NHTSA vehicle safety data

2002 GMC Safari Recalls, Ratings & Complaints

The 2002 GMC Safari has 3 NHTSA recall campaigns and 25 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2002 GMC Safari, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2002 GMC Safari owner complaints

Owners have filed 25 complaints with NHTSA about the 2002 GMC Safari, describing incidents dated May 22, 2001 to October 31, 2017.

Most-cited components

Service Brakes 12 complaints
Suspension 4 complaints
Electrical System 3 complaints
Visibility/Wiper 3 complaints
Air Bags 2 complaints
Equipment 2 complaints

Of the 25 complaints on file, 4 report a crash and 1 a fire; across all 25 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11046293 · Filed November 15, 2017
TL* THE CONTACT OWNS A 2002 GMC SAFARI. WHILE DRIVING 45 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE DRIVER'S SIDE BY A 2006 DODGE CARAVAN. THE CONTACT'S VEHICLE THEN CRASHED INTO A POLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED LOWER BACK PAIN, A BRUISED TOE, A FOREHEAD GASH, AND DAMAGE…
ODI #10546772 · Filed October 4, 2013
FRONT BRAKE LINE RUSTED OUT AND FAILED, NECESSITATING EXPENSIVE REPAIR AND REPLACEMENT. *TR
ODI #10273158 · Filed June 8, 2009
MY 2002 GMC SAFARI WOULD NOT START. I WENT AND REPLACED THE 2.5 YEAR OLD BATTERY (IT WAS LEAKING AT THE TERMINALS) IT STARTED ONE TIME AND THEN ABOUT 45 MINUTES LATER IT WAS DEAD AGAIN. IT WAS TOWED TO THE DEALER. I WAS FIRST INFORMED THAT THE CHARGING SYSTEM WAS O.K. AND THAT THE PROBABLE CAUSE WAS…

Read all 25 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2002 GMC Safari in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE04-072: LOSS OF BRAKE LAMP ILLUMINATION
Closed March 21, 2005
- Recall 05V-099

Open and recently closed NHTSA defect investigations

AFTERMARKET FUEL FILTERS/FUEL LEAK

NHTSA #06E043000 · Fuel System, Gasoline · NHTSA notice

Reported May 19, 2006 · HONEYWELL INTERNATIONAL, INC.

Potentially affected: 88,303 vehicles

Owners notified October 18, 2006

Defect description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Safety consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Manufacturer remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

STOP LAMP/HAZARD LAMP CIRCUIT

NHTSA #05V099000 · Exterior Lighting — Brake Lights — Switch · NHTSA notice

Reported March 14, 2005 · GENERAL MOTORS CORP.

Potentially affected: 77,055 vehicles

Manufacturer campaign 05013 · Owners notified April 13, 2005 · Vehicles built March 1, 2001 – August 31, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.

Safety consequence

THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Notes

GM RECALL NO. 05013.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2002 GMC Safari

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

1 investigation

25 owner complaints have been filed with NHTSA for the 2002 GMC Safari.

Air Bags

ODI #11046293

Crash 1 injury

Incident: October 31, 2017 · Filed: November 15, 2017

TL* THE CONTACT OWNS A 2002 GMC SAFARI. WHILE DRIVING 45 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE DRIVER'S SIDE BY A 2006 DODGE CARAVAN. THE CONTACT'S VEHICLE THEN CRASHED INTO A POLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED LOWER BACK PAIN, A BRUISED TOE, A FOREHEAD GASH, AND DAMAGE TO THE RIBS. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. *TT UPDATED 8/21/18*JB

