NHTSA vehicle safety data

2001 Kia Sportage Recalls & Complaints

The 2001 Kia Sportage has 2 NHTSA recall campaigns and 228 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Kia dealer.

NHTSA recall and complaint data for the 2001 Kia Sportage. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Kia Sportage owner complaints

Owners have filed 228 complaints with NHTSA about the 2001 Kia Sportage, describing incidents dated May 30, 2000 to March 17, 2018.

Most-cited components

Fuel/Propulsion System 62 complaints
Engine 46 complaints
Service Brakes 26 complaints
Structure 24 complaints
Electrical System 23 complaints
Power Train 22 complaints

Of the 228 complaints on file, 25 report a crash and 4 a fire; across all 228 complaints, owners report 17 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11082039 · Filed March 29, 2018
I BOUGHT THE CAR 2 WEEKS AFTER I LEFT DEALER STARTED NOTICING A SMELL OF GAS THOUGH WAS. BECAUSE JUST PUT GAS IN .THEN WHEN TURNED ON HEAT SMELL WOULD GET WORSE ! A FEW DAYS AGO WENT TO FILL GAS AND A LOT GAS OVER.FILLED ONTO GROUND NOT ABLE TO FIGURE OUT WHY THE SMELL GAS SO STRONG INSIDE CAR ITS…
ODI #10940367 · Filed January 7, 2017
BOUGHT THIS VEHICLE WITH ONLY 11K MILES FROM AN ELDERLY COUPLE THAT HARDLY DROVE IT. NOW AT 21K MILES, THERE IS A GAS SMELL COMING INSIDE THE VEHICLE AND ALSO OUTSIDE OF THE VEHICLE. HAS A ROUGH IDLE AND GAS SPEWS OUT OF TANK WHILE I'M PUMPING GAS. THE FRONT PASSENGER TIRE SOUNDS LIKE IT'S ABOUT TO…
ODI #10795040 · Filed November 20, 2015
TL* THE CONTACT OWNS A 2001 KIA SPORTAGE. WHILE DRIVING AT APPROXIMATELY 20 MPH, THE VEHICLE BEGIN TO SHAKE, THE BRAKE WARNING INDICATOR ILLUMINATED, AND THE BRAKES FAILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME WAS CORRODED AND NEEDED TO BE REPLACED…

Read all 228 complaints

Owner-reported

2001 Kia Sportage mileage at failure

121 of the 228 complaints on file for the 2001 Kia Sportage give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Fuel/Propulsion System	Median 70,000 miles	Middle half 50,000–90,000 miles	Based on 48 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Kia Sportage in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA06-007: FUEL TANK LEAKAGE
Closed November 30, 2007
Recall Query RQ03-007: SEAT BELT BUCKLE FALSE LATCH/MALFUNCTION
Closed February 27, 2004
- Recall 04V-305

Open and recently closed NHTSA defect investigations

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2001 Kia Sportage. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

228 owner complaints have been filed with NHTSA for the 2001 Kia Sportage.

Electrical System; Fuel/Propulsion System

ODI #11082039

Incident: March 17, 2018 · Filed: March 29, 2018

I BOUGHT THE CAR 2 WEEKS AFTER I LEFT DEALER STARTED NOTICING A SMELL OF GAS THOUGH WAS. BECAUSE JUST PUT GAS IN .THEN WHEN TURNED ON HEAT SMELL WOULD GET WORSE ! A FEW DAYS AGO WENT TO FILL GAS AND A LOT GAS OVER.FILLED ONTO GROUND NOT ABLE TO FIGURE OUT WHY THE SMELL GAS SO STRONG INSIDE CAR ITS. ACTUALLY UPSET MY STOMACH WHEN DRIVING THE. AT AND AFRAID GOING START FIRE ! ALSO LEAKAGE ON GROUND WHEN PARKED . I HAVE READ OTHER COMPLAINTS WITH SAME PROBLEM !! IT'S A 2001 KIA. ONLY HAS 78,000 MILES ON IT THINK SHOULD BE COVER. FROM COMPANY SINCE NOT ONLY ONE WITH THIS PROBLEM .

