NHTSA vehicle safety data
2005 Freightliner Century ST Recalls & Complaints
The 2005 Freightliner Century ST has 6 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Freightliner dealer.
NHTSA recall and complaint data for the 2005 Freightliner Century ST. Recall data is refreshed daily from NHTSA.
2005 Freightliner Century ST owner complaints
Owners have filed 1 complaint with NHTSA about the 2005 Freightliner Century ST, describing incidents dated April 21, 2007.
Most-cited components
- Engine 1 complaint
Newest complaints
ODI #10192033 · Filed
TL*THE CONTACT OWNS A 2005 FREIGHTLINER CENTURY ST. ON APRIL 14, 2007, THE CONTACT EXPERIENCED NAUSEA, VOMITING, HALLUCINATIONS, DIZZINESS, AND BAD HEADACHES WHILE DRIVING DUE TO EMISSIONS AND EXHAUST LEAKS IN THE VEHICLE. WHEN A BREAK DOWN TECHNICIAN ARRIVED, HE STATED THAT THERE WERE THREE HOLES…
NHTSA defect investigations
NHTSA's investigations file lists the 2005 Freightliner Century ST in 4 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.
- Preliminary Evaluation PE09-040: RACK AND PINION FAILURE
Closed November 19, 2009
- Preliminary Evaluation PE08-009: POWER STEERING PUMP FAILURES
Closed July 3, 2008
- Engineering Analysis EA07-002: STEERING COLUMN WELD CRACKS
Closed July 12, 2007
- Preliminary Evaluation PE06-033: STEERING COLUMN WELD CRACKS
Closed January 30, 2007
FRONT AXLE STEERING STOPS
NHTSA #07V403000 · Steering — Linkages — Tie Rod Assembly · NHTSA notice
Reported September 6, 2007 · FREIGHTLINER LLC
Potentially affected: 450 vehicles
Freightliner campaign FL-513 · Owners notified July 8, 2008 · Vehicles built November 1, 2004 – August 31, 2007 (per NHTSA)
Defect description
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE BALL SOCKET ASSEMBLY AT THE INNER END OF THE DRIVER SIDE TIE ROD MAY BE DAMAGED IN A SHARP TURN. EXCESSIVE TIE ROD ANGLES MAY LOOSEN THE TIE ROD IN THE BALL SOCKET OR DAMAGE THE THREADED TIE ROD SOCKET ATTACHMENT TO THE STEERING RACK ON THE DRIVER SIDE. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.
Safety consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.
Manufacturer remedy
DEALERS WILL CHANGE THE FRONT AXLE STEERING STOPS TO PREVENT INTERFERENCE IN THE TIE ROD BALL SOCKET ASSEMBLY AND STEERING COMPONENTS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 8, 2008, AND WILL BE MAILED IN PHASES THROUGH DECEMBER 31, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
Notes
FREIGHTLINER RECALL NO. FL-513. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
STEERING ARM INSTALLATION
NHTSA #07V400000 · Steering — Linkages — Tie Rod Assembly · NHTSA notice
Reported September 5, 2007 · FREIGHTLINER LLC
Potentially affected: 413 vehicles
Freightliner campaign FL-512 · Owners notified May 1, 2008 · Vehicles built November 1, 2004 – August 31, 2007 (per NHTSA)
Defect description
ON CERTAIN TRUCKS EQUIPPED WITH RACK AND PINION STEERING, THE TIE ROD ARMS MAY HAVE BEEN INCORRECTLY INSTALLED. THE THREADED END OF THE BALL SOCKET ASSEMBLY MAY FRACTURE AND SEPARATE.
Safety consequence
A FRACTURED TIE ROD ASSEMBLY WILL MAKE THE VEHICLE MORE DIFFICULT TO CONTROL AT HIGHER SPEEDS AND A CRASH MAY OCCUR.
Manufacturer remedy
DEALERS WILL INSPECT FOR INSTALLATION OF THE STEERING ARMS. STEERING COMPONENTS WILL BE REPLACED ON TRUCKS THAT HAVE INCORRECTLY INSTALLED TIE ROD ARMS. THE RECALL BEGAN ON MAY 1, 2008. OWNER MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
Notes
FREIGHTLINER RECALL NO. FL-512.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
SR-7 SPRING BRAKE VALVE ASSEMBLY/BENDIX/PARKER
NHTSA #07V302000 · Service Brakes, Air — Supply — Check Valve · NHTSA notice
Reported July 16, 2007 · FREIGHTLINER LLC
Potentially affected: 75,000 vehicles
Freightliner campaign FL-504 · Owners notified January 11, 2008 · Vehicles built July 1, 2002 – July 3, 2007 (per NHTSA)
Defect description
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
Safety consequence
THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.
