NHTSA vehicle safety data

2011 Ford F-750 Recalls & Complaints

The 2011 Ford F-750 has 3 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2011 Ford F-750. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2011 Ford F-750 owner complaints

Owners have filed 2 complaints with NHTSA about the 2011 Ford F-750, describing incidents dated April 30, 2012 to June 18, 2015.

Most-cited components

Service Brakes 1 complaint
Structure 1 complaint

Of the 2 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10726663 · Filed June 22, 2015
THIS VEHICLE WAS USED AS A MOBILE MEDICAL UNIT FOR RESEARCH. TWO STAFF MEMBERS WERE IN THE CAB EN ROUTE TO A STUDY VISIT - BOTH WERE FAMILIAR DRIVERS OF THE VEHICLE. APPROXIMATELY 9 MILES INTO THE TRIP A PASSERBY ON THE INTERSTATE FLAGGED US DOWN AND WANTED US TO PULL OVER AND INFORMED US THAT THE…
ODI #10462405 · Filed June 20, 2012
TL* THE CONTACT OWNS A 2011 FORD F-750. THE CONTACT STATED THAT THE VEHICLE'S HEADLINER WAS TOO LOW AND A NORMAL SIZED PERSON WAS UNABLE TO OPERATE THE VEHICLE WITHOUT HITTING THEIR HEAD ON IT. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DECIDED TO LOWER THE SEAT HEIGHT AS A TEMPORARY REMEDY, WHICH…

Read all 2 complaints

Sure Power DC-DC Converters:Fire Risk

NHTSA #14V186000 · Electrical System — 12V/24V/48V Battery · NHTSA notice

Reported April 8, 2014 · DUECO Inc.

Potentially affected: 34 vehicles

Owners notified May 29, 2014 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DUECO Inc. (DUECO), a manufacturer of utility vehicles, is recalling certain Dueco-modified model year 2009-2011 International 4300, 2010 International 4400, 2009 and 2011 International 7400, 2010 Freightliner M2, 2008-2009 GMC C5500, and 2011 Ford F-750 vehicles, equipped with Sure Power DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.

Safety consequence

Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.

Manufacturer remedy

DUECO will notify owners, and Sure Power will replace the converters, free of charge. The recall began on May 29, 2014. Owners may contact Dueco at 1-800-558-4004.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

SERVICE BRAKES/TRACTION RELAY VALVE

NHTSA #12V097000 · Service Brakes, Air — Supply — Check Valve · NHTSA notice

Reported March 7, 2012 · FORD MOTOR COMPANY

Potentially affected: 352 vehicles

Ford campaign 12S28 · Owners notified April 12, 2012 · Vehicles built December 3, 2010 – December 20, 2011 (per NHTSA)

Defect description

FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-650 AND F-750 TRUCKS, MANUFACTURED FROM DECEMBER 3, 2010, THROUGH DECEMBER 20, 2011, EQUIPPED WITH BENDIX ATR-6 ANTILOCK TRACTION RELAY VALVES. IN EXTREMELY COLD CONDITIONS, THE BENDIX RELAY VALVES MAY POTENTIALLY DEVELOP INTERNAL LEAKAGE. INTERNAL LEAKAGE CAN LEAD TO AIR PRESSURE BEING DELIVERED TO AFFECTED PRIMARY OR SECONDARY BRAKE CAUSING CONTINUOUS BRAKE APPLICATION.

Safety consequence

UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE BRAKES TO OVERHEAT AND LEAD TO A FIRE. UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH. ALSO, THE BRAKES MAY BE APPLIED WITHOUT ILLUMINATING THE BRAKE LIGHTS, FAILING TO GIVE PROPER WARNING TO OTHER DRIVERS.

Manufacturer remedy

FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A BENDIX ATR-6 TRACTION RELAY VALVE KIT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY AT 1-800-392-3673.

Notes

FORDS RECALL NUMBER IS 12S28.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AIR BRAKES MODULE REPLACEMENT/FMVSS 121

NHTSA #11V264000 · Service Brakes, Air — Antilock — Control Unit/Module · NHTSA notice

Reported May 3, 2011 · FORD MOTOR COMPANY

Potentially affected: 93 vehicles

Ford campaign 11C17 · Owners notified May 18, 2011 · Vehicles built December 10, 2010 – March 2, 2011 (per NHTSA)

Defect description

FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-650 AND F-750 TRUCKS, EQUIPPED WITH AIR BRAKES AND A TRAILER PACKAGE OR TRACTOR PACKAGE, FOR AN INCORRECTLY PROGRAMMED ABS MODULE. AS SUCH, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS (ABS)."

