2016 Hyundai Santa FE Sport Recalls, Ratings & Complaints

Incident: October 31, 2026 · Filed: November 1, 2026

I was driving from Tampa to Wesley chapel Fl I was going about 70 and was pushing a bit then slowed down right away then I was speeding a little back up and my car was dropping to speed by itself I pulled over to the shoulder and it was leaking radiator fluid I was trying to crank it to see if I can make it work then it started smelling bad in the car so I turned it off right away and it was Smokey

Incident: October 11, 2026 · Filed: October 11, 2026

While driving I smelled gasoline then it turned to a burnt smell, engine turned off. Got to side of the road and engine caught fire. Firetrucks and police arrived. Car is totaled entire engine bay was up in flames. Car has been towed.

Incident: September 20, 2026 · Filed: September 21, 2026

Odometer Fraud. The contact purchased a 2016 Hyundai Santa Fe Sport. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the Facebook Marketplace advertisement and odometer reading were 114,841 miles. However, approximately one hour later, it was discovered that the title listed the mileage at 170,395.

Incident: August 12, 2026 · Filed: September 8, 2026

The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while the vehicle was parked, there was an abnormal knocking sound coming from the engine compartment. The vehicle was towed to a dealer where it was diagnosed that there was coolant in the engine and that the knock sensor detection system needed to be replaced. The dealer made the contact aware of Manufacturer Campaign Number: 953 and stated that the vehicle was not previously serviced under the campaign, so the vehicle could not be repaired. The manufacturer was notified of the failure. The failure mileage was approximately 111,000.

Incident: August 4, 2026 · Filed: September 3, 2026

Was traveling along a city street with parked cars on the passenger side of my vehicle. Axle or wheel broke and veered into parked vehicle severing the engine wiring harness not allowing the airbag to deploy.

Incident: August 8, 2026 · Filed: August 10, 2026

The contact owns a 2016 Hyundai Santa Fe Sport. The contact stated that while driving approximately 65 MPH and attempting to overtake another vehicle, the vehicle lost automotive power and decelerated with the check engine, battery, and oil warning lights illuminated. The vehicle was parked on the shoulder of the highway, and smoke was coming from under the hood of the vehicle. The contact stated that after parking on the shoulder, the brakes erroneously activated, and the vehicle failed to move forward. The contact stated that moments later there were flames and smoke was coming from under the hood. The contact exited the vehicle. The Fire Department was called to the scene, and the flames were extinguished by the firemen. The vehicle was destroyed in the fire. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The manufacturer and local dealer were not contacted. The failure mileage was 105,225.

Incident: July 27, 2026 · Filed: July 27, 2026

my BSD sensor would go on and off for the last several months when no one was around me. I work early and even when I was alone on the road the BSD would flash for 2-3 mins and go off.. then my fan for my air conditioner stopped. When I removed the glove compartment to see the wire connecting to the fan is "melted". When i called bob king hyundai, I was informed there was no recall. So, I attempted to fix the issue myself only to find the fuses (under the hood) are almost all bad. The tips of the fuses will not pull out. only the body of the fuse. With all this happening over the last several days and by the way, the vehicle passed inspection. I wanted to reach out as this is definitely a fire hazard and a huge concern.

Incident: May 13, 2026 · Filed: July 1, 2026

The engine (2016 Hyundai Santa Fe 2.0L/2.4L Theta II GDI engine) suffered a catastrophic internal mechanical failure, specifically related to the known connecting rod bearing defect. The vehicle is currently un-driveable and is located at Serra Hyundai in Trussville, AL. The vehicle and its failed engine are available for inspection upon request. The engine suddenly failed and lost all power while driving at highway speeds in active traffic. I was forced to coast a dead vehicle across multiple lanes of traffic to the shoulder without any acceleration capability. Yes. The vehicle experienced a complete failure, cannot be restarted, and is currently parked at an authorized Hyundai dealership The vehicle is currently at an authorized Hyundai dealership awaiting a formal corporate inspection and evaluation for engine replacement approval. It has not been inspected by police or insurance. There were no long-term warning lamps, messages, or symptoms prior to the incident. The vehicle was operating normally until the exact moment of the failure, when the engine suddenly began knocking loudly, lost power, and stalled within seconds.

Incident: May 22, 2026 · Filed: June 22, 2026

The vehicle is a 2016 Hyundai Santa Fe Sport. It had previously been included in an engine-fire-related recall/service campaign, and Hyundai replaced the engine between approximately October 2024 and January 2025 at about 113,000 miles. About 10,000 miles and 14 months later, the vehicle developed engine/performance problems. A Hyundai dealership service center performed about $6,500 in repairs, including installation of a new transmission, and represented that the engine and transmission had a lifetime guarantee. One day after the vehicle was returned from the dealership, the engine compartment caught fire while the vehicle was being driven. The fire rapidly escalated, the vehicle exploded/burned, and the vehicle was destroyed down to the frame. The occupants escaped, but the incident created an immediate risk of serious injury or death. The failed component appears to involve the engine, engine compartment, fuel/oil/electrical systems, transmission-related repair area, or another drivetrain component. The vehicle remains may be available for inspection depending on insurance/tow/storage status. The vehicle had recently been repaired and inspected by a Hyundai dealership service center. This incident raises concern that the recall-related engine-fire risk, replacement engine, recent dealership repairs, transmission installation, or related components may have failed and created a serious fire hazard.

Incident: June 15, 2026 · Filed: June 22, 2026

After driving the vehicle around all day, I parked it and turned it off and then it set on fire.