NHTSA vehicle safety data

2004 Georgie BOY Cruise Master Recalls & Complaints

The 2004 Georgie BOY Cruise Master has 3 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Georgie BOY dealer.

NHTSA recall and complaint data for the 2004 Georgie BOY Cruise Master. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Georgie BOY Cruise Master owner complaints

Owners have filed 2 complaints with NHTSA about the 2004 Georgie BOY Cruise Master, describing incidents dated August 15, 2012 to July 15, 2014.

Most-cited components

Equipment Adaptive/Mobility 1 complaint
Service Brakes 1 complaint

Together, the 2 complaints on file report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10637056 · Filed September 17, 2014
JUST SO HAPPENED WHEN WE PULLED INTO THE DRIVEWAY MY WIFE SAID THE BRAKES WENT OUT AND I THOUGHT NOTHING OF IT. I DUMPED MY SEWER AND WENT TO PULL UP INTO MY NORMAL PARKING PLACE AT MY PLACE OF RESIDENCE AND I HAD NO BRAKES AND ALMOST RAN INTO MY GARAGE. I PUMPED THEM SEVERAL TIME AND MANAGED TO…
ODI #10477311 · Filed September 27, 2012
TL* THE CONTACT OWNS A 2004 GEORGIE BOY CRUISE MASTER 3640 MOTOR HOME. THE CONTACT STATED THAT WHILE PARKED, THE BATHROOM SHOWER DOOR SHATTERED AFTER BEING CLOSED. THE FAILURE CAUSED THE CONTACT TO SUSTAIN LACERATIONS TO THE FOOT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE…

Read all 2 complaints

OVERHEATED BRAKE CALIPERS/BOSCH/WORKHORSE

NHTSA #09V193000 · Service Brakes, Hydraulic — Fluid · NHTSA notice

Reported June 2, 2009 · COACHMEN RV COMPANY, LLC

Potentially affected: 2,555 vehicles

Owners notified May 1, 2009 · Vehicles built August 1, 2000 – May 31, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

COACHMEN IS RECALLING 2,555 MY 2000-2009 GEORGIE BOY AND COACHMEN RECREATIONAL TRAILERS EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Safety consequence

THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR COACHMEN AT 1-574-266-4030, option 5.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SHOWER DOOR TOWEL BAR

NHTSA #08V639000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported December 4, 2008 · COACHMEN RV COMPANY, LLC

Potentially affected: 13,662 vehicles

Owners notified February 9, 2009 · Vehicles built June 15, 2001 – August 6, 2007 (per NHTSA)

Defect description

COACHMEN IS RECALLING 13,662 MY 2002-2008 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH GLASS SHOWER DOORS AND MANUFACTURED FROM JUNE 15, 2001 THORUGH AUGUST 6, 2007. WHEN PRESSURE IS APPLIED TO THE TOWEL BAR ON THE GLASS SHOWER DOOR, THE EDGE OF THE BAR MAY CONTACT THE GLASS.

Safety consequence

GLASS BREAKAGE MAY OCCUR WHICH COULD CAUSE PERSONAL INJURY.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH NEW MOUNTING HARDWARE FOR THE TOWEL BAR AND INSTALLATION INSTRUCTIONS. IF AN OWNER IS NOT COMFORTABLE REPLACING THE HARDWARE THEMSELVES, A DEALER WILL INSTALL THE HARDWARE AT NO COST TO THEM. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 19, 2008. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO WWW.SAFERCAR.GOV.

FUEL RAIL DAMPER RETAINER CLIP/WORKHORSE

NHTSA #06V352000 · Engine and Engine Cooling · NHTSA notice

Reported September 13, 2006 · COACHMEN RV COMPANY, LLC

Potentially affected: 1,332 vehicles

Vehicles built July 1, 2004 – August 31, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.

Safety consequence

IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.

Manufacturer remedy

WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR COACHMAN AT 219-825-8528.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2004 Georgie BOY Cruise Master. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2004 Georgie BOY Cruise Master.

Service Brakes

ODI #10637056

Incident: July 15, 2014 · Filed: September 17, 2014

JUST SO HAPPENED WHEN WE PULLED INTO THE DRIVEWAY MY WIFE SAID THE BRAKES WENT OUT AND I THOUGHT NOTHING OF IT. I DUMPED MY SEWER AND WENT TO PULL UP INTO MY NORMAL PARKING PLACE AT MY PLACE OF RESIDENCE AND I HAD NO BRAKES AND ALMOST RAN INTO MY GARAGE. I PUMPED THEM SEVERAL TIME AND MANAGED TO STOP. A HOLE HAD RUSTED THROUGH IN ONE SPOT WHERE AN OFFSET WAS BENT IN THE BRAKE LINE AND WHILE REPAIRING I FOUND ANOTHER SPOT RIGHT NEXT TO IT THAT I PUSHED A HOLE IN IT WITH MY POCKET KNIFE. LUCKILY IT HAPPENED IN THE DRIVEWAY AND NOT ON THE HIGHWAY WHERE WE HAD JUST CAME FROM A 200 MILE TRIP. *TR

Equipment Adaptive/Mobility

ODI #10477311

1 injury

Incident: August 15, 2012 · Filed: September 27, 2012

TL* THE CONTACT OWNS A 2004 GEORGIE BOY CRUISE MASTER 3640 MOTOR HOME. THE CONTACT STATED THAT WHILE PARKED, THE BATHROOM SHOWER DOOR SHATTERED AFTER BEING CLOSED. THE FAILURE CAUSED THE CONTACT TO SUSTAIN LACERATIONS TO THE FOOT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THE VIN FAILED TO QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 08V639000(EQUIPMENT:RECREATIONAL VEHICLE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 59,500.

Other Georgie BOY Cruise Master model years

Check your 2004 Georgie BOY Cruise Master VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Georgie BOY Cruise Master at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Georgie BOY VIN