Service Brakes

ODI #10546772

Incident: April 2, 2013 · Filed: October 4, 2013

FRONT BRAKE LINE RUSTED OUT AND FAILED, NECESSITATING EXPENSIVE REPAIR AND REPLACEMENT. *TR

Service Brakes, Hydraulic

ODI #10273158

Incident: May 16, 2009 · Filed: June 8, 2009

MY 2002 GMC SAFARI WOULD NOT START. I WENT AND REPLACED THE 2.5 YEAR OLD BATTERY (IT WAS LEAKING AT THE TERMINALS) IT STARTED ONE TIME AND THEN ABOUT 45 MINUTES LATER IT WAS DEAD AGAIN. IT WAS TOWED TO THE DEALER. I WAS FIRST INFORMED THAT THE CHARGING SYSTEM WAS O.K. AND THAT THE PROBABLE CAUSE WAS THE BATTERY WAS NOT FULLY CHARGED. I WAS THEN INFORMED THAT THE BRAKE LIGHT WAS ON THE DASH AND A BRAKE LINING WAS LEAKING. THEY RECOMMENDED TO REPLACE BOTH LININGS AND FLUSH THE SYSTEM AND FILL WITH FRESH FLUID. AFTER SEVERAL HOURS I WAS TOLD THAT WHEN THE PARTS CAME AND THE TECH WAS TO INSTALL THE LININGS THAT THE FLUID WAS SMOKING AND THE TECH ALMOST BURNED HIS HANDS. THE VEHICLE WAS ON THE LIFT THREE HOURS FOR THIS TO HAPPEN. THE SERVICE REP COULD NOT EXPLAIN HOW THIS HAPPENED. I WAS TOLD THAT GM TOLD THEM TO CHECK THE POSITIVE CABLE FOR GROUNDING. THEY FOUND IT WAS GROUNDING ON THE CENTER LINK OF THE STEERING. THE WORK ORDER SAID THEY RE-ROUTED THE CABLE. I WAS TOLD BY A GM REP IN ARGENTINA THAT GM FELT THAT AFTER THE TIME AND MILEAGE THAT THEY WERE NOT RESPONSIBLE. I TOLD HIM THAT IF THE CABLE HAD BEEN PROPERLY ROUTED AT THE TIME OF MANUFACTURE THAT THIS WOULD NOT HAVE HAPPENED REGARDLESS OF THE TIME AND/OR MILES. I AM THANKFUL THAT THE FLUID HAD NOT LEAKED OUT OR BOILED TO THE POINT THAT I WOULD HAVE HAD BRAKE FAILURE. I FEEL IT COST ME ALL MOST $700. AT THIS POINT THAT WAS DO TO THE ROUTING OF THE CABLE AND WOULD LIKE TO BE REIMBURSED. THE GM REP SAID I COULD GO TO THE BETTER BUSINESS BUREAU THAT HE COULD DO NOTHING. CAN YOU HELP OR TELL ME WHERE I CAN GO FOR HELP? THANK YOU. *TR

Steering; Suspension; Service Brakes, Hydraulic

ODI #10224784

Incident: March 11, 2008 · Filed: April 17, 2008

TL*THE CONTACT OWNS A 2002 GMC SAFARI. WHILE DRIVING 5 OR 6 MPH, IT TOOK 40-50 FEET BEFORE THE CONTACT COULD STOP THE VEHICLE. A MECHANIC STATED THAT BOTH THE PASSENGER AND DRIVER SIDE WHEEL BEARINGS AND IDLER ARMS NEEDED TO BE REPLACED. THE LOCAL MECHANIC PERFORMED THE REPAIRS. GMC DENIED HIM REIMBURSEMENT BECAUSE THEY DID NOT MAKE THE REPAIR. THE CONSUMER HAD THE REPAIRS MADE A AN INDEPENDENT SHOP THE CURRENT MILEAGE WAS 28,550 AND FAILURE MILEAGE WAS 28,530. UPDATED 5/5/08 *CN UPDATED

Exterior Lighting

ODI #10219097

Incident: January 1, 2006 · Filed: February 25, 2008

TL*THE CONTACT OWNS A 2002 GMC SAFARI. THE CONTACT STATED THAT THE BRAKE LIGHTS WORKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THEY STATED THAT THE REPAIR REQUIRED THEM TO DISMANTLE SOME OF THE MAJOR COMPONENTS TO BETTER ACCESS THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED REQUESTING INFORMATION ON NHTSA CAMPAIGN ID NUMBER 05V099000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE CURRENT MILEAGE WAS 44,500 AND FAILURE MILEAGE WAS 28,000. UPDATED 03/26/08. *LJ

Service Brakes, Hydraulic

ODI #10190480

Incident: May 2, 2003 · Filed: May 11, 2007

TL*THE CONTACT OWNS A 2002 GMC SAFARI. THE CONTACT STATED THAT THE VEHICLE'S BRAKES SQUEAKED AND SHE HAD THE BRAKE PADS REPLACED. THE PADS WERE REPLACED A SECOND TIME AT 40,000 MILES. THE BRAKES CONTINUE TO SQUEAK. THE VEHICLE'S PURCHASE DATE AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 68,000 AND FAILURE MILEAGE WAS 22,000.

