NHTSA vehicle safety data

2004 Itasca Meridian Recalls & Complaints

The 2004 Itasca Meridian has 4 NHTSA recall campaigns and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Itasca dealer.

NHTSA recall and complaint data for the 2004 Itasca Meridian. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Itasca Meridian owner complaints

Owners have filed 4 complaints with NHTSA about the 2004 Itasca Meridian, describing incidents dated February 27, 2008 to May 5, 2021.

Most-cited components

Exterior Lighting 1 complaint
Fuel/Propulsion System 1 complaint
Power Train 1 complaint
Service Brakes 1 complaint
Structure 1 complaint
Unknown or Other 1 complaint

Of the 4 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11416196 · Filed May 11, 2021
OUR ENTIRE MOTORHOME BURNED COMPLETELY, WE BARELY ESCAPED WITH OUR LIVES, WHEN THE NORCOLD REFRIGERATOR CAUGHT FIRE IN THE NIGHT WHILE WE WERE ASLEEP. WE WERE PARKED ON REMOTE PRIVATE PROPERTY. Consumer stated from 2004- 2020 there was no issues with the refrigerator. Original owners: [XXX]and [XXX]…
ODI #10511169 · Filed May 8, 2013
TL* THE CONTACT OWNS A 2004 ITASCA MERIDIAN. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE FOG HEADLIGHTS FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT REPAIRED. THE DEALER DID NOT PROVIDE A DIAGNOSIS FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE…
ODI #10462563 · Filed June 21, 2012
A PROPANE LEAK ODOR, COMING FROM MY MOTORHOME, WAS BROUGHT TO MY ATTENTION BY A CAMPER IN AN ADJOINING CAMPSITE. I USED A WATER AND SOAP SOLUTION AND FOUND MY PROPANE TANK WAS LEAKING AT THE REAR BRACKET WELD. I CONTACTED WINNEBAGO'S 800 PHONE NUMBER LISTED IN A RECALL LISTEDON THE INTERNET AS NHTSA…

Read all 4 complaints

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #10V525000 · Equipment · NHTSA notice

Reported October 26, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 18,461 vehicles

Owners notified December 15, 2010

Defect description

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REFRIGERATOR ROOF VENT RELOCATION

NHTSA #05V407000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported September 14, 2005 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 1,367 vehicles

Manufacturer campaign 96 · Owners notified September 9, 2005 · Vehicles built May 2, 2002 – August 12, 2005 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES, THE ROOF VENT FOR THE OPTIONAL 4-DOOR REFRIGERATOR WAS INCORRECTLY LOCATED.

Safety consequence

THIS CAN ALLOW EXCESSIVE HEAT BUILDUP WHICH HAS THE POTENTIAL TO IGNITE SURROUNDING MATERIALS, RESULTING IN PERSONAL INJURY AND/OI VEHICLE AND PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL RELOCATE THE ROOF VENT. THE RECALL BEGAN ON SEPTEMBER 9, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.

Notes

WINNEBAGO RECALL NO. 96.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

WINNEBAGO/AMSAFE/SEAT BELTS

NHTSA #04V608000 · Seat Belts — Front — Buckle Assembly · NHTSA notice

Reported December 18, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 6,201 vehicles

Manufacturer campaign 92 · Owners notified November 29, 2004 · Vehicles built September 8, 2003 – April 30, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Safety consequence

THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Manufacturer remedy

DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO RECALL NO. 92.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

WINNEBAGO/LP TANK

NHTSA #04V114000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Tank Assembly · NHTSA notice

Reported March 4, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 5,143 vehicles

Manufacturer campaign 90 · Owners notified March 25, 2004 · Vehicles built April 28, 1999 – September 19, 2003 (per NHTSA)

Defect description

ON CERTAIN MOTORHOMES, THE LP TANK HAS STRESS ON WELD JOINTS AT THE POINT WHERE MOUNTING BRACKETS ARE WELDED TO THE TANK.

Safety consequence

THIS COULD CAUSE STRESS CRACKS AT THE WELD JOINTS AND LEAD TO AN LP LEAK AND CAUSE PERSONAL INJURY AND/OR VEHICLE DAMAGE.

Manufacturer remedy

DEALERS WILL REINSTALL A CRADLE-STYLE CARRIER, AND, IF NECESSARY REPLACE THE LP TANK. THE RECALL BEGAN ON MARCH 25, 2004. OWNERS SHOULD CONTACT WINNEBAGO AT 641-585-6939.

Notes

WINNEBAGO RECALL NO. 90.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2004 Itasca Meridian. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

4 owner complaints have been filed with NHTSA for the 2004 Itasca Meridian.

Power Train; Structure; Unknown or Other

ODI #11416196

Fire

Incident: May 5, 2021 · Filed: May 11, 2021

OUR ENTIRE MOTORHOME BURNED COMPLETELY, WE BARELY ESCAPED WITH OUR LIVES, WHEN THE NORCOLD REFRIGERATOR CAUGHT FIRE IN THE NIGHT WHILE WE WERE ASLEEP. WE WERE PARKED ON REMOTE PRIVATE PROPERTY. Consumer stated from 2004- 2020 there was no issues with the refrigerator. Original owners: [XXX]and [XXX] Email: [XXX] @ aol.com Telephone [XXX] Address [XXX] Documents follow INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”

Exterior Lighting

ODI #10511169

Incident: December 7, 2012 · Filed: May 8, 2013

TL* THE CONTACT OWNS A 2004 ITASCA MERIDIAN. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE FOG HEADLIGHTS FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT REPAIRED. THE DEALER DID NOT PROVIDE A DIAGNOSIS FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 35,000. *TR

Fuel System, Diesel

ODI #10462563

Incident: June 18, 2012 · Filed: June 21, 2012

A PROPANE LEAK ODOR, COMING FROM MY MOTORHOME, WAS BROUGHT TO MY ATTENTION BY A CAMPER IN AN ADJOINING CAMPSITE. I USED A WATER AND SOAP SOLUTION AND FOUND MY PROPANE TANK WAS LEAKING AT THE REAR BRACKET WELD. I CONTACTED WINNEBAGO'S 800 PHONE NUMBER LISTED IN A RECALL LISTEDON THE INTERNET AS NHTSA RECALL 04V114/WINNEBAGO RECALL 90. WINNEBAGO ASVISED ME THAT MY COACH WASN'T IN THE SERIAL NUMBER RANGE FOR THIS RECALL, THEY OFFERED TO SEND ME MOUNTING CRADLES UNDER THIS RECALL BUT WON'T REPLACE THE PROPANE TANK. *TT

Service Brakes, Air

ODI #10219354

Incident: February 27, 2008 · Filed: February 27, 2008

THE 2 REAR AIR BRAKE HOSES TO THE AIR CANISTERS ON A 2004 FREIGHTLINER RV CHASSIS HAVE RUBBED TOGETHER ENOUGH TO MAKE A PIN HOLE LEAK IN ONE OF THEM AND A PARTIAL WEAR-THROUGH IN THE OTHER. WITH A WARNING FROM OTHER USERS ON AN RV FORUM, A PHYSICAL INSPECTION CAUGHT THIS PROBLEM BEFORE A BRAKE FAILURE HAPPENED AND POSSIBLE PROPERTY DAMAGE OR LOSS OF LIFE COULD OCCUR. BOTH OF THESE HOSES MUST BE REPLACED AND THE HOSES MUST BE RE-ROUTED TO KEEP THIS FROM RECURRING. *TR

Other Itasca Meridian model years

Check your 2004 Itasca Meridian VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Itasca Meridian at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Itasca VIN