NHTSA vehicle safety data

2000 Freightliner Columbia Recalls & Complaints

The 2000 Freightliner Columbia has 3 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Freightliner dealer.

NHTSA recall and complaint data for the 2000 Freightliner Columbia. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2000 Freightliner Columbia owner complaints

Owners have filed 1 complaint with NHTSA about the 2000 Freightliner Columbia, describing incidents dated March 22, 2006.

Most-cited components

Seat Belts 1 complaint

The complaint on file reports a crash, with 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10158770 · Filed June 1, 2006
IT HAPPEN IN INDIANAPOLIS, IN. ON HIGHWAY LOOP 465 NORTH BOUND WHEN MY CO-DRIVER REAR ENDED A SEMI-TRUCK, WE WERE DRIVING A FREIGHTLINER COLUMBIA TRUCK SEMI. I WAS IN THE BACK IN THE SLEEPER BUNK SLEEPING AND FACING THE WALL AND I WAS WEARING A STRAP DOWN BY THE SEAT BELT,LOOKS MORE LIKE A SAFETY…

Read the full complaint

NHTSA defect investigations

NHTSA's investigations file lists the 2000 Freightliner Columbia in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE03-005: FRONT BRAKE AIR HOSE LEAKS
Closed August 22, 2003
Preliminary Evaluation PE02-088: INTEGRAL HUB AND BEARING ASSEMBLY
Closed May 1, 2003

Open and recently closed NHTSA defect investigations

FREIGHTLINER/STERLING/FIFTH WHEELS/FATIGUE CRACKS

NHTSA #03V227000 · Trailer Hitches — Fifth Wheel Assembly · NHTSA notice

Reported June 17, 2003 · FREIGHTLINER CORPORATION

Potentially affected: 2,000 vehicles

Freightliner campaign FL-411 · Owners notified November 12, 2003 · Vehicles built September 3, 1999 – April 14, 2003 (per NHTSA)

Defect description

ON CERTAIN TRUCK TRACTORS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.

Safety consequence

IF LEFT UNDETECTED OR CORRECTED IT COULD LEAD TO THE SEPARATION OF THE FIFTH WHEEL TOP PLATE FROM ITS MOUNTING STRUCTURE, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE BRACKET PINS AND REPAIR INSTRUCTIONS FREE OF CHARGE. OWNER NOTIFICATION BEGAN NOVEMBER 12, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT JOST INTERNATIONAL AT 616-846-7700 OR BY EMAIL TO [email protected] OR FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-411.ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FREIGHTLINER/ARVINMERITOR/SKF/FRONT AXLE HUBS

NHTSA #03V112000 · Suspension — Front — Hub · NHTSA notice

Reported March 21, 2003 · FREIGHTLINER CORPORATION

Potentially affected: 5,716 vehicles

Freightliner campaign FL-407 · Owners notified September 20, 2003 · Vehicles built August 1, 1998 – February 28, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.

Safety consequence

SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.

Manufacturer remedy

DEALERS WILL REPLACE BOTH FRONT HUBS. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

Notes

FREIGHTLINER RECALL NO. FL-407.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FREIGHTLINER/ABS ECU

NHTSA #00V232002 · Service Brakes, Air — Antilock · NHTSA notice

Reported August 7, 2000 · FREIGHTLINER CORPORATION

Potentially affected: 35,405 vehicles

Freightliner campaign FL-266 · Owners notified August 29, 2000 · Vehicles built February 13, 1998 – August 3, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.

Safety consequence

THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE ABS ECU.

Notes

OWNER NOTIFICATION BEGAN AUGUST 29, 2000, TO SCHOOL BUSES AND EMERGENCY VEHICLE CUSTOMERS. OWNERS OF THE REMAINING POPULATION WERE SENT LETTERS ON SEPTEMBER 9, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2000 Freightliner Columbia. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2000 Freightliner Columbia.

Seat Belts

ODI #10158770

Crash 1 injury

Incident: March 22, 2006 · Filed: June 1, 2006

IT HAPPEN IN INDIANAPOLIS, IN. ON HIGHWAY LOOP 465 NORTH BOUND WHEN MY CO-DRIVER REAR ENDED A SEMI-TRUCK, WE WERE DRIVING A FREIGHTLINER COLUMBIA TRUCK SEMI. I WAS IN THE BACK IN THE SLEEPER BUNK SLEEPING AND FACING THE WALL AND I WAS WEARING A STRAP DOWN BY THE SEAT BELT,LOOKS MORE LIKE A SAFETY NET AND IT ONLY COVERS FROM THE CHEST TO MID-WAY OF MY KNEES AND DOESN'T COVER THE HEAD, THAT'S WHERE I RECEIVED ALL OF MY INJURIES. I HIT MY HEAD ON THE COUNTER TWICE THE TIME WAS WHEN THE DRIVER SLAMMED ON THE BRAKES I ROLLED OVER HITTING THE COUNTER, SECOND WHEN HE REAR ENDED THE SEMI AND I REALLY TRIED TO BRACE MYSELF TO PREVENT HITTING THE COUNTER I WAS NOT VERY SUCCESSFUL,CAUSE WHEN HE REAR ENDED IT WAS MORE OF A SURPRISE. BECAUSE OF THIS, I'M ON WORKERS COMPENSATION AND GOING ON C-SPINE TESTING AND PHYSICAL THERAPY AND I AM STILL IN A LOT OF PAIN EVEN WITH MEDICATION AND LOST OF WAGES. I REALLY NOTICED THAT THE SEAT BELT OR STRAP DOESN'T PROTECT THE HEAD WHICH I DEEPLY IN MY HEART FEELS IT SHOULD PROTECT THE HEAD AND FOR ANY REASON THAT THIS SAFETY BELT IS NOT MADE TO SAFELY PROTECT THE PERSON SLEEPING IN THE BUNK OR NOT MADE FOR IT. THEN THEY SHOULD BAN TEAM DRIVING, BECAUSE IT IS NOT SAFE AND IT WILL NOT PROTECT THE OTHER DRIVER SLEEPING. THAT IS VERY DANGEROUS,COSTLY, BODY INJURY INCREASE, DISABILITY,COSTLY INSURANCE FOR CO. AND DRIVERS AND TIME CONSUMING ALL AROUND, BUT EVEN MORE SADLY NOT BEING ABLE TO PLAY,RUN OR DOING ANY FUN ACTIVITIES WITH YOUR KIDS, THAT'S WERE IT REALLY HURTS. THESE SEATBELT OR STRAP( NET) SHOULD BE REDESIGNED OR MODIFIED TO PROTECT THE PERSON SLEEPING AND ABLE TO COME HOME WELL AND ABLE TO ENJOY HIS FAMILY AND IF THIS STRAP IS NOT MADE FOR THIS PURPOSE THEN WE SHOULD STOP TEAM DRIVERS. THEY SHOULD ONLY HAVE ONE DRIVER DRIVING. WHAT I LIKE TO KNOW WHO IS AT FAULT IN LETTING US KNOW THAT THIS SEAT BELT OR STRAP IS NOT MADE TO PROTECT THE PERSON SLEEPING AND NOBODY SHOULD BE BACK THERE AT ALL. *JB

Other Freightliner Columbia model years

Check your 2000 Freightliner Columbia VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Freightliner Columbia at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Freightliner VIN