Seat Belts; Wheels; Fuel/Propulsion System

ODI #10940367

Incident: December 15, 2016 · Filed: January 7, 2017

BOUGHT THIS VEHICLE WITH ONLY 11K MILES FROM AN ELDERLY COUPLE THAT HARDLY DROVE IT. NOW AT 21K MILES, THERE IS A GAS SMELL COMING INSIDE THE VEHICLE AND ALSO OUTSIDE OF THE VEHICLE. HAS A ROUGH IDLE AND GAS SPEWS OUT OF TANK WHILE I'M PUMPING GAS. THE FRONT PASSENGER TIRE SOUNDS LIKE IT'S ABOUT TO FALL OFF. HAD TO REPLACE SPARK PLUGS TWICE ALREADY. ALSO, THE DRIVERSIDE SEATBELT WILL NOT RETRACT. I BOUGHT THIS VEHICLE WITH ONLY 11K MILES THINKING IT WILL LAST FOR AWHILE, BUT I'VE HAD SO MANY ISSUES WITH IT.

Structure

ODI #10795040

Incident: November 19, 2015 · Filed: November 20, 2015

TL* THE CONTACT OWNS A 2001 KIA SPORTAGE. WHILE DRIVING AT APPROXIMATELY 20 MPH, THE VEHICLE BEGIN TO SHAKE, THE BRAKE WARNING INDICATOR ILLUMINATED, AND THE BRAKES FAILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE. UPDATED 01/12/16*LJ ;UPDATED VIN INVALID 4/25/18*JB *TR

Fuel/Propulsion System

ODI #10703076

Incident: April 1, 2013 · Filed: April 1, 2015

TL* THE CONTACT OWNS A 2001 KIA SPORTAGE. WHILE DRIVING AT VARIOUS SPEEDS, FUEL FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED FUEL LEAKING FROM THE FUEL TANK. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT FUEL WAS LEAKING FROM THE TOP OF THE FUEL TANK AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,000.

Fuel System, Gasoline

ODI #10668990

Incident: December 25, 2014 · Filed: December 30, 2014

JUST PURCHASED THIS CAR FOR MY TEEN...WHEN FILLING GAS TANK IT BEGINS TO SPEW OUT ONTO HIM . ARE THE PERSON FILLING THE TANK.ALSO A BAD SMELL OF FUMES INSIDE OF CAR,,,,PLEASE HELP THE PROBLEM....*JS

Suspension

ODI #10644890

Incident: October 15, 2014 · Filed: October 15, 2014

THE REAR PART OF THE FRAME JUST BEHIND THE REAR SUSPENSION RUSTS FROM WATER THROWN UP BY THE TIRES. WHILE THIS MIGHT NOT NORMALLY BE A DANGER UNLESS YOU WERE TOWING, ON THIS MODEL IT'S WHERE THE FRAME CONNECTS TO THE WHEELS BELOW TO STABILIZE THE FRAME OVER THE SUSPENSION, WITHOUT THIS SUPPORT IT RELEASES THE BACK SUSPENSION AND ALLOWS THE CAR TO EASILY ROCK BACK AND FORTH INTO THE WHEELS. I COULD SEE SHINY SPOTS ON THE SHOCKS FROM TIRE RUB WHERE THE PAINT WAS RUBBED OFF, NO CURRENT SIGN OF TIRE DAMAGE. I FEEL THIS COULD CAUSE AN ACCIDENT BECAUSE THE SHOCKS, SPRINGS OR OTHER METAL BODY OR FRAME PART COULD WEAR OR POSSIBLY IF SHARP PUNCTURE A TIRE ON EITHER SIDE WHEN CORNERING. THIS PROBLEM CAN EASILY BE SEEN BY SWINGING THE SPARE TIRE OUT OF IT'S CLOSED POSITION TO OPEN THE TAILGATE, WHEN THE TIRE REACHES THE END OF IT'S ARM THE WHOLE BACK END OF THE VEHICLE WILL MOVE OVER, THE RUSTED FRAME BELOW WILL BEND. *TR