Safety consequence

AN AFFECTED VEHICLE MAY NOT DISPLAY A TRAILER ABS FAULT IN THE CAB OF THE TRUCK WARNING THE DRIVER OF AN EXISTING TRAILER ABS FAILURE. SUCH AN ABS FAILURE MAY RESULT IN TRAILER BRAKE LOCK-UP, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL NOTIFY OWNERS AND REPLACE THE ABS MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Notes

FORD SAFETY RECALL NO. 11C17.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2011 Ford F-750. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2011 Ford F-750.

Service Brakes, Air

ODI #10726663

Fire

Incident: June 18, 2015 · Filed: June 22, 2015

THIS VEHICLE WAS USED AS A MOBILE MEDICAL UNIT FOR RESEARCH. TWO STAFF MEMBERS WERE IN THE CAB EN ROUTE TO A STUDY VISIT - BOTH WERE FAMILIAR DRIVERS OF THE VEHICLE. APPROXIMATELY 9 MILES INTO THE TRIP A PASSERBY ON THE INTERSTATE FLAGGED US DOWN AND WANTED US TO PULL OVER AND INFORMED US THAT THE BACK WHEELS WERE ON FIRE. WITHOUT THE PASSERBY, WE WOULD NOT HAVE KNOW ANYTHING WAS WRONG. THERE WERE NO INDICATOR LIGHT WARNINGS AND THE VEHICLE DID NOT SEEM TO BE DRIVING DIFFERENT THAN USUAL. WE PULLED OVER, CALLED 911 FOR ASSISTANCE AND USED A FIRE EXTINGUISHER WE HAD ON BOARD TO DOUSE THE FLAMES. TWO OTHER TRUCKERS STOPPED AND ASSISTED US, BRINGING THEIR FIRE EXTINGUISHERS TO OUR AID. THE LOCAL FIRE DEPARTMENT ARRIVED AND GOT THE FIRE COMPLETELY EXTINGUISHED. THE VEHICLE HAS A DIESEL POWERED ENGINE AND AIR BRAKES. IT ALSO HAS A HYDRAULIC LEVELING SYSTEM TO STABILIZE THE UNIT WHILE AT STUDY VISITS. THERE WERE TWO LOUD POPPING NOISES WITHIN MINUTES OF EACH OTHER AT ONE POINT. THE PARTICULAR VIN FOR THIS VEHICLE DOES NOT HAVE ANY RECALLS, BUT I HAVE READ ABOUT 2 RECALLS THAT INVOLVE AIR BRAKES ON FORD F750 2011 VEHICLES. (NHTSA CAMPAIGN NUMBER: 12V097000 COMPONENT(S): SERVICE BRAKES, AIR AND NHTSA CAMPAIGN NUMBER: 11V264000 COMPONENT(S): SERVICE BRAKES, AIR). THERE WERE NO BODILY INJURIES IN THIS EVENT, BUT A GREAT DEAL OF EQUIPMENT DAMAGE. IT WAS CATEGORIZED AS A ROADSIDE ASSIST, NOT AN ACCIDENT, SO THERE IS NO ACCIDENT REPORT. ...UPDATED08/20/15 *BF UPDATED 11/30/2015 *JS

Structure

ODI #10462405

Incident: April 30, 2012 · Filed: June 20, 2012

TL* THE CONTACT OWNS A 2011 FORD F-750. THE CONTACT STATED THAT THE VEHICLE'S HEADLINER WAS TOO LOW AND A NORMAL SIZED PERSON WAS UNABLE TO OPERATE THE VEHICLE WITHOUT HITTING THEIR HEAD ON IT. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DECIDED TO LOWER THE SEAT HEIGHT AS A TEMPORARY REMEDY, WHICH FAILED TO REPAIR THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100 AND THE CURRENT MILEAGE WAS 4,000.

Other Ford F-750 model years

Check your 2011 Ford F-750 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford F-750 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN