NHTSA vehicle safety data

2005 Mazda MPV Recalls, Ratings & Complaints

The 2005 Mazda MPV has 3 NHTSA recall campaigns and 36 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Mazda dealer.

NHTSA recall and complaint data for the 2005 Mazda MPV, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Mazda MPV owner complaints

Owners have filed 36 complaints with NHTSA about the 2005 Mazda MPV, describing incidents dated March 15, 2005 to July 30, 2023.

Most-cited components

Engine 12 complaints
Air Bags 10 complaints
Service Brakes 4 complaints
Electrical System 3 complaints
Seat Belts 3 complaints
Structure 3 complaints

Of the 36 complaints on file, 5 report a crash; across all 36 complaints, owners report 8 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11565797 · Filed January 16, 2024
The contact owns a 2005 Mazda MPV. The contact stated while driving 45 MPH and depressing the brake pedal, the brake pedal was depressed to the floorboard and the vehicle failed to come to a complete stop. As a result of the failure, the contact crashed into a tree on the passenger side of the…
ODI #11465505 · Filed May 20, 2022
Takata recall. The contact owns a 2005 Mazda MPV. The contact received notification of NHTSA Campaign Number: 18V404000 (Air Bags) however, the nearest dealer location was nearly 5 hours away. The manufacturer was notified of the issue and attempted to send a mechanic from the dealer to the…
ODI #11098311 · Filed May 28, 2018
I WAS COMING HOME FROM WORK DOING THE SPEED LIMIT AND MY CAR WOULD NOT STOP I PRESS THE BRAKE ALL THE WAY TO THE FLOOR AND IT STILL DID NOT STOP I PULLED UP MY EMERGENCY BRAKE AND THAT DID NOT WORK SO FINALLY I GOT THE CAR TO STOP BECAUSE I KEPT PUMPING THE BRAKES AND THE CAR STARTED SLOWING DOWN…

Read all 36 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Mazda MPV in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page

Open and recently closed NHTSA defect investigations

Passenger Frontal Air Bag Inflator May Explode

NHTSA #19V781000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported October 31, 2019 · Mazda North American Operations

Potentially affected: 47,006 vehicles

Repair completion: 37.75% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Mazda campaign 2618F · Owners notified December 3, 2019 · Vehicles built August 21, 2003 – August 27, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Mazda dealer immediately.

Defect description

Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began December 3, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: This recall supersedes recalls 13V130, 14V362, 14V773 and 15V869.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #18V404000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported June 15, 2018 · Mazda North American Operations

Potentially affected: 4,184 vehicles

Repair completion: 11.24% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Mazda campaign 2618F · Owners notified July 6, 2018 · Vehicles built August 2, 2004 – April 28, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Mazda dealer immediately.

Defect description

Mazda North America Operations (Mazda) is recalling certain 2005-2006 Mazda MPV vehicles sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. On July 9, 2019 this recall was expanded to include certain 2005-2009 RX-8 vehicles that were previously recalled under 17V-011 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator explosion may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018 for MPV vehicles. The recall began July 9, 2019 for RX-8 vehicles. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: With the addition of the RX-8 vehicles, this recall fully supersedes recall 17V-011.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #18V402000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported June 15, 2018 · Mazda North American Operations

Potentially affected: 308,591 vehicles

Repair completion: 9.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Mazda campaign 2618F · Owners notified July 6, 2018 · Vehicles built August 21, 2002 – April 28, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Mazda dealer immediately.

Defect description

Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018. Mailing to the affected RX-8 owners began July 6, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: With the addition of the RX-8 vehicles, this recall fully supersedes recall 16V354.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

2005 Mazda MPV

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

3 investigations

36 owner complaints have been filed with NHTSA for the 2005 Mazda MPV.

Service Brakes

ODI #11565797

Crash

Incident: July 30, 2023 · Filed: January 16, 2024

The contact owns a 2005 Mazda MPV. The contact stated while driving 45 MPH and depressing the brake pedal, the brake pedal was depressed to the floorboard and the vehicle failed to come to a complete stop. As a result of the failure, the contact crashed into a tree on the passenger side of the vehicle. The driver's side air bag deployed; however, the passenger’s side air bag did not deploy. No warning lights were illuminated. A Police report was filed, but no injuries were reported. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V781000 (Air Bags). The contact stated that the VIN was included; however, the vehicle had previously been repaired by the dealer. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 251,000.

Air Bags

ODI #11465505

Incident: March 1, 2022 · Filed: May 20, 2022

Takata recall. The contact owns a 2005 Mazda MPV. The contact received notification of NHTSA Campaign Number: 18V404000 (Air Bags) however, the nearest dealer location was nearly 5 hours away. The manufacturer was notified of the issue and attempted to send a mechanic from the dealer to the residence for the recall repair however, the dealer declined. The contact was then referred to a Subaru dealer for assistance; however, the manufacturer failed to send the part to the dealer. The contact had gone back and forth with the manufacturer and other dealers but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

Service Brakes

ODI #11098311

Incident: May 28, 2018 · Filed: May 28, 2018

I WAS COMING HOME FROM WORK DOING THE SPEED LIMIT AND MY CAR WOULD NOT STOP I PRESS THE BRAKE ALL THE WAY TO THE FLOOR AND IT STILL DID NOT STOP I PULLED UP MY EMERGENCY BRAKE AND THAT DID NOT WORK SO FINALLY I GOT THE CAR TO STOP BECAUSE I KEPT PUMPING THE BRAKES AND THE CAR STARTED SLOWING DOWN AND I THREW IT IN PARK I WAS SO SCARED I SEARCHED AROUND FOR RECALLS ON THE BRAKE AND THE EMERGENCY BRAKE THE ONLY RECALL I SEEN WAS IN 2017 IN DETROIT. PLEASE ANYTHING SUGGESTIONS

Unknown or Other

ODI #11054508

Incident: June 30, 2016 · Filed: December 13, 2017

DOS NOTE TUN ON CHECKLIGHT.ENGINE WENT OUT RUNNING ANDE DOS NOTE GIVE CONDE.TRIED WIHT OTHER ECU ANDE HACE THE DAME.