Power Train

ODI #10153709

Incident: August 1, 2003 · Filed: March 25, 2006

HAD TO REPLACE TRANSMISSION AT 39,000 MILES. THEN AGAIN AT 131,000 MILES. NOW IT IS BACK IN THE SHOP WITH TRANSMISSION PROBLEMS YET TO BE DETERMINED AT 149,000 MILES. JUDGING FROM THE COMPLAINTS ON THE INTERNET, THIS SEEMS TO BE A DEFECT THAT IS COSTING THE CONSUMER A BUNDLE OF MONEY. SO FAR I HAVE SPENT OVER $3000 TO REPAIR THE TRANSMISSION. I AM NOW WAITING TO HEAR HOW MUCH MORE I WILL HAVE TO SPEND. THIS NEEDS TO BE INVESTIGATED. *JB

Suspension; Service Brakes, Hydraulic

ODI #10148491

Incident: January 9, 2006 · Filed: January 24, 2006

WHEN BACKING OUT OF GARAGE BRAKES FAILED AND THE PEDAL WENT ALL THE WAY TO THE FLOOR. DEALER TOLD ME THERE WAS NO BRAKE PROBLEMS, BUT COULD BE ABS SENSORS RUSTED OR HAD DIRT BUILD UP. THE DEALER CLEANED ABS SENSORS AND SPRAYED A RUST INHIBITOR ON SENSORS AND HUBS , AND SAID THEY HOPED THIS WOULD SOLVE THE PROBLEM. IF PROBLEM PERSISTS TO COME BACK.*AK

Service Brakes, Hydraulic

ODI #10147236

Incident: December 29, 2005 · Filed: January 9, 2006

I WAS VERY NEARLY BROADSIDED WHEN MY VEHICLE'S ANTI LOCK BRAKE SENSOR FAILED WHEN ATTEMPTING TO STOP AT AN INTERSECTION OF A SECONDARY ROAD WITH A STATE HIGHWAY. MY VEHICLE PROCEEDED INTO THE INTERSECTION AT A VERY SLOW RATE OF SPEED WHILE MY BRAKE WAS PUSHED TO THE FLOOR. I HAVE SUBSEQUENTLY DISCOVERED THAT THERE HAS BEEN A RECALL FOR THIS PROBLEM BUT THAT IT IS LIMITED TO SELECTED STATES AND THE DISTRICT OF COLUMBIA. I LIVE IN THE ADIRONDACK PARK IN UPSTATE NY WHERE TOWNS USE DIRT ONLY ON ITS ROADS. I CAN'T IMAGINE A WORST SITUATION FOR THIS CONDITION TO OCCUR THAN THE COMBINATION OF SALT AND DIRT (LIKE DC I SUPPOSE). HOW MANY CRASHES OR FATALITIES ARE REQUIRED IN EACH STATE ON KNOWN PROBLEMS BEFORE RECALLS ARE EXPANDED? *JB

Service Brakes, Hydraulic

ODI #10145325

Filed: November 29, 2005

2002 GMC SAFARI BRAKES WOULD NOT PERFORM PROPERLY. *TS ***NO ANSWER REQUIRED*** THE BRAKES WOULD NOT STOP THE VEHICLE AND RESULTED IN EXTENDED STOPPING DISTANCE. THE CONSUMER MENTIONED THIS PROBLEM TO THE DEALER SEVERAL TIMES BUT EACH TIME THEY CLAIMED THAT NO PROBLEM WAS FOUND. THE CONSUMER HEARD OF THE RECALL ON SOME GMC VEHICLE'S BUT SOON FOUND OUT THE HER VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. * NM

Other GMC Safari model years

Check your 2002 GMC Safari VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Safari at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN