT DRIVING APPROXIMATELY 15 -20 MPH, THE VEHICLE COLLAPSED WITHOUT WARNING ON THE FRONT PASSENGER'S SIDE. THE CONTACT MANAGED TO VEER TO THE SHOULDER OF THE ROAD OUT OF THE WAY OF OTHER VEHICLES. A TOWING COMPANY WAS CONTACTED AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN INSPECTED THE VEHICLE AND NOTICED THAT THE SUBFRAME AND CV-JOINT WERE FRACTURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE CONTACT ALSO STATED THAT NHTSA CAMPAIGN NUMBER: 15E045000 (SUSPENSION) WAS REPLACED APPROXIMATELY 1 YEAR AGO, AFTER THE WHEEL COLLAPSED ON FRONT DRIVER'S SIDE. THE VEHICLE WAS ALSO REPAIRED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000.

Engine

ODI #11352783

Incident: September 2, 2020 · Filed: September 2, 2020

ENGINE SUDDENLY CUTS OFF WHILE DRIVING. MESSAGE ON DASH SAYS TO SAFELY STOP THE VEHICLE.

Steering; Power Train; Service Brakes

ODI #11312062

Crash 2 injuries

Incident: February 20, 2020 · Filed: February 28, 2020

RECALL FOR COOLANT PUMP ON HYBRID SYSTEM COULD RESULT IN HYBRID ELECTRONIC OVERHEATING CAUSING A STALL LIKE CONDITION RECALL WAS ADDRESSED BY DEALERSHIP BACK ON 7/20/2015 2ND OWNER HAS HAD VEHICLE FOR 9 MNTHS - HAVE HAD 3 INCIDENTS OF VEHICLE SHUTTING DOWN WITH DASH LIGHT ADVISING TO PULL OVER FOR SAFETY AND THE SYSTEM SHUTTING DOWN DIRECTLY AFTER - BRAKES /STEERING ETC. FOR THE FIRST INCIDENT - TOWED TO LOCAL DEALERSHIP - UNABLE TO DIAGNOSE 2ND INCIDENT - TO A REPUTABLE LOCAL MECHANICS SHOP - CHANGED OUT NORMAL VEHICLE BATTERY 3RD INCIDENT - CAUSED DRIVER TO ROLL THROUGH AN INTERSECTION ON A RED LIGHT - STRUCK BY OTHER VEHICLE

Power Train; Electrical System; Engine

ODI #11296840

Incident: December 1, 2019 · Filed: January 3, 2020

THE GEAR SHIFT IS NOT PROPERLY SHIFTING. IT GOES FROM PARK TO REVERSE ON ITS OWN. SOMETIME IT WONT REVERSE AND MAKES A LOUD NOISE. IT CLICK BACK AND FORTH BETWEEN GEARS. IVE REPLACE THE SWITCH TO SEE IF THAT WOULD WORK BUT IT DOESNT. PLEASE LET ME KNOW IF I CAN DO ANYTHING TO FIX THIS PROBLEM BUT IT IS THE SAME RECALL 15V606000 FOR OTHER VEHICALS OF THE SAME TYPE

Fuel/Propulsion System

ODI #11205996

Incident: May 4, 2019 · Filed: May 7, 2019

WHILE DEIVING A MESSAGE ON THE DASH STATED TO STOP WHILE IT IS SAFE. THE CAR PROCEDED TO STALL. IT COULD NOT BE STARTED. I HAPPEN TO BE IN THE MIDDLE OF THE ROAD AND REQUIRED TO CALL FOR HELP TO PUSH THE VEHICLE TO THE SIDE. I WAS ABLE TO START THE CAR LATER THAT DAY TO DRIVE IT HOME. THIS IS THE FORTH TIME IT HAPPENED OVER AN 18 MONTH PERIOD. I WAS VERY LUCKY THAT I WAS NOT IN HEAVY TRAFFIC OR ON A HIGH SPEED ROAD DURING ANY OF THESE EVENTS. I DID HAVE THE CAR TO A REPAIR SHOP AFTER THE LAST TIME IT HAPPENED AND DESCRIBED THE PROBLEM TO THE MCHANIC. REPAIRS WERE MADE BUT NOTHING TO DO WITH THIS PROBLEM. THIS IS DEFINITELY A SAFETY ISSUE AND IT APPEARS THAT IT HAS BEEN REPORTED MANY TIMES. I DO NOT UNDERSTAND WHY THERE HAS NOT BEEN A RECALL ON THIS ISSUE. I DON'T KNOW WHAT TO DO AT THIS TIME OR WHETHER I SHOULD CONTINUE USING THE VEHICLE.

