try.vin
Log in

NHTSA vehicle safety data

2006 Freightliner FLD120 Recalls & Complaints

The 2006 Freightliner FLD120 has 2 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Freightliner dealer.

NHTSA recall and complaint data for the 2006 Freightliner FLD120. Recall data is refreshed daily from NHTSA.

2006 Freightliner FLD120 owner complaints

Owners have filed 1 complaint with NHTSA about the 2006 Freightliner FLD120, describing incidents dated January 21, 2013.

Most-cited components

  • Engine 1 complaint
  • Fuel/Propulsion System 1 complaint
  • Vehicle Speed Control 1 complaint

Newest complaints

  • ODI #10514247 · Filed

    CHECK ENGINE LIGHT CAME ON THEN TRACTOR STARTING LOOSING POWER. TOOK TO W.W. WILLIAMS DETROIT DIESEL. THEY FOUND DELTA P SENSOR OUT OF CALIBRATION. V-POD CUTTING OUT, TURBO HAD EXCESSIVE PLAY IN VNT. THEY REPLACED THE V-POD WHICH WAS UNDER WARRANTY. THE SAME PROBLEM OCCURRED IN MARCH 2013. PROBLEMS…

Read the full complaint

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Freightliner FLD120 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Open and recently closed NHTSA defect investigations

FIFTH WHEEL LEVER PIVOT BOLTS/HOLLAND SIMPLEX

NHTSA #07V530000 · Trailer Hitches — Fifth Wheel Assembly · NHTSA notice

Reported November 13, 2007 · FREIGHTLINER LLC

Potentially affected: 38,000 vehicles

Freightliner campaign FL-514 · Owners notified January 3, 2008 · Vehicles built January 1, 2006 – May 31, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRUCK-TRACTORS EQUIPPED WITH HOLLAND SIMPLEX SE OR SE II FIFTH WHEELS, THE LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER-TIGHTENED WHICH COULD DISTORT THE PIVOT BOLT SPACER SLEEVE. CORROSION OR CONTAMINATES IN THE PIVOT MAY CAUSE IT TO BIND AND PREVENT THE FIFTH WHEEL JAW FROM LATCHING SECURELY AROUND THE TRAILER KING PIN.

Safety consequence

THERE IS A POSSIBILITY THAT THE FIFTH WHEEL MAY FAIL TO LATCH WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THE OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER. THE RECALL BEGAN ON JANUARY 3, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-514.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

SR-7 SPRING BRAKE VALVE ASSEMBLY/BENDIX/PARKER

NHTSA #07V302000 · Service Brakes, Air — Supply — Check Valve · NHTSA notice

Reported July 16, 2007 · FREIGHTLINER LLC

Potentially affected: 75,000 vehicles

Freightliner campaign FL-504 · Owners notified January 11, 2008 · Vehicles built July 1, 2002 – July 3, 2007 (per NHTSA)

Defect description

CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.

Safety consequence

THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.

Manufacturer remedy

FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-504.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Other Freightliner FLD120 model years

Check your 2006 Freightliner FLD120 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Freightliner FLD120 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Freightliner VIN