Engine

ODI #11052832

Incident: December 6, 2017 · Filed: December 6, 2017

ENGINE STALLS OR SHUT DOWN COMPLETELY WHEN AUTO MOVES FROM HIGH SPEED TO LOW SPEED. MAZDA 6 W/ 3.0 LITER ENGINE, WHICH IS THE SAME ENGINE AS THIS UNIT, HAS A SIMILAR ISSUE - SEE HERE: HTTP://WWW.6CREW.COM/FILES/TSB/01-016-06-2135.PDF THIS IS HAPPENING PERSISTENTLY FOR THE LAST 2 YEARS.

Structure

ODI #11022890

Incident: May 29, 2017 · Filed: September 12, 2017

TL* THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED THAT THE FRONT PASSENGER AND DRIVER SIDE DOORS FAILED TO OPEN FROM THE INSIDE. THE CONTACT HAD TO OPEN THE WINDOWS TO OPEN THE DOORS FROM THE OUTSIDE HANDLE. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

Air Bags

ODI #11006748

Incident: December 15, 2016 · Filed: July 21, 2017

TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT SPOKE WITH BOMMARITO MAZDA SERVICE (4198 I-70 NORTH OUTER RD, ST PETERS, MO 63376) WHO STATED THAT THEY HAD NOT YET RECEIVED THE REPAIR PARTS. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Structure

ODI #10984967

Incident: April 1, 2017 · Filed: May 11, 2017

TL* THE CONTACT OWNS A 2005 MAZDA MPV. WHILE THE VEHICLE WAS STATIONARY, THE FRAME OF THE VEHICLE IN FRONT OF THE REAR WHEELS WAS RUSTED AND SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 79,473.

Electrical System; Air Bags; Interior Lighting; Engine

ODI #10960427

Incident: May 25, 2016 · Filed: March 13, 2017

TL* TAKATA RECALL. THE CONTACT OWNS A 2005 MAZDA MPV. THE CONTACT STATED THAT THERE WAS A RANDOM FAILURE AND VARIOUS WARNING INDICATORS FLASHED, INCLUDING THE SERVICE ENGINE AND AIR BAG WARNING INDICATORS. IN ADDITION, THE INTERIOR LIGHTING FAILED TO FUNCTION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) SEVERAL MONTHS AGO AND WAS UNABLE TO SCHEDULE A REPAIR WITH A DEALER WITHIN A REASONABLE TIME FRAME. THE CONTACT WAS UNCERTAIN OF WHEN THE VEHICLE WOULD BE REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.

Air Bags

ODI #10953758

Incident: October 31, 2016 · Filed: February 9, 2017

IN AUGUST OF 2016 RECEIVED A NOTICE FROM MAZDA STATING MAZDA DECIDED THAT A DEFECT WHICH RELATES TO MOTOR VEHICLE SAFETY EXISTS IN MAZDA 2005 MPV. THE RECALL NOTICE CONTINUES TO STATE DO NOT DRIVE THE VEHICLE BECAUSE HIGH LEVELS OF HUMIDITY CAN CAUSE THE PASSENGER FRONTAL AIR BAG TO RUPTURE AND COULD RESULT IN METAL FRAGMENTS STRIKING THE DRIVER OR OTHER VEHICLE OCCUPANTS RESULTING IN SERIOUS INJURY OR DEATH. ON 10-31-16, I CALLED OAK TREE MAZDA, SAN JOSE TO SCHEDULE THE APPOINTMENT. I PROVIDED THEM WITH MY VIN NUMBER AND WAS TOLD BY THE PARTS DEPARTMENT THEY DID NOT HAVE THE PART IN STOCK AND WOULD NEED TO ORDER IT. THE SAID AS SOON AS THE PART CAME IN THEY WOULD CALL ME TO SCHEDULE THE REPAIR. NEVER RECEIVED A CALL BACK WITHIN 1 MONTH. CALLED AGAIN AND WAS IN ESSENCE TOLD THE SAME INFORMATION TAT THEY WOULD CALL ME BACK WITH INFORMATION. PROVIDED THEM WITH MY CORRECT PHONE NUMBER AND AS OF THIS DATE, 2-9-17 HAVE NOT RECEIVED A CALL BACK TO SCHEDULE MY APPOINTMENT. PLEASE ASSIST ME IN GETTING THIS ISSUE FIXED SO WE CAN DRIVE OUR VEHICLE. I AM NOT SURE IF THIS INVOLVES THE "TAKATA RECALL" AS OUR PAPERWORK JUST INDICATES, FRONT AIR BAG INFLATOR.

Other Mazda MPV model years

Check your 2005 Mazda MPV VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Mazda MPV at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Mazda VIN