try.vin
Log in

NHTSA vehicle safety data

2000 Gulf Stream Sun Voyager Recalls & Complaints

The 2000 Gulf Stream Sun Voyager has 3 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Gulf Stream dealer.

NHTSA recall and complaint data for the 2000 Gulf Stream Sun Voyager. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2000 Gulf Stream Sun Voyager owner complaints

Owners have filed 2 complaints with NHTSA about the 2000 Gulf Stream Sun Voyager, describing incidents dated December 7, 2001 to October 19, 2006.

Most-cited components

  • Suspension 2 complaints
  • Engine 1 complaint
  • Equipment 1 complaint
  • Power Train 1 complaint
  • Structure 1 complaint

Newest complaints

  • ODI #10172523 · Filed

    DT*: THE CONTACT STATED WHILE DRIVING 55 MPH, THE MOTOR HOME BEGAN TO ROCK FROM SIDE TO SIDE. AS THE VEHICLE SLOWED, THE ROCKING SUBSIDED. AS THE VEHICLE SPED UP, THE ROCKING BECAME WORSE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER WAS UNABLE TO DETERMINE THE PROBLEM.*AK UPDATED…

  • ODI #8003939 · Filed

    SEVERE PROBLEM WITH LOSS OF CONTROL WHILE DRIVNG ON RUGGED ROAD AT ANY SPEED, ALSO WHILE DRIVING 60 MPH OR MORE IN HIGH WINDS IT IS HARD TO CONTROL. DEALER WAS NOTIFIED. *AK CONSUMER STATED THERE IS AN EXHAUST SMELL INSIDE OF RV, THERE IS ALSO A NOISE IN DRIVE TRAIN, DRIVERS SEAT WILL NOT ADJUST…

Read all 2 complaints

REFRIGERATOR/FIRE/NORCOLD

NHTSA #08V383000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported August 5, 2008 · GULF STREAM COACH, INC.

Potentially affected: 413 vehicles

Owners notified August 15, 2008 · Vehicles built March 1, 1999 – April 30, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

GULF STREAM IS RECALLING 413 MY 1999-2002 SUN VOYAGER, SCENIC CRUISE, FRIENDSHIP, AND TOUR MASTER MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Safety consequence

EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Manufacturer remedy

GULF STREAM IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E030). NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT NORCOLD AT 1-800-767- 9101 OR GULF STREAM AT 1-574-773-7761.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #07V136000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported March 20, 2007 · GULF STREAM COACH, INC.

Potentially affected: 38,767 vehicles

Owners notified June 28, 2007 · Vehicles built April 1, 1997 – August 31, 2003 (per NHTSA)

Defect description

CERTAIN MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Manufacturer remedy

GULF STREAM WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. THE RECALL BEGAN ON JUNE 28, 2007. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR GULF STREAM AT 1-574-773-7761.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GULF STREAM/BRAKE SYSTEM WARNING INDICATOR

NHTSA #03V092000 · Service Brakes, Hydraulic — Brake Fluid Low Warning — Lamp · NHTSA notice

Reported March 12, 2003 · GULF STREAM COACH INC.

Potentially affected: 998 vehicles

Owners notified May 1, 2003 · Vehicles built September 21, 1999 – March 11, 2003 (per NHTSA)

Defect description

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Safety consequence

IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Manufacturer remedy

DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION IS BEGAN MAY 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GULF STREAM AT 1-574-773-7761.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Gulf Stream Sun Voyager model years

Check your 2000 Gulf Stream Sun Voyager VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Gulf Stream Sun Voyager at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Gulf Stream VIN