Fuel/Propulsion System

ODI #10626338

Incident: August 4, 2014 · Filed: August 19, 2014

TL* THE CONTACT OWNS A 2001 KIA SPORTAGE. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL, WHICH CREATED FUMES IN AND AROUND THE VEHICLE. THE CONTACT LOCATED THE LEAK UNDER THE FUEL TANK ON THE PASSENGER SIDE OF THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED DUE TO THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

Fuel/Propulsion System

ODI #10615861

Incident: July 7, 2014 · Filed: July 23, 2014

JUST PURCHASED THIS VEHICLE FROM A PRIVATE OWNER, THEY SMELLED AN ODOR OF FUEL EVER SINCE THEY ACQUIRED THE VEHICLE A MONTH AGO. PRIOR TO THAT IT WAS OWNED BY ONE OWNER AND GARAGE KEPT. THE FUEL TANK AND BOTTOM PROTECTOR WAS ROTTED AWAY AND IN DANGEROUS LEAKING CONDITION. KIA WAS CONTACTED AND THEY SAID THERE WERE NO RECALL AND THEY WOULDN'T REPAIR THE VEHICLE. THE ROT IN THIS TANK DIDN'T HAPPEN OVERNIGHT, BUT IT WAS SO SEVERE THAT IT WARRANTS A LOOK FROM THE NHTSA INTO THIS. A MANUFACTURER SUCH AS KIA SHOULD NOT BE ABLE TO SELL AN INFERIOR SAFETY HAZARD TO THE CITIZENS OF THE USA. THERE WERE INVESTIGATIONS INTO THIS PROBLEM A FULL 7 YEARS AGO AND NOTHING WAS DONE. THIS IS AN INSULT TO PEOPLE CONCERNED WITH MOTORING SAFETY, WE SHOULD EXPECT BETTER FROM BOTH THE MANUFACTURER AND GOVERNMENT AGENCIES SUCH AS THIS ONE. IT'S NOT A MILEAGE ISSUE, THE 1999/2000 SPORTAGES WERE RUSTING OUT WITH ONLY A FEW YEARS OF SERVICE AND IT IS DUE TO INFERIOR MATERIALS THAT SHOULD BE COVERED BY A MANUFACTURER THAT USES THEM. *TR

Fuel System, Gasoline; Electrical System

ODI #10614450

Incident: July 9, 2014 · Filed: July 17, 2014

THE CAR KEEPS STALLING JUST QUITS WHEN I SLOW DOWN. I HAD TWO MECHANICS CHECK IT OUT. FILLED THE TANK WITH NEW GAS, AND NOTHING SHOWED UP ON THE ELECTRICAL CHECK. IT IS A MYSTERY WHY THIS KEEPS HAPPENING. I AM WORRIED THAT THIS MIGHT HAPPEN ON A MAJOR HIGHWAY. AND I DON'T WANT TO SELL THE CAR AND GIVE SOMEONE ELSE THIS PROBLEM.

Structure

ODI #10573564

Incident: March 19, 2014 · Filed: March 19, 2014

I JUST TRIED TO GET MY KIA SPORTAGE INSPECTED AND WAS TOLD BY TWO DIFFERENT PLACES THE FRAME IS RUSTED RIGHT OUT AND I SHOULDN'T EVEN BE DRIVING IT. I JUST LOOKED ONLINE ABOUT THE PROBLEM AND THERE ARE ALOT OF COMPLAINTS AND FEEL THERE SHOULD BE A RECALL TO FIX THE PROBLEM. THE CAR IS FINE OTHERWISE. IF THERE IS NO RECALL I AM GOING TO BE WITHOUT A VEHICLE NOW BECAUSE I CANT AFFORD ANOTHER ONE. *TR

Other Kia Sportage model years

Check your 2001 Kia Sportage VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Kia Sportage at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Kia VIN