NHTSA vehicle safety data

2006 GMC Envoy XL Recalls, Ratings & Complaints

The 2006 GMC Envoy XL has 5 NHTSA recall campaigns and 109 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized GMC dealer.

NHTSA recall and complaint data for the 2006 GMC Envoy XL, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 GMC Envoy XL owner complaints

Owners have filed 109 complaints with NHTSA about the 2006 GMC Envoy XL, describing incidents dated November 23, 2005 to March 27, 2019.

Most-cited components

Fuel/Propulsion System 71 complaints
Electrical System 23 complaints
Visibility/Wiper 8 complaints
Electronic Stability Control (ESC) 5 complaints
Engine 5 complaints
Exterior Lighting 4 complaints

Of the 109 complaints on file, 3 report a crash and 2 a fire; across all 109 complaints, owners report 4 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11210852 · Filed May 30, 2019
ON HIGHWAY US-31 IN MUSKEGON COUNTY MICHIGAN, VEHICLE (ENVOY) WAS AT ALMOST A COMPLETE STOP FOR A VEHICLE STOPPED AHEAD WHEN STRUCK FROM BEHIND BY ANOTHER VEHICLE TRAVELLING AT 70+ MPH. THE ENVOY WAS THEN PUSHED INTO THE VEHICLE IN FRONT OF THE ENVOY. THE ENVOY SUFFERED MAJOR REAR END DAMAGE AND…
ODI #11206098 · Filed May 7, 2019
STEERING WHEEL LOCKS. IT CANNOT BE TURNED TO THE RIGHT AS IT WILL CAUSE THE ENTIRE CARE TO SWERVE. WHEN REVERSING THE CAR TURNS IN THE OPPOSITE DIRECTION OF WHERE YOU ARE TURNING. I'M BACKING INTO TRAFFIC AND HAVE TO MANUALLY PULL THE STEERING WHEEL AS IF THERE IS A POWER STEERING ISSUE. ENGINE…
ODI #11204939 · Filed May 1, 2019
2006 GMC ENVOY ENGINE SHUTS OFF WHILE DRIVING CODE PO601 FIND OUT IT'S THE PCM

Read all 109 complaints

Owner-reported

2006 GMC Envoy XL mileage at failure

94 of the 109 complaints on file for the 2006 GMC Envoy XL give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Fuel/Propulsion System	Median 60,000 miles	Middle half 45,000–80,000 miles	Based on 63 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 GMC Envoy XL in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Recall Query RQ17-002: Loss of Headlights
Closed March 29, 2021
Engineering Analysis EA12-004: Driver's Master Power Window Switch
Closed June 21, 2013
- Recall 12V-406
- Recall 13V-248
Defect Petition DP10-001: Fuel Level Gauge System Failure
Closed May 23, 2011

Open and recently closed NHTSA defect investigations

Driver's Master Power Window Switch may Short

NHTSA #15V599000 · Visibility — Power Window Devices and Controls · NHTSA notice

Reported September 24, 2015 · General Motors LLC

Potentially affected: 9,932 vehicles

Repair completion: 60.73% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 15700 · Owners notified November 2, 2015 · Vehicles built June 2, 2005 – June 11, 2006 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.

Safety consequence

The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.

Manufacturer remedy

GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Headlamps may Fail

NHTSA #15V519000 · Exterior Lighting — Headlights · NHTSA notice

Reported August 14, 2015 · General Motors LLC

Potentially affected: 429,170 vehicles

Repair completion: 51.17% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14291 · Owners notified May 17, 2016 · Vehicles built December 1, 2005 – February 20, 2006 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.

Safety consequence

Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.

Manufacturer remedy

GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver's Master Power Window Switch may Short

NHTSA #14V404000 · Visibility — Power Window Devices and Controls · NHTSA notice

Reported July 2, 2014 · General Motors LLC

Potentially affected: 184,611 vehicles

Repair completion: 66.72% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign 14309 · Owners notified October 3, 2014 · Vehicles built May 17, 2005 – February 20, 2006 (per NHTSA)

Defect description

General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Safety consequence

A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Manufacturer remedy

GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver's Master Power Window Switch

NHTSA #13V248000 · Electrical System · NHTSA notice

Reported June 13, 2013 · General Motors LLC

Potentially affected: 193,652 vehicles

Manufacturer campaign 12180 · Owners notified August 2, 2013 · Vehicles built May 17, 2005 – February 20, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Safety consequence

Manufacturer remedy

Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

Notes

Owners may also contact the National Highway Traffic Safety Administration's Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153), or go to www.safercar.gov.

POWER STEERING HOSE

NHTSA #05V455000 · Steering — Hydraulic Power Assist — Hose, Piping, and Connections · NHTSA notice

Reported October 5, 2005 · GENERAL MOTORS CORP.

