NHTSA vehicle safety data

2015 Isuzu NPR Recalls & Complaints

The 2015 Isuzu NPR has 5 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Isuzu dealer.

NHTSA recall and complaint data for the 2015 Isuzu NPR. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2015 Isuzu NPR owner complaints

Owners have filed 1 complaint with NHTSA about the 2015 Isuzu NPR, describing incidents dated August 6, 2019.

Most-cited components

Engine 1 complaint
Fuel/Propulsion System 1 complaint
Steering 1 complaint

Newest complaints

ODI #11271094 · Filed October 25, 2019
I HAD MY 2015 ISUZU TRUCK TOWED FOR SERVICE TO THE ISUZU DEALERSHIP (1463 US-22, MOUNTAINSIDE, NJ 07092) WHERE I LEASED IT. EVEN THOUGH THE TRUCK WAS BROUGHT IN DUE TO A PROBLEM WITH THE ENGINE THAT WAS COVERED UNDER THE TRUCK'S WARRANTEE, THEY FORCED ME TO SPEND OVER $1000 ON A NEW TIRE AND MANY…

Read the full complaint

NHTSA defect investigations

NHTSA's investigations file lists the 2015 Isuzu NPR in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE19-005: Unintended Movement
Closed December 9, 2021

Open and recently closed NHTSA defect investigations

Rear Axle U-Bolt Not Properly Tightened

NHTSA #21V194000 · Suspension — Rear — Springs — Leaf Spring Assembly — U-Bolt, Leaf Spring to Axle · NHTSA notice

Reported March 19, 2021 · Isuzu Technical Center of America, Inc.

Potentially affected: 258 vehicles

Repair completion: 74.03% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Isuzu campaign V2103 · Owners notified April 23, 2021

Defect description

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2015-2017 Isuzu NPR, Reach, 2016-2020 Isuzu NPR XD, NPR HD, NQR, 2016-2021 Isuzu NRR, 2017-2020 Chevrolet 4500XD, 4500HD, 5500HD, and 2020 Chevrolet 5500XD vehicles. The U-bolt nuts for the rear axle may not have been properly tightened and may loosen, causing the axle to misalign.

Safety consequence

The misalignment may cause the propeller shaft to separate, causing a loss of power to the rear wheels and a stall, increasing the risk of a crash.

Manufacturer remedy

Isuzu will notify owners, and dealers will inspect and, if needed, replace and tighten the rear axle U-bolt nuts, free of charge. The recall began on April 23, 2021. Owners may contact Isuzu customer service at 1-866-441-9638. Isuzu's number for this recall is V2103.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Fire Extinguisher May Be Clogged or Inoperable

NHTSA #17V726000 · Equipment · NHTSA notice

Reported November 14, 2017 · Isuzu Technical Center of America, Inc.

Potentially affected: 69,138 vehicles

Repair completion: 3.17% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Isuzu campaign V1705 · Owners notified January 11, 2018 · Vehicles built September 21, 2010 – October 13, 2017 (per NHTSA)

Defect description

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2011-2017 Isuzu NPR, 2008 NPR HD and NPR-HD Gas, 2011-2018 NPR HD and NRR, 2015-2018 NPR XD, 2012-2018 NQR, 2012-2017 NPR Gas and NPR-HD Gas, 2016-2017 Chevrolet Low Cab Forward 3500 HD, 3500 and 4500 and 2017-2018 Chevrolet Low Cab Forward 4500 HD, 4500 XD, 5500 HD and 5500 XD vehicles, equipped with certain Walter Kidde Plastic-Handle Fire Extinguishers, models FC10 and FC110. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable.

Safety consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Manufacturer remedy

Isuzu will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall is expected to begin in December 2017. Owners may contact Isuzu customer service at 1-866-441-9638 or Walter Kidde customer service at 1-855-262-3540 or they may also visit www.kidde.com and click on "Product Safety Recall" to order replacement fire extinguishers free of charge. Isuzu's number for this recall is V1705. Note: This recall includes fire extinguishers provided as a remedy for previous Isuzu recall 15V778.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Rear Wheel/Axle Assembly may Partially Separate

NHTSA #17V191000 · Power Train — Axle Hubs · NHTSA notice

Reported March 21, 2017 · Isuzu Technical Center of America, Inc.

Potentially affected: 97,000 vehicles

Repair completion: 64.1% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified April 19, 2017 · Vehicles built September 16, 2010 – April 16, 2016 (per NHTSA)

Defect description

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2011-2016 NPR, 2011-2017 NPR-HD, NQR, NRR, 2015-2017 NPR-XD, 2012-2016 Reach, NPR Gas and NPR-HD Gas incomplete trucks. The left rear wheel bearing hub locking bolts may not have been properly tightened during assembly.

Safety consequence

The loose bolts can allow the wheel assembly to move outward from the axle housing, affecting the control of the vehicle and reducing braking performance, thereby increasing a risk of a crash.

Manufacturer remedy

Isuzu will notify owners, and dealers will inspect the left rear wheel bearing hub locking bolts, tightening them as necessary, free of charge. The recall began on April 19, 2017. Owners may contact Isuzu customer service at 1-866-441-9638.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Throttle may Stick in the Open Position

NHTSA #16V797000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported November 2, 2016 · Isuzu Technical Center of America, Inc.

Potentially affected: 25,018 vehicles

Repair completion: 60.88% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified November 9, 2016 · Vehicles built August 26, 2013 – November 11, 2016 (per NHTSA)

Defect description

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain model year 2014-2016 Isuzu NPR and NPR HD vehicles manufactured August 26, 2013, to November 11, 2016, and 2016 Chevrolet Low Cab Forward 3500 and 4500 vehicles manufactured July 27, 2016, to November 11, 2016. The affected vehicles have a throttle pedal that may get stuck under the steel stopper bolt, causing the pedal to remain in the full throttle position. Note: In gasoline models only.

Safety consequence

A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.

Manufacturer remedy

Isuzu will notify owners, and dealers will remove and replace the stopper bolt with a flanged plate, to prevent lateral movement of the throttle, free of charge. The recall began November 14, 2016. Owners may contact Isuzu customer service at 1-866-441-9638.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Kidde Handheld Fire Extinguisher may not Discharge

NHTSA #15V778000 · Equipment · NHTSA notice

Reported November 20, 2015 · Isuzu Technical Center of America, Inc.

Potentially affected: 25,209 vehicles

Repair completion: 50.7% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 18, 2016 · Vehicles built November 24, 2011 – August 27, 2015 (per NHTSA)

Defect description

Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2012-2016 NPR, NPR-HD, NPR-XD, NQR, and NRR diesel trucks manufactured November 24, 2011, to July 24, 2015, and 2012-2015 NPR and NPR-HD gasoline-powered trucks manufactured October 5, 2011, to August 27, 2015. The trucks may have been equipped with certain Kidde plastic valve disposable handheld fire extinguishers, model FC10, that may not properly discharge when the lever is pressed.

Safety consequence

In the event of a fire, if the fire extinguisher does not work correctly, there is an increased risk of injury.

Manufacturer remedy

Isuzu will notify and instruct owners to order replacement fire extinguishers free of charge directly from Kidde Safety at www.kidde.com, or toll-free at (855)283-7991, or by contacting and visiting a dealer. The recall began on January 18, 2016. Owners may contact Isuzu customer service at 1-866-441-9638.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

try.vin has no NCAP crash-test rating on file for the 2015 Isuzu NPR. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2015 Isuzu NPR.

Steering; Engine; Fuel/Propulsion System

ODI #11271094

Incident: August 6, 2019 · Filed: October 25, 2019

I HAD MY 2015 ISUZU TRUCK TOWED FOR SERVICE TO THE ISUZU DEALERSHIP (1463 US-22, MOUNTAINSIDE, NJ 07092) WHERE I LEASED IT. EVEN THOUGH THE TRUCK WAS BROUGHT IN DUE TO A PROBLEM WITH THE ENGINE THAT WAS COVERED UNDER THE TRUCK'S WARRANTEE, THEY FORCED ME TO SPEND OVER $1000 ON A NEW TIRE AND MANY OTHER "NEEDED" REPAIRS SO THE TRUCK COULD PASS FEDERAL INSPECTION. UPON PICKING UP THE TRUCK, IT HAD NO INSPECTION STICKER AND THEY SLAPPED ONE ON IN LESS THAN 5 MINUTES AND COULD NOT HAVE INSPECTED THE TRUCK. WHEN THE TECHNICIAN FINALLY CAME OUT TO MY PROPERTY AT 206 TYLER ROAD, EDISON NJ 08820, HE TOOK THE TRUCK FOR SHORT TEST DRIVE AND UPON RETURNING HE INFORMED ME THAT THE TRUCK HAD A PROBLEM WITH THE STEERING, SOUNDED LOUD AND IT DID PULL TO THE RIGHT. IT DID NOT DO THAT WHEN THE TRUCK WAS TOWED AND SERVICED. THE SERVICE MANAGER TOLD ME THAT HE WOULD NOT TOW THE TRUCK BACK TO THE STATION AND THAT THEY WOULD FIX THE PROBLEM BUT I HAD TO DRIVE IT BACK TO THE ISUZU DEALERSHIP APPROXIMATELY 10 MILE. I HAVE LOST SIGNIFICANT MONEY FOR MY CHARITY SOMEONE NEEDS TO HOLD ISUZU RESPONSIBLE FOR FAULTY REPAIRS AND A BOX TRUCK THAT PASSED INSPECTION BY ISUZU BUT IS NOT DRIVABLE.

Other Isuzu NPR model years

Check your 2015 Isuzu NPR VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Isuzu NPR at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Isuzu VIN