NHTSA vehicle safety data

2010 Harley-Davidson Flht Recalls & Complaints

The 2010 Harley-Davidson Flht has 2 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Harley-Davidson dealer.

NHTSA recall and complaint data for the 2010 Harley-Davidson Flht. Recall data is refreshed daily from NHTSA.

2010 Harley-Davidson Flht owner complaints

Owners have filed 1 complaint with NHTSA about the 2010 Harley-Davidson Flht, describing incidents dated October 22, 2016.

Most-cited components

Service Brakes 1 complaint

Newest complaints

ODI #10918042 · Filed October 22, 2016
I PULLED OUT OF MY GARAGE ON MY 2010 ELECTRA GLIDE CLASSIC AND WHEN I ARRIVED AT THE STOP SIGN ON THE STREET AT APPROX 10 MPH I WENT TO APPLY MY FRONT BRAKE AND FOUND I COULD NOT MOVE MY FRONT BRAKE LEVER. LUCKILY MY REAR BRAKE HAD WORKED AND I WAS ABLE TO STOP MOTORCYCLE BEFORE AND DAMAGE OCCURRED…

Read the full complaint

NHTSA defect investigations

NHTSA's investigations file lists the 2010 Harley-Davidson Flht in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE16-009: Sudden Brake Failure - Motorcycle
Closed April 23, 2018
- Recall 18V-076

Open and recently closed NHTSA defect investigations

REAR BRAKE LAMP SWITCH

NHTSA #11V506000 · Exterior Lighting — Brake Lights — Switch · NHTSA notice

Reported October 19, 2011 · HARLEY-DAVIDSON MOTOR COMPANY

Potentially affected: 250,757 vehicles

Harley-Davidson campaign 0145 · Owners notified October 31, 2011 · Vehicles built June 6, 2008 – September 16, 2011 (per NHTSA)

Defect description

HARLEY-DAVIDSON IS RECALLING CERTAIN MODEL YEAR 2009-2012 TOURING, CVO TOURING AND TRIKE VEHICLES MANUFACTURED FROM JUNE 6, 2008, THROUGH SEPTEMBER 16, 2011. SEE THE ABOVE LIST FOR THE MODELS INCLUDED IN THE RECALL. THE REAR BRAKE LIGHT SWITCH MAY BE EXPOSED TO EXCESSIVE HEAT FROM THE EXHAUST SYSTEM.

Safety consequence

THE EXCESSIVE HEAT MAY CAUSE THE SWITCH TO NOT ACTIVATE THE BRAKE LAMP OR ACTIVATE THE BRAKE LAMP WHEN NO BRAKE IS APPLIED AND/OR CAUSE A BRAKE FLUID LEAK AT THE BRAKE LIGHT SWITCH, AFFECTING REAR BRAKE PERFORMANCE. EITHER CONDITION MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

HARLEY-DAVIDSON WILL NOTIFY OWNERS, AND DEALERS WILL A INSTALL A REAR BRAKE LIGHT SWITCH KIT, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 31, 2011. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

Notes

HARLEY-DAVIDSON SAFETY RECALL NUMBER IS 0145.CUSTOMERS OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRONT FUEL TANK MOUNTS/FUEL LEAK

NHTSA #09V457000 · Fuel System, Gasoline — Storage — Tank Assembly — Mounting · NHTSA notice

Reported December 1, 2009 · HARLEY-DAVIDSON MOTOR COMPANY

Potentially affected: 111,569 vehicles

Owners notified December 11, 2009 · Vehicles built June 6, 2008 – November 19, 2009 (per NHTSA)

Defect description

HARLEY-DAVIDSON IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 TOURING FAMILY MOTORCYCLES, INCLUDING CVO TOURING AND TRIKE PRODUCTS, MANUFACTURED FROM JUNE 6, 2008 THROUGH NOVEMBER 19, 2009. THE FRONT FUEL TANK MOUNTS MAY DISTORT IN REACTION TO SEVERE FRAME DAMAGE FROM A FRONTAL COLLISION. THIS CONDITION MAY CAUSE A FUEL LEAK AT THE WELD OF THE FRONT BRACKET TO THE TUNNEL.

Safety consequence

A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE, WHICH COULD LEAD TO INJURY OR DEATH TO THE RIDER.

Manufacturer remedy

DEALERS WILL INSTALL A LEFT AND RIGHT BRACE, WHICH ARE INTENDED TO REDUCE FRONT MOUNT DISTORTION DURING CERTAIN CRASH CONDITIONS. THIS REPAIR WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2010 Harley-Davidson Flht. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2010 Harley-Davidson Flht.

Service Brakes

ODI #10918042

Incident: October 22, 2016 · Filed: October 22, 2016

I PULLED OUT OF MY GARAGE ON MY 2010 ELECTRA GLIDE CLASSIC AND WHEN I ARRIVED AT THE STOP SIGN ON THE STREET AT APPROX 10 MPH I WENT TO APPLY MY FRONT BRAKE AND FOUND I COULD NOT MOVE MY FRONT BRAKE LEVER. LUCKILY MY REAR BRAKE HAD WORKED AND I WAS ABLE TO STOP MOTORCYCLE BEFORE AND DAMAGE OCCURRED. THERE WAS NO APPARENT ISSUES WITH MY BRAKE SYSTEM (NO FLUID LEAKS) SO I CALLED MY HD DEALER AND THEY HAD TOLD ME MY ABS MODULE HAD FAILED DUE TO LACK OF CHANGING MY BRAKE FLUID AND NEEDS TO BE REPLACED. I HAVE OWNED MANY VEHICLES WITH ABS BRAKING OVER THE YEARS, AND CONTINUE TO OWN ABS BRAKING VEHICLES, AND HAVE NEVER HAD TO, OR REQUIRED TO CHANGE MY BRAKE FLUID TO PREVENT A CATASTROPHIC EVENT. YOU WOULD THINK THAT A MOTORCYCLE WITHOUT BRAKES IS AN EXTREMELY HAZARDOUS EVENT, AND IF HARLEY DAVIDSON KNEW THAT IF YOU DID NOT REPLACE THE BRAKE FLUID EVERY 2 YEARS YOUR BRAKE SYSTEM WOULD FAIL, THAT THEY WOULD BE VERY CLEAR IN LETTING ME KNOW THIS BOTH VERBALLY WHEN I PURCHASED THE BIKE, AND WITH SOME KIND OF SIGNAGE SOMEWHERE OBVIOUS ON THE BIKE TO STATE THAT IF YOU DON'T REPLACE BRAKE FLUID YOUR BRAKES WOULD FAIL.

Other Harley-Davidson Flht model years

Check your 2010 Harley-Davidson Flht VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Harley-Davidson Flht at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Harley-Davidson VIN