Potentially affected: 123,592 vehicles

Manufacturer campaign 05086 · Owners notified October 14, 2005 · Vehicles built July 1, 2005 – August 31, 2005 (per NHTSA)

Defect description

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.

Safety consequence

IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.

Manufacturer remedy

DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.

Notes

GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 GMC Envoy XL 4-DR

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

Electronic Stability Control

4 investigations

109 owner complaints have been filed with NHTSA for the 2006 GMC Envoy XL.

Air Bags; Seat Belts; Structure

ODI #11210852

Crash 3 injuries

Incident: August 21, 2018 · Filed: May 30, 2019

ON HIGHWAY US-31 IN MUSKEGON COUNTY MICHIGAN, VEHICLE (ENVOY) WAS AT ALMOST A COMPLETE STOP FOR A VEHICLE STOPPED AHEAD WHEN STRUCK FROM BEHIND BY ANOTHER VEHICLE TRAVELLING AT 70+ MPH. THE ENVOY WAS THEN PUSHED INTO THE VEHICLE IN FRONT OF THE ENVOY. THE ENVOY SUFFERED MAJOR REAR END DAMAGE AND SEVERE FRONT END DAMAGE. NONE OF THE FRONT AIRBAGS DEPLOYED. BOTH FRONT DRIVER AND PASSENGER SEATBELTS DID NOT RESTRAIN. THE SEATBELTS STRETCHED OUT TO THEIR LIMIT. BOTH FRONT DRIVER'S SEAT AND PASSENGER SEAT TWISTED INWARDS TOWARD THE CONSOLE. SEVERE BODILY INJURIES OCCURRED. ON 08/23/2018, GMC WAS MADE AWARE OF THIS. A CASE WAS OPENED. THE EVENT DATA RECORDER WAS RECOVERED BY GMC. THE EDR SHOWED THE IMPACT VELOCITY, NON-DEPLOYMENT OF AIRBAGS AND NON-RESTRAINT OF SEATBELTS. GMC THEN CLOSED THE CASE STATING THAT BECAUSE THERE WAS NO TRAUMATIC BRAIN INJURY, THERE WOULD BE NO FURTHER INVESTIGATION OR COMPENSATION. THE 2006 GMC ENVOY WAS DEEMED A TOTAL LOSS BY THE AUTO INSURER.

Steering; Electronic Stability Control (ESC); Fuel/Propulsion System

ODI #11206098

Incident: March 27, 2019 · Filed: May 7, 2019

STEERING WHEEL LOCKS. IT CANNOT BE TURNED TO THE RIGHT AS IT WILL CAUSE THE ENTIRE CARE TO SWERVE. WHEN REVERSING THE CAR TURNS IN THE OPPOSITE DIRECTION OF WHERE YOU ARE TURNING. I'M BACKING INTO TRAFFIC AND HAVE TO MANUALLY PULL THE STEERING WHEEL AS IF THERE IS A POWER STEERING ISSUE. ENGINE LIGHT CAME ON DAY AFTER PURCHASE INDICATING I NEED CATALYST CONVERTER AND SENSOR. NO WAY TO PREDICT WHICH WAY THE CAR WILL TURN. IF I HIT A BUMP THE CAR SWERVES TO THE RIGHT CAUSING ME TO SWERVE INTO NEXT LANE. IN MOTION I AM CONSTANTLY SWERVING INTO DANGER.

Electrical System

ODI #11204939

Incident: August 15, 2018 · Filed: May 1, 2019

2006 GMC ENVOY ENGINE SHUTS OFF WHILE DRIVING CODE PO601 FIND OUT IT'S THE PCM

Suspension; Exterior Lighting; Wheels

ODI #11067043

Crash

Incident: January 28, 2018 · Filed: February 5, 2018

I PURCHASED THIS VEHICLE WITH NEW TIRES ON IT. EXCESSIVE TIRE WEAR WAS STARTING ON THE DRIVERS SIDE TIRE BEFORE THE YEAR MARK OF ME PURCHASING IT. THERE WAS NO RECALLS OPEN ON THAT TIME THAT WE COULD FIND. I HAVE HAD TO REPLACE THE FOG LIGHTS ON SEVERAL OCCASIONS. IT HAD ELECTRICAL SHORT THAT NO ONE SEEMED TO FIND AND THERE WAS NO WAY TO LOCATE WITHOUT EXPENSIVE DIAGNOSTIC TIME. WHEN I WENT TO THE DEALER ABOUT RECALLS THEY INFORMED ME THE ONLY OPEN WAS A WINDOW SWITCH. AFTER A FRONT END ACCIDENT AT 30 MPH THE TIRE BLEW OUT ON THE DRIVERS SIDE ON IMPACT. I WAS INFORMED IN MY ESTIMATE THAT THERE WAS A OPEN RECALL WHICH COULD LEAD TO INCORRECT RIM SELECTION / TIRES FOR THE CAR CAUSING AIR LEAKAGE AND POSSIBLE ACCIDENT. IF I HAD KNOWN THIS BEFORE HAND MAYBE THIS COULD HAVE BEEN PREVENTED!

Structure; Visibility/Wiper

ODI #11048558

Incident: October 30, 2017 · Filed: November 27, 2017

TL* THE CONTACT OWNS A 2006 GMC ENVOY XL. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE DOOR SWITCH FAILED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V599000 (VISIBILITY). THE VEHICLE WAS TAKEN TO CITY BUICK GMC (43-60 NORTHERN BLVD, LONG ISLAND CITY, NY 11101 AT (347) 670-4210) AND REPAIRED; HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE FRONTAL DRIVER'S SIDE DOOR SWITCH WAS INOPERABLE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT TOOK THE VEHICLE TO ANOTHER INDEPENDENT MECHANIC FOR A SECOND OPINION WHERE IT WAS DIAGNOSED THAT THE MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS OPENED. THE APPROXIMATE FAILURE MILEAGE WAS 161,000.

Electronic Stability Control (ESC); Engine

ODI #10983824

Incident: May 6, 2017 · Filed: May 6, 2017

I AM SO SICK OF MY 06 GMC ENVOY XL. I TRULY GIVE UP. I HAD THE STABILITRAK AND REDUCED ENGINE LIGHT COME ON MY CAR FOR FIVE MONTHS. I HAVE REPLACED THE STEERING WHEEL SENSOR, THE THROTTLE BODY, AND HAD THE RELEARN THE IDLE THING DONE, TO NO AVAIL. THIS MAKES MY FOURTH TIME GOING TO THE DEALER, BECAUSE I THOUGHT THEY COULD FIX IT. I HAVE ALWAYS BOUGHT GM. IF GOD BLESSES ME WITH ANOTHER OPPORTUNITY TO BUY A CAR, IT WILL NOT BE A GM. IT THROWS MY CAR OFF. I'VE HAD TO PULL OVER AND START THE CAR OVER A THOUSAND TIMES. I'VE SEEN MANY FORUMS ONLINE ABOUT THIS PROBLEM, BUT THERE IS NO RECALL? I'VE EVEN CALLED GM. I STILL HAD TO PAY MONEY. RESETTING THE COMPUTER HAS DONE ABSOLUTELY NOTHING. JUST WANTED TO RANT, BECAUSE BESIDES GIVING ME SOME OF MY MONEY BACK (TO THE TUNE OF A GRAND), WHAT CAN I DO?

Visibility/Wiper

ODI #10906097

Incident: September 10, 2016 · Filed: September 13, 2016

TL* THE CONTACT OWNS A 2006 GMC ENVOY XL. THE CONTACT STATED THAT THE FRONT DRIVER SIDE POWER WINDOW SWITCH FAILED TO OPERATE INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 14V404000 (VISIBILITY). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V599000 (VISIBILITY). THE FAILURE MILEAGE WAS 170,000.

Electrical System

ODI #10888234

Incident: July 25, 2016 · Filed: July 25, 2016

TL* THE CONTACT OWNS A 2006 GMC ENVOY XL. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. IN ORDER TO RESTART THE VEHICLE, THE CONTACT WOULD HAVE TO JUMPSTART THE BATTERY. SHORTLY AFTER CHARGING THE BATTERY, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO STATED THAT THE ALTERNATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

Fuel/Propulsion System

ODI #10885427

Incident: May 5, 2016 · Filed: July 18, 2016

DRIVING ON THE HIGHWAY AFTER PUTTING FUEL IN AND FUEL GAUGE SUDDENLY SHOWS EMPTY AND MY VEHICLE STALLED. THE FUEL GUAGE WOULD THEN SHOW FULL AT TIMES THEN EMPTY. NOW IT SHOWS EMPTY ALL THE TIME AND HAS STALLED 3 MORE TIMES WHILE DRIVING IN TRAFFIC.

Electrical System; Exterior Lighting

ODI #10808107

Incident: January 2, 2013 · Filed: December 3, 2015

ALL EXTERIOR LIGHTS FLICKER AND FAIL INTERMITTENTLY, USUALLY WHILE DECELERATING, OR APPLYING BRAKES. HAS BEEN HAPPENING FOR 18 MONTHS. CURRENT MILEAGE 155,000

Other GMC Envoy XL model years

Check your 2006 GMC Envoy XL VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Envoy XL at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN