NHTSA vehicle safety data

2005 Georgie BOY Cruise Master Recalls & Complaints

The 2005 Georgie BOY Cruise Master has 7 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Georgie BOY dealer.

NHTSA recall and complaint data for the 2005 Georgie BOY Cruise Master. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Georgie BOY Cruise Master owner complaints

Owners have filed 3 complaints with NHTSA about the 2005 Georgie BOY Cruise Master, describing incidents dated April 4, 2005 to August 5, 2009.

Most-cited components

Equipment 1 complaint
Fuel/Propulsion System 1 complaint
Service Brakes 1 complaint

Newest complaints

ODI #10350733 · Filed August 20, 2010
TL* THE CONTACT OWNS A 2005 GEORGIE BOY CRUISE MASTER MOTOR HOME WITH A WORKHORSE CHASSIS. THE CONTACT WAS DRIVING 55-60 MPH WHEN HE APPLIED THE BRAKES AND THE PEDAL FELL ABNORMALLY FARTHER INTO THE FLOORBOARD THAN USUAL. ALL WARNING LIGHTS WERE ILLUMINATED AT THE TIME OF THE FAILURE. THE CONTACT…
ODI #10156280 · Filed April 21, 2006
THE CONSUMER HAS HAD NUMEROUS PROBLEMS WITH HER GEORGIE BOY MOTORHOME. SOME OF THE PROBLEMS INCLUDE LOOSE DOOR LOCKS AND POP OUT WALL THAT WOULD NOT AUTOMATICALLY, ETC. *NM THE CONSUMER NOTICED GRAY WATER LEAKING FROM UNDER THE HOLDING TANK AND WAS FLOODING THE BACK BATHROOM. ON ONE OCCASION, THE…
ODI #10142762 · Filed November 15, 2005
DT: THE CONTACT STATES WHILE PERFORMING MAINTENANCE HE DISCOVERED THE FUEL LINE WAS RUBBING THE FLOOR OF THE RV. THE SHARP PART OF THE METAL FLOORING HAD BEGUN TO WEAR INTO THE FUEL LINE. HE DID NOT TAKE THE VEHICLE TO THE DEALER. HE PERFORMED PREVENTIVE MEASURES BY CUTTING BACK THE FLOOR BOARD AND…

Read all 3 complaints

OVERHEATED BRAKE CALIPERS/BOSCH/WORKHORSE

NHTSA #09V193000 · Service Brakes, Hydraulic — Fluid · NHTSA notice

Reported June 2, 2009 · COACHMEN RV COMPANY, LLC

Potentially affected: 2,555 vehicles

Owners notified May 1, 2009 · Vehicles built August 1, 2000 – May 31, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

COACHMEN IS RECALLING 2,555 MY 2000-2009 GEORGIE BOY AND COACHMEN RECREATIONAL TRAILERS EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Safety consequence

THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR COACHMEN AT 1-574-266-4030, option 5.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SHOWER DOOR TOWEL BAR

NHTSA #08V639000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported December 4, 2008 · COACHMEN RV COMPANY, LLC

Potentially affected: 13,662 vehicles

Owners notified February 9, 2009 · Vehicles built June 15, 2001 – August 6, 2007 (per NHTSA)

Defect description

COACHMEN IS RECALLING 13,662 MY 2002-2008 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH GLASS SHOWER DOORS AND MANUFACTURED FROM JUNE 15, 2001 THORUGH AUGUST 6, 2007. WHEN PRESSURE IS APPLIED TO THE TOWEL BAR ON THE GLASS SHOWER DOOR, THE EDGE OF THE BAR MAY CONTACT THE GLASS.

Safety consequence

GLASS BREAKAGE MAY OCCUR WHICH COULD CAUSE PERSONAL INJURY.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH NEW MOUNTING HARDWARE FOR THE TOWEL BAR AND INSTALLATION INSTRUCTIONS. IF AN OWNER IS NOT COMFORTABLE REPLACING THE HARDWARE THEMSELVES, A DEALER WILL INSTALL THE HARDWARE AT NO COST TO THEM. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 19, 2008. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #08V279000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported June 25, 2008 · COACHMEN RV COMPANY, LLC

Potentially affected: 37,293 vehicles

Owners notified July 30, 2008 · Vehicles built June 1, 2003 – February 28, 2007 (per NHTSA)

Defect description

COACHMEN IS RECALLING 37,293 MOTORHOMES AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Manufacturer remedy

COACHMEN IS WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COACHMEN AT 574-825-5821.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL RAIL DAMPER RETAINER CLIP/WORKHORSE

NHTSA #06V352000 · Engine and Engine Cooling · NHTSA notice

Reported September 13, 2006 · COACHMEN RV COMPANY, LLC

Potentially affected: 1,332 vehicles

Vehicles built July 1, 2004 – August 31, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.

Safety consequence

IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.

Manufacturer remedy

WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR COACHMAN AT 219-825-8528.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

OVERHEAD TV CABINET

NHTSA #06V267000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 19, 2006 · COACHMEN RV COMPANY, LLC

Potentially affected: 1,485 vehicles

Owners notified July 24, 2006 · Vehicles built April 27, 2004 – July 6, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES, THE CABINET CONTAINING THE TELEVISION SET THAT IS INSTALLED IN THE OVERHEAD COCKPIT MAY BE INADEQUATELY SECURED.

Safety consequence

SHOULD THE CABINET FASTENERS FAIL, THE OVERHEAD TELEVISION CABINET AND TELEVISION SET MAY FALL AND COULD CONTACT THE WINDSHIELD, DRIVER, OR PASSENGER INCREASING THE RISK OF A CRASH OR PERSONAL INJURY.

Manufacturer remedy

DEALERS WILL INSPECT THE CABINETS AND MAKE THE NECESSARY REPAIRS. THE RECALL BEGAN ON JULY 24, 2006. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

INSTRUMENT CLUSTER/FMVSS 101 & 105/ WORKHORSE

NHTSA #05V089000 · Electrical System · NHTSA notice

Reported March 17, 2005 · GEORGIE BOY MFG., LLC

Potentially affected: 151 vehicles

Georgie BOY campaign 50402-C · Vehicles built August 27, 2002 – February 2, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 101, "CONTROLS AND DISPLAY" AND STANDARD NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." MODELS WITH ACTIA INSTRUMENT CLUSTER, THE INCORRECT SOFTWARE PROGRAMMED INTO THE CLUSTER SUCH THAT CERTAIN WARNINGS ARE NOT DISPLAYED.

Safety consequence

INCORRECT SOFTWARE MAY NOT HAVE THE ABILITY TO ILLUMINATE WARNING LAMPS INDICATING BRAKE SYSTEM FAILURES. THE STANDARDS REQUIRE DRIVER WARNING WHEN BRAKE FAILURE CODES ARE SET.

Manufacturer remedy

WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR GEORGIE BOY AT 877-876-9024.

Notes

WORKHORSE RECALL NO. 50402-C.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

GEORGIE BOY/FMVSS 104/WINDSHIELD WIPERS

NHTSA #04V587000 · Visibility — Windshield Wiper/Washer · NHTSA notice

Reported December 21, 2004 · GEORGIE BOY MFG., LLC

Potentially affected: 22 vehicles

Owners notified December 22, 2004 · Vehicles built June 1, 2004 – October 31, 2004 (per NHTSA)

Defect description

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEM." WHILE TRAVELING AT HIGH SPEEDS, THE WINDSHIELD WIPERS COULD EITHER SKIP ACROSS THE WINDSHIELD OR SWING TOO FAR OUTWARD CAUSING THE BLADE TO TRAVEL INTO THE RADIUS OF THE WINDSHIELD RESULTING IN THE SPLINE OF THE WIPER ARM AND THE SPINDLE TO FAIL. THE RESULT IS A WIPER STUCK IN THE OUT POSITION.