Manufacturer remedy
FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Notes
FREIGHTLINER RECALL NO. FL-504.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
DOUGLAS AUTOTEC STEERING COLUMN MISSING WELDS
NHTSA #07V289000 · Steering — Column · NHTSA notice
Reported July 3, 2007 · FREIGHTLINER LLC
Potentially affected: 25,643 vehicles
Freightliner campaign FL-503 · Owners notified August 30, 2007 · Vehicles built October 23, 2004 – March 21, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
CERTAIN FREIGHTLINER SCHOOL BUSES AND TRUCKS MANUFACTURED FROM OCTOBER 23, 2004, TO MARCH 21, 2006. DURING THE STEERING COLUMN MANUFACTURING PROCESS TWO WELDS MAY HAVE BEEN MISSING.
Safety consequence
COLUMNS WITH TWO WELDS MISSING MAY FATIGUE AND FRACTURE AND ALLOW THE STEERING WHEEL TO PROGRESSIVELY BE MOVED OUT OF ITS NORMAL POSITION WHICH MAY CAUSE THE STEERING TO RESPOND DIFFERENTLY THAN EXPECTED. IF THIS CONDITION IS IGNORED, A CRASH MAY OCCUR.
Manufacturer remedy
FREIGHTLINER WILL NOTIFY OWNERS AND INSPECT AND REPAIR THE AFFECTED VEHICLE FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Notes
FREIGHTLINER RECALL NO. FL-503.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
ARVINMERITOR REAR AXLE HOUSING
NHTSA #05V467000 · Suspension — Rear — Axle — Spindle · NHTSA notice
Reported October 5, 2005 · FREIGHTLINER LLC
Potentially affected: 1,100 vehicles
Freightliner campaign FL-460 · Owners notified April 11, 2006 · Vehicles built June 13, 2005 – July 8, 2005 (per NHTSA)
Defect description
CERTAIN 2005 THOMAS BUILT FS-65 AND C-2 SCHOOL BUSES AND 2005 FREIGHTLINER ARGOSY, COLUMBIA, CENTURY ST, AND M2 BUSINESS CLASS TRUCKS MANUFACTURED BETWEEN JUNE 4 AND JULY 8, 2005. THE SPINDLES IN THE REAR AXLE HOUSING WERE OVERHEATED DURING THE HEAT TREATMENT PROCESS. INCORRECTLY HEAT TREATED SPINDLES COULD RESULT IN A FRACTURE OF THE SPINDLE.
Safety consequence
INCORRECTLY HEAT TREATED SPINDLES COULD FRACTURE, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Manufacturer remedy
FREIGHTLINER WILL NOTIFY ITS CUSTOMERS AND INSPECT FOR THE HEAT TREAT DATE CODE ON THE END OF THE REAR SPINDLES AND REPLACE THE AXLE HOUSING IF NECESSARY. THE RECALL IS EXPECTED TO BEGIN ON JANUARY 23, 2006. OWNERS MAY CONTACT FREIGHTLINER
Notes
FREIGHTLINER RECALL NO. FL-460.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY:1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
ALUMINUM WHEELS/ACCURIDE
NHTSA #05V185000 · Wheels · NHTSA notice
Reported April 27, 2005 · FREIGHTLINER LLC
Potentially affected: 3,500 vehicles
Freightliner campaign FL-448 · Owners notified October 21, 2005 · Vehicles built February 20, 2005 – March 20, 2005 (per NHTSA)
Defect description
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH ACCURIDE ALUMINUM WHEELS, THE WHEELS WERE NOT PROPERLY PRE-STRESSED. THIS ALLOWS CRACKS TO DEVELOP OVER TIME.
Safety consequence
THIS MAY EVENTUALLY LEAD TO WHEEL FAILURE AND POSSIBLY RESULT IN A VEHICLE CRASH.
Manufacturer remedy
DEALERS WILL REPLACE THE WHEELS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
Notes
FREIGHTLINER RECALL NO. FL-448.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
Other Freightliner Century ST model years
Check your 2005 Freightliner Century ST VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Freightliner Century ST at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Freightliner VIN