Power Train

ODI #11187149

Incident: March 14, 2019 · Filed: March 15, 2019

THE CAR SHUTS DOWN ON THE FREEWAY WHILE DRIVING AT 60-70 MPH. A RED TRIANGLA IS DISPLAYED ALONG WITH A MESSAGE, PULL OVER STOP SAFELY NOW. THIS HAS OCCURRED SEVERAL TIMES AFTER DRIVING G APPROXAMATELY 30 MILES. LUCKILY I WAS ABLE TO PULL OVER SAFELY. THE CAR RESTARTS WITHIN 30 SECONDS AND WILL SHUT DOWN AGAIN EVERY 5 MINS UNTIL THE VEHICLE IS ALLOWED TO COOL DOWN.

Structure

ODI #11082502

Incident: March 21, 2018 · Filed: April 2, 2018

I WAS DRIVING ON THE TURNPIKE AND MY CAR SUDDENLY DINT TURN WHEN I TURNED THE STEERING. ME AND MY PASSENGERS SOMEHOW ESCAPED THE LIFE THREATENING SITUATION IN THE MIDDLE OF THE TRAFFIC. IT WAS MY CARS SUB FRAME THAT WAS RUSTED SO BAD THAT IT BROKE IN THE MIDDLE OF THE ROAD. THIS IS AFTER I SERVICE MY CAR EVERY NOW AND THEN. ITS A SERIOUS ISSUE WITH THIS CAR AND THERE SHOULD BE A RECALL FOR THIS PROBLEM. I HAD TO SPEND SO MUCH DUE TO THIS CARELESSNESS FROM THE COMPANY.

Steering; Engine

ODI #11023371

Incident: July 16, 2017 · Filed: September 13, 2017

MY VEHICLE: 2006 MERCURY MARINER HYBRID SUV. PURCHASED NEW IN 2006. IN HOT WEATHER...VEHICLE ENGINE QUITS WHILE IN MOTION ON FREEWAY AT APPROXIMATELY 70 MPH (3 TIMES), AND CITY STREETS (3 TIMES). EXTREMELY DANGEROUS WHEN ENGINE QUITS WHILE DRIVING ON FREEWAY IN TRAFFIC. ALL YOU CAN DO (WHILE PRAYING!) IS COAST TO A STOP AND DO YOUR BEST TO PULL OFF ON TO SHOULDER OF ROAD WITHOUT CRASHING INTO OTHER VEHICLES. WE HAVE TRIED 3 TIMES TO GET FORD MOTOR TO REPAIR THIS PROBLEM...ALL TO NO AVAIL. THE LAST TIME WE HAD TO PAY APPROXIMATELY $1,500. HOWEVER, FORD MOTOR DID REIMBURSE US! BUT AT THE SAME TIME THEY CLAIMED THE PROBLEM WAS RESOLVED. NOT TRUE! ABOUT TWO YEARS LATER THE PROBLEM STARTED ALL OVER AGAIN. FOR10 YEARS WE HAVE BEEN DRIVING A DEFECTIVE VEHICLE THAT WAS--AT ALL TIMES--A DANGER TO OUR LIVES. FORD MOTOR SHOULD HAVE TAKEN THIS PROBLEM MUCH MORE SERIOUSLY AND EITHER REPLACED THE VEHICLE WITH A ANOTHER ONE, OR TRULY FIXED THE PROBLEM. I FEEL FORD MOTOR HAS LIABILITY IN THIS MATTER. THE LAST TIME THIS PROBLEM OCCURRED WAS JULY 16, 2017.

Other Mercury Mariner model years

Check your 2006 Mercury Mariner VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Mercury Mariner at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Mercury VIN