Safety consequence

SUCH A FAILURE OF THE WINDSHIELD WIPER SYSTEM COULD IMPAIR VISIBILITY AND COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE WINDSHIELD WIPER SYSTEM. THE RECALL BEGAN ON DECEMBER 22, 2004. OWNERS SHOULD CONTACT GEORGIE BOY AT 1-800-521-8733.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2005 Georgie BOY Cruise Master. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2005 Georgie BOY Cruise Master.

Service Brakes, Hydraulic

ODI #10350733

Incident: August 5, 2009 · Filed: August 20, 2010

TL* THE CONTACT OWNS A 2005 GEORGIE BOY CRUISE MASTER MOTOR HOME WITH A WORKHORSE CHASSIS. THE CONTACT WAS DRIVING 55-60 MPH WHEN HE APPLIED THE BRAKES AND THE PEDAL FELL ABNORMALLY FARTHER INTO THE FLOORBOARD THAN USUAL. ALL WARNING LIGHTS WERE ILLUMINATED AT THE TIME OF THE FAILURE. THE CONTACT WAS ABLE TO DRIVE TO HIS RESIDENCE AT RELATIVELY LOW SPEED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE WHEEL SPEED SENSORS WERE REPLACED AND THE BRAKE FLUID WAS FLUSHED. THE FAILURE RECURRED WITHIN EIGHT MONTHS. THE VEHICLE WAS TOWED AGAIN TO THE DEALER WHERE TWO REAR CALIPERS, WHEEL SENSORS, BRAKE PADS AND BRAKE FLUID WERE REPLACED. A BRAKE FLUSH WAS ALSO PERFORMED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V193000 (SERVICE BRAKES, HYDRAULIC: FLUID) BUT WAS UNABLE TO CONFIRM IF HIS VEHICLE WAS INCLUDED IN THE RECALL. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 22,500.

Equipment

ODI #10156280

Incident: April 4, 2005 · Filed: April 21, 2006

THE CONSUMER HAS HAD NUMEROUS PROBLEMS WITH HER GEORGIE BOY MOTORHOME. SOME OF THE PROBLEMS INCLUDE LOOSE DOOR LOCKS AND POP OUT WALL THAT WOULD NOT AUTOMATICALLY, ETC. *NM THE CONSUMER NOTICED GRAY WATER LEAKING FROM UNDER THE HOLDING TANK AND WAS FLOODING THE BACK BATHROOM. ON ONE OCCASION, THE MOTORHOME WOULD NOT START, IT WAS DISCOVERED THAT 5 BATTERY CABLES WERE NOT SECURED PROPERLY. WHILE DRIVING, THE WASHER/DRYER FELL OUT FROM ITS HOLDING AREA AND DAMAGED THE INSIDE WALL. THE SHOWER WAS LEAKING. THE STEPS OF THE MORE HOME HAD FALLEN OUT AND DAMAGED A MOTORIST TRUCK. THE CRUISE CONTROL WAS INOPERATIVE, THERE WAS EXCESSIVE AIR COMING FROM UNDER THE DASH PANEL. *JB

Fuel System, Gasoline

ODI #10142762

Incident: October 30, 2005 · Filed: November 15, 2005

DT: THE CONTACT STATES WHILE PERFORMING MAINTENANCE HE DISCOVERED THE FUEL LINE WAS RUBBING THE FLOOR OF THE RV. THE SHARP PART OF THE METAL FLOORING HAD BEGUN TO WEAR INTO THE FUEL LINE. HE DID NOT TAKE THE VEHICLE TO THE DEALER. HE PERFORMED PREVENTIVE MEASURES BY CUTTING BACK THE FLOOR BOARD AND ADDED INSULATION TO THE FUEL HOUSING AS WELL AS A RUBBER COATING. THERE HAVE BEEN NO FURTHER PROBLEMS SINCE THE REPAIR. THIS IS MANUFACTURED BY GEORGIE BOY AND THE MODEL IS A 2005 LANDOU LS. *NM

Other Georgie BOY Cruise Master model years

Check your 2005 Georgie BOY Cruise Master VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Georgie BOY Cruise Master at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Georgie BOY VIN