2022 Hyundai Santa FE Plug-In Hybrid Recalls & Complaints

Incident: August 14, 2026 · Filed: August 16, 2026

The car was shaking alot but the engine light was off. Started it the next dat and the check engine light came on. Went to auto zone to see what the codes were. The 1st and 3rd cylinder are misfiring. The car was just serviced for the 60,000 mile tune up in june 2026. This problem started August 14, 2026. The dealership is stating that the spark coils or cylinders are not under warranty even though it was just serviced

Incident: July 25, 2026 · Filed: August 6, 2026

2022 Hyundai Santa Fe Plug-in Hybrid, confirming the exact symptom “the gasoline engine continues running after the vehicle is switched off.” the vehicle is on and your burn fuel and if the fuel tank is full then some major issue may occur.

Incident: June 15, 2026 · Filed: June 16, 2026

My passenger's front door side vent window glass shattered unexplainably while I was making a left hand turn at 15 mph. This occurred at 7:25am in the morning after pulling my car out of my garage and driving about 1/3 mile before the unexplained glass explosion/shattering. The sound made was a loud bang/pop. Air temperature was around 68 degrees, no air conditioning was being used at the time. No other cars or pedestrians were around when it occurred. I inspected the glass and it does not appear as if there was any possibility it was caused by a rock or a projectile such as a bullet or bb gun. As mentioned the component that failed was a fixed vent window that does not open. Fortunately no passengers were in the car when the glass shattered. It has not been inspected since insurance will not cover the cost of the glass replacement. (Safelite glass to replace for $346.00 (my insurance deductible exceeds that amount). No warning signs before it occurred. (Possible manufacturing defect -impurities in glass? I don't think it was body flex or vibration which may have caused the explosion as I was driving only 15mph. I don't believe it is attributable to thermal stress either -due to no variation between internal and external air temperature)

Incident: February 6, 2026 · Filed: February 9, 2026

This is a 2022 Santa Fe PHEV with just 33k miles on it. While driving on freeway, vehicle displayed warning sign for "Check Hybrid System" and the Check Engine light and Battery light switched on. Sensing a loss of power with the acceleration, I managed to get off the freeway and had to get the vehicle towed to the nearest dealership. Once they checked the vehicle, they reported they had to recalibrate the HSG resolver motor and claimed the issue was now fixed. I collected the vehicle back from the dealership and to my horror, on the drive back home, the exact same problem resurfaced and I experienced a loss of power and stalling again. Now I have to tow the vehicle to another dealer again. Searching the internet for this problem shows that many other drivers have experienced and reported this issue, so I am recording my formal complaint. Twice in the space of a few days, I have experienced a safety issue that could have affected myself and my family and other drivers on the road. Hyundai needs to investigate and figure out the proper resolution for this failure and institute a recall to address ASAP.

Incident: May 15, 2025 · Filed: November 7, 2025

First the vehicle randomly lost all power and engine function, so was taken to the Hyundai service center. It was a safety issue as we had to coast to the margin in heavy traffic. Hyundai attempted a fix and returned it to us. It developed issues before we even got home. Now it is has been 6 months in the service center with continuously new issues. Every time they assure us it is fixed and we try to take it home, it develops another failure and the check engine light returns. The technicians have told us they have no explanation for the multiple failures and are not confident they can permanently fix the vehicle. The failures are unrelated and are with the manifold, gasket, CVVD,, oxygen sensor, and battery. A bolt also sheared off in this time frame and had to be drilled out. In the last failure, the car began smoking heavily and dripping oil. We've requested a replacement. Hyundai said they will not replace the vehicle (nor buy back) and it is acceptable that multiple systems and parts fail within 3 years.

Incident: July 20, 2025 · Filed: July 20, 2025

I have taken my Hyundai Santa Fe 2022 PHEV under warranty for a fix of being in reverse, the function not working, the car revs aggressively not in gear and then put it in park and the car aggressively jolts forward in park like a hard gear change. Hyundai replaced pcm and said it was fine. I took car and immediately noticed grinding noises and straight back to Hyundai. They claim it's fine. Today same issue with reversing and aggressive car jolting. Hyundai is going to take it back tomorrow. I do not feel safe in this vehicle. It felt like the transmission was going to give out on the freeway. The rpm are maxing out at 5-20 mph and sometimes don't want to engage in drive. Extremely unsafe for freeway driving. There is something terribly wrong with this cars engine or transmission. Unsafe for Hyundai to release for use.

Incident: June 22, 2025 · Filed: June 22, 2025

I believe my vehicle is part of the parking prawn recall. It jerked and jolt when in park very aggressively. When we proceeded to try to move the car in reverse it did not budge.

Incident: April 28, 2025 · Filed: May 30, 2025

The steering wheeled locked up and the dash showed error messages of check hybrid system and refill inverter coolant and car seemed to go into limp mode as I could barely accelerate forcing me to pull over. The messages and issue would go away upon turning off car and turning it back on, however the issue would eventually happen again. This has happened while driving on the highway and other various road situations without warning and making the vehicle very unsafe. I have taken my vehicle to Hyundai Ourisman in Bowie, Maryland (the dealership where I purchased the vehicle) three times over two years and they have failed to fix the problem. They have even replaced the battery in the car.

Incident: January 2, 2025 · Filed: January 5, 2025

Driving along, merging onto Interstate, various warnings such as check lane keeping assist, and warnings to stop vehicle and check brake systems. Driving approximately 50mph, the warning started to flash and speedometer dropped to zero then went back to full speed. Automatic braking was attempting to slow the car. Attached photo shows an indicated speed of 0mph, however was travelling approximately 50mph at this time. I also have video of the errors occurring, but there is not a way to upload video.

Incident: March 27, 2024 · Filed: April 3, 2024

Loss of acceleration while driving. This has occurred multiple times (always while moving or actively driving). The first time we were driving up a significant hill and the car slowed, lost power and we had to pull over and coast back down the mountain to a repair center. The second time, I was on the freeway and lost acceleration causing me to pull off the road in median. The third time, I was at a stoplight and when the light turned green, I had almost no movement after edging into the intersection. Eventually, at about 5 mph, the car regained speed. The check light went on in the first event and the car was supposedly repaired at the second dealership by re-tensioning "pins". However, no lights or warnings went on for incident #2 or #3 that occurred after the earlier repair effort. The vehicle is currently at the dealership service center for it's 7th day of "unable to replicate the problem